Mazda Mazdaspeed 3 (2013 year). Manual — part 29
Keep all flames, including cigarettes, and sparks away from open battery cells:
Flames and sparks near open battery cells are dangerous. Hydrogen gas, produced
during normal battery operation, could ignite and cause the battery to explode. An
exploding battery can cause serious burns and injuries.
Do not jump-start a frozen battery or one with a low fluid level:
Jump-starting a frozen battery or one with a low fluid level is dangerous. It may
rupture or explode, causing serious injury.
Connect the negative cable to a good ground point away from the battery:
Connecting the end of the second jumper cable to the negative ( ) terminal of the
discharged battery is dangerous.
A spark could cause the gas around the battery to explode and injure someone.
Route the jumper cables away from parts that will be moving:
Connecting a jumper cable near or to moving parts (cooling fans, belts) is dangerous.
The cable could get caught when the engine starts and cause serious injury.
CAUTION
Use only a 12 V booster system. You can damage a 12 V starter, ignition system, and
other electrical parts beyond repair with a 24 V power supply (two 12 V batteries in
series or a 24 V motor generator set).
SKYACTIV-G 2.0
Connect cables in numerical order and disconnect in reverse order.
Booster battery
Discharged battery
Jumper cables
7-20
In Case of an Emergency
Emergency Starting
MZR 2.0, MZR 2.3 DISI Turbo and MZR 2.5
Connect cables in numerical order and disconnect in reverse order.
Booster battery
Discharged battery
Jumper cables
In Case of an Emergency
Emergency Starting
7-21
1. Remove the battery cover from its front
side.
Battery cover
CAUTION
Ø Do not use a tool which applies
excessive force such as a
screwdriver or pliers.
If excessive force is applied to the
clips, they could be damaged.
To prevent damaging the battery
cover, remove the battery cover
using the following procedure.
1 Detach the clip facing the side of
the vehicle first and pull it outward
with your finger approx. 4 mm (0.2
in). Then, lift the cover slightly to
clear the lock.
Clip
2 Detach the clip facing the vehicle
interior first and pull it outward
with your finger approx. 4 mm (0.2
in). Then, lift the cover slightly to
clear the lock.
Clip
3 Pull out the battery cover being
careful not to allow it to contact
the cowl grille.
Battery cover
Cowl grille
2. Make sure the booster battery is 12 V
and that its negative terminal is
grounded.
3. If the booster battery is in another
vehicle, don't allow both vehicles to
touch. Turn off the engine of the
vehicle with the booster battery and all
unnecessary electrical loads in both
vehicles.
7-22
In Case of an Emergency
Emergency Starting
4. Connect the jumper cables in the exact
sequence as in the illustration.
l
Connect one end of a cable to the
positive terminal on the discharged
battery (1).
l
Attach the other end to the positive
terminal on the booster battery (2).
l
Connect one end of the other cable
to the negative terminal of the
booster battery (3).
l
Connect the other end to the ground
point indicated in the illustration
away from the discharged battery
(4).
5. Start the engine of the booster vehicle
and run it a few minutes. Then start the
engine of the other vehicle.
6. When finished, carefully disconnect the
cables in the reverse order described in
the illustration.
7. Install the battery cover.
CAUTION
Ø Do not use a tool which applies
excessive force such as a
screwdriver or pliers.
If excessive force is applied to the
clips, they could be damaged.
To prevent damaging the battery
cover, install the battery cover
using the following procedure.
1 Being careful not to contact the
cowl grille, insert the tabs on the
one end of the battery cover into
the holes of the battery tray and
engage the tabs.
Cowl grille
Tab
Hole
SKYACTIV-G 2.0
Cowl grille
Tabs
Holes
MZR 2.0, MZR 2.3 DISI Turbo
and MZR 2.5
2 Attach the clips on both sides of
the battery cover.
Clips
In Case of an Emergency
Emergency Starting
7-23
NOTE
Verify that the covers are securely installed.
Push-Starting
Do not push-start your Mazda.
WARNING
Never tow a vehicle to start it:
Towing a vehicle to start it is
dangerous. The vehicle being towed
could surge forward when its engine
starts, causing the two vehicles to
collide. The occupants could be
injured.
