Kia Carnival (2007 year). Instruction — part 249

2007 > 2.7L V6 GASOLINE >

TROUBLESHOOTING

Symptom

Suspect Area

Remedy (See page)

Water leaks from sunroof

Dirt accumulated in drain tube

Clear dirt inside of drain

Clogged drain tube

Blow air into drain to remove dirt

Broken or dislocated drain tube, defective
Or cracked clip

Check tube installation and
Flange contact

Deteriorated roof lid weatherstrip

Replace

Excessive roof lid-to-body clearance and
Improperly fitted weatherstrip

Adjust

Wind noise around sunroof

Loose or deformed deflector, gaps
In body work

Retighten adjust or replace

Sunroof lid makes a noise when
moveing

Foreign particles lodged in guide rail

Check drive cable and guide
Rails for foreign particles

Loose guide rails and lid

Retighten

Motor runs but sunroof does not
move or moves only partially

Foreign particles lodged in guide rail

Check drive cable and guide
Rails for foreign particles

Incorrect engagement of motor pinion
With drive cable

Check for loose motor installation
And damaged pinion

Decrease in motor`s clutch slipping force

Adjust

Increased sunroof sliding resistance
Or interference of sunroof with drive
cables, weatherstrip, etc. due to
maladjustment of sunroof

Adjust or replace

Noise in motor (clutch slipping
Noise from motor when sunroof
Is fully opened or closed is not
An unusual noise

Incorrect engagement of motor pinion
With drive cable

Check pinion installation and
Retighten motor

Worn out or damaged motor pinion bearing

Replace motor assembly

Worn out or deformed drive cable

Replace

Door glass fails to operate
Up and down

Incorrect window glass installation

Adjust position

Damaged or faulty regulator arm or regulator

Correct or replace

Door does not open or close
completely

Incorrect door installation

Adjust position

Defective door check assembly

Correct or replace

Door hinge requires grease

Apply grease

Hood does not open or close
completely

Striker and latch not properly aligned

Adjust

Incorrectly installed hood

Adjust

Incorrect hood bumper height

Adjust

Water leak through windshield
end rear window

Defective seal

Fill with sealant

Defective flange

Correct

2007 > 2.7L V6 GASOLINE >

SPECIFICATIONS

HOOD

Type

Rear hinged, gas lifter type

REAR DOOR

Construction
Regulator system
Locking system

Front hinged, full door construction
X-ARM type
Pin-fork system

FRONT DOOR

Construction
Regulator system
Locking system

Sliding door construction
Wire drum type
Pin-fork system

TAILGATE

Type

Inner hinged, gas lifter type

GLASS

THICKNESS

Windshield glass
Front door glass
Rear door glass
Rear window glass

5mm
4mm
4mm
3.5mm

SEAT BELTS

Front
Rear

3 point type with Emergency Locking Retractor
(E.L.R)
3 point type with Emergency Locking Retractor
(E.L.R)

TIGHTENING TORQUE

Items

N.m

Kgf.m

Lbf.ft

Front and rear doors

Door hinge to body
Door hinge to door
Striker
Glass mounting bolt
Outside handle mounting bolt
Rear channel mounting nut

33.3~41.2
21.6~26.5

6.9~10.8
7.8~11.8
6.9~10.8
7.8~11.8

3.4~4.2
2.2~2.7
0.7~1.1
0.8~1.2
0.7~1.1
0.8~1.2

24.6~30.4
15.9~19.5

5.1~8.0
5.8~8.7
5.1~8.0
5.8~8.7

Tailgate

Tailgate hinge to body
Tailgate hinge to tailgate
Tailgate lift mounting bolt
Key cylinder mounting nut

6.9~8.8
6.9~8.8
6.9~8.8

6.9~10.8

0.7~0.9
0.7~0.9
0.7~0.9
0.7~1.1

5.1~6.5
5.1~6.5
5.1~6.5
5.1~8.0

Hood

Hood hinge to body
Hood hinge to hood
Hood latch to body

21.6~26.5
21.6~26.5

6.9~10.8

2.2~2.7
2.2~2.7
0.7~1.1

15.9~19.5
15.9~19.5

5.1~8.0

Seat

Front seat mounting bolts
Rear seat mounting bolts

43.1~64.7
43.1~64.7

4.4~6.6
4.4~6.6

31.8~47.7
31.8~47.7

Seat belt

Front seat belt height adjuster
Front seat belt buckle
mounting bolt
Front seat belt anchor
mounting bolt
Front seat belt lower anchor
Front seat belt upper anchor
Rear seat belt anchor
attaching bolt
Rear seat belt retractor
mounting bolt

39.2~53.9
39.2~53.9
39.2~53.9
39.2~53.9
39.2~53.9
39.2~53.9
39.2~53.9

4.0~5.5
4.0~5.5
4.0~5.5
4.0~5.5
4.0~5.5
4.0~5.5
4.0~5.5

28.9~39.8
28.9~39.8
28.9~39.8
28.9~39.8
28.9~39.8
28.9~39.8
28.9~39.8

Exterior

Fender