CAUTION
Do not push-start a vehicle that has
a manual transaxle. It can damage
the emission control system.
NOTE
You can't start a vehicle with an automatic
transaxle by pushing it.
7-24
In Case of an Emergency
Emergency Starting
Towing Description
We recommend that towing be done only
by an Authorized Mazda Dealer or a
commercial tow-truck service.
Proper lifting and towing are necessary to
prevent damage to the vehicle.
Government and local laws must be
followed.
A towed vehicle usually should have its
drive wheels (front wheels) off the
ground. If excessive damage or other
conditions prevent this, use wheel dollies.
Wheel dollies
When towing with the rear wheels on the
ground, release the parking brake.
CAUTION
Do not tow the vehicle pointed
backward with driving wheels on the
ground. This may cause internal
damage to the transaxle.
CAUTION
Do not tow with sling-type
equipment. This could damage your
vehicle. Use wheel-lift or flatbed
equipment.
In Case of an Emergency
Emergency Towing
7-25
Tiedown Hook
CAUTION
Do not use the front and rear
tiedown eyelets for towing the
vehicle.
They have been designed only for
securing the vehicle to a transport
vessel during shipping.
Using the eyelets for any other
purpose could result in the vehicle
being damaged.
qTiedown Hook-Front
Type A
1. Remove the tiedown eyelet and the lug
wrench from the trunk (page 7-3).
2. Wrap the lug wrench with a soft cloth
to prevent damage to the bumper and
remove the cover located on the front
bumper.
NOTE
Remove the cover completely and store it so as
not to lose it.
3. Securely install the tiedown eyelet
using the lug wrench.
Lug wrench
4. Hook the tying rope to the tiedown
eyelet.
CAUTION
Ø If the tiedown eyelet is not securely
tightened, it may loosen or
disengage from the bumper when
tying down the vehicle. Make sure
that the tiedown eyelet is securely
tightened to the bumper.
Ø The front tiedown hook is
designed only for lashing the
vehicle during overseas transport.
Do not use the front tiedown hook
for any other use such as
transporting the vehicle on trucks
or railway.
7-26
In Case of an Emergency
Emergency Towing
Type B
1. Remove the tiedown eyelet from the
trunk (page 7-3).
2. Remove the cover.
NOTE
Remove the cover completely and store it so as
not to lose it.
3. Securely install the tiedown eyelet
using the lug wrench.
Lug wrench
4. Hook the tying rope to the tiedown
eyelet.
CAUTION
Ø If the tiedown eyelet is not securely
tightened, it may loosen or
disengage from the bumper when
tying down the vehicle. Make sure
that the tiedown eyelet is securely
tightened to the bumper.
Ø The front tiedown hook is
designed only for lashing the
vehicle during overseas transport.
Do not use the front tiedown hook
for any other use such as
transporting the vehicle on trucks
or railway.
In Case of an Emergency
Emergency Towing
7-27
qTiedown Hook-Rear
Tiedown hook
CAUTION
The rear tiedown hook is designed
only for lashing the vehicle during
overseas transport. Do not use the
rear tiedown hook for any other use
such as transporting the vehicle on
trucks or railway.
Recreational Towing
An example of
“recreational towing” is
towing your vehicle behind a motorhome.
The transaxle is not designed for towing
this vehicle on all 4 wheels.
When doing recreational towing refer to
“Towing Description” (page 7-25) and
“Tiedown Hook” (page 7-26) and
carefully follow the instructions.
7-28
In Case of an Emergency
Emergency Towing
8
Maintenance and Care
How to keep your Mazda in top condition.
Introduction . . . . . . . . . . . . . . . . . . . . .. 8-2
Introduction . . . . . . . . . . . . . . . . . . . ... 8-2
Scheduled Maintenance . . . . . . . . . . . . . . . . 8-4
Scheduled Maintenance (USA, Canada, and Puerto Rico) . ... 8-4
Scheduled Maintenance (Mexico) . . . . . . . . . . . . 8-9
Owner Maintenance . . . . . . . . . . . . . . . . ... 8-16
Owner Maintenance Schedule . . . . . . . . . . . . 8-16
Owner Maintenance Precautions . . . . . . . . . . . . 8-17
Engine Compartment Overview . . . . . . . . . . . .. 8-19
Engine Oil . . . . . . . . . . . . . . . . . . . ... 8-21
Engine Coolant . . . . . . . . . . . . . . . . . ... 8-25
Brake/Clutch Fluid . . . . . . . . . . . . . . . . .. 8-27
Power Steering Fluid . . . . . . . . . . . . . . . ... 8-27
Automatic Transaxle Fluid (ATF)
í
. . . . . . . . . . 8-28
Washer Fluid . . . . . . . . . . . . . . . . . . ... 8-29
Body Lubrication . . . . . . . . . . . . . . . . . 8-30
Wiper Blades . . . . . . . . . . . . . . . . . . ... 8-31
Battery . . . . . . . . . . . . . . . . . . . . . . 8-35
Tires . . . . . . . . . . . . . . . . . . . . . . 8-39
Light Bulbs . . . . . . . . . . . . . . . . . . . . 8-46
Fuses . . . . . . . . . . . . . . . . . . . . . ... 8-58
Appearance Care . . . . . . . . . . . . . . . . . . 8-65
How to Minimize Environmental Paint Damage . . . . . 8-65
Exterior Care . . . . . . . . . . . . . . . . . . ... 8-67
Interior Care . . . . . . . . . . . . . . . . . . . 8-71
8-1
í
Some models.
Introduction
Be extremely careful and prevent injury to yourself and others or damage to your vehicle
when using this manual for inspection and maintenance.
If you are unsure about any procedure it describes, we strongly urge you to have a reliable
and qualified service shop perform the work, preferably an Authorized Mazda Dealer.
Factory-trained Mazda technicians and genuine Mazda parts are best for your vehicle.
Without this expertise and the parts that have been designed and made especially for your
Mazda, inadequate, incomplete, and insufficient servicing may result in problems. This
could lead to vehicle damage or an accident and injuries.
For expert advice and quality service, consult an Authorized Mazda Dealer.
To continue warranty eligibility and to protect your investment, it is your responsibility to
properly maintain your vehicle according to factory recommended schedules outlined in
this manual. As part of this you must keep your maintenance records, receipts, repair orders
and any other documents as evidence this maintenance was performed. You must present
these documents, should any warranty coverage disagreement occur. Failure to do so can
result in your warranty being voided either in whole or in part.
This evidence may consist of the following:
l
The Mazda Scheduled Maintenance Record, refer to the Warranty Booklet, must be
completely filled out showing mileage, repair order number, date for each service, and
signed by a qualified automotive service technician who service vehicles.
l
Original copies of repair orders or other receipts that include the mileage and date the
vehicle was serviced. Each receipt should be signed by a qualified automotive service
technician.
l
For self maintenance, a statement that you completed the maintenance yourself,
displaying mileage and the date the work was performed. Also, receipts for the
replacement parts (fluid, filters, etc.) indicating the date and mileage must accompany
this statement.
NOTE
If you elect to perform maintenance yourself or have your vehicle serviced at a location other than an
Authorized Mazda Dealer, Mazda requires that all fluids, parts and materials must meet Mazda
standards for durability and performance as described in this manual.
Claims against the warranty resulting from lack of maintenance, as opposed to defective
materials or authorized Mazda workmanship, will not be honored.
8-2
Maintenance and Care
Introduction
Any auto repair shop using parts equivalent to your Mazda's original equipment may
perform maintenance. But we recommend that it always be done by an Authorized
Mazda Dealer using genuine Mazda parts.
For vehicles equipped with the multi information display, selecting
“Maintenance Monitor”
enables the system to notify you of your vehicle's approaching inspection/servicing period
(page 6-183).
Maintenance and Care
Introduction
8-3
Scheduled Maintenance (USA, Canada, and Puerto Rico)
Follow Schedule 1 if the vehicle is operated mainly where none of the following conditions
apply.
l
Repeated short-distance driving
l
Driving in dusty conditions
l
Driving with extended use of brakes
l
Driving in areas where salt or other corrosive materials are used
l
Driving on rough or muddy roads
l
Extended periods of idling or low-speed operation
l
Driving for long periods in cold temperatures or extremely humid climates
l
Driving in extremely hot conditions
l
Driving in mountainous conditions continually
If any do apply, follow Schedule 2 (Canada and Puerto Rico residents follow Schedule 2).
NOTE
After the prescribed period, continue to follow the described maintenance at the recommended
intervals.
8-4
Maintenance and Care
Scheduled Maintenance
qSchedule 1
Maintenance Interval
Number of months or kilometers (miles), whichever comes first
Months
6
12
18
24
30
36
42
48
×1000 km
12
24
36
48
60
72
84
96
×1000 miles
7.5
15
22.5
30
37.5
45
52.5
60
ENGINE
Engine valve clearance
Audibly inspect every 120,000 km (75,000 miles), if noisy,
adjust
Drive belts
I
Engine oil
R
R
R
R
R
R
R
R
Engine oil filter
R
R
R
R
R
R
R
R
COOLING SYSTEM
Engine coolant
FL22 type
*1
Replace at first 192,000 km (120,000 miles) or 10 years; after
that, every 96,000 km (60,000 miles) or 5 years
Others
Replace at first 96,000 km (60,000 miles) or 4 years; after that,
every 2 years
FUEL SYSTEM
Air filter
R
Fuel lines and hoses
*2
I
I
Hoses and tubes for emission
*2
I
IGNITION SYSTEM
Spark plugs
Replace every 120,000 km (75,000 miles)
CHASSIS and BODY
Brake lines, hoses and connections
I
I
Disc brakes
I
I
I
I
Tire (Rotation)
Rotate every 12,000 km (7,500 miles)
Steering operation and linkages
I
I
Front and rear suspension, ball joints and wheel
bearing axial play
I
I
Driveshaft dust boots
I
I
Bolts and nuts on chassis and body
T
T
Exhaust system and heat shields
Inspect every 72,000 km (45,000 miles) or 5 years
All locks and hinges
L
L
L
L
L
L
L
L
Maintenance and Care
Scheduled Maintenance
8-5
Maintenance Interval
Number of months or kilometers (miles), whichever comes first
Months
6
12
18
24
30
36
42
48
×1000 km
12
24
36
48
60
72
84
96
×1000 miles
7.5
15
22.5
30
37.5
45
52.5
60
AIR CONDITIONER SYSTEM
Cabin air filter
R
R
Chart symbols:
I: Inspect: Inspect and clean, repair, adjust, fill up, or replace if necessary.
R: Replace
L: Lubricate
T: Tighten
Remarks:
*1 Use FL22 type coolant in vehicles with the inscription
“FL22” on the radiator cap itself or the surrounding
area. Use FL22 when replacing the coolant.
*2 According to state/provincial and federal regulations, failure to perform maintenance on these items will not
void your emissions warranties. However, Mazda recommends that all maintenance services be performed at
the recommended time or mileage/kilometer period to ensure long-term reliability.
8-6
Maintenance and Care
Scheduled Maintenance
qSchedule 2
Maintenance Interval
Number of months or kilometers (miles), whichever comes first
Months
4
8
12
16
20
24
28
32
36
40
44
48
×1000 km
8
16
24
32
40
48
56
64
72
80
88
96
×1000 miles
5
10
15
20
25
30
35
40
45
50
55
60
ENGINE
Engine valve clearance
Audibly inspect every 120,000 km (75,000 miles), if noisy,
adjust
Drive belts
I
Engine oil
Puerto Rico
Replace every 5,000 km (3,000 miles) or 3 months
Others
R
R
R
R
R
R
R
R
R
R
R
R
Engine oil filter
R
R
R
R
R
R
R
R
R
R
R
R
COOLING SYSTEM
Engine coolant
FL22 type
*1
Replace at first 192,000 km (120,000 miles) or 10 years; after
that, every 96,000 km (60,000 miles) or 5 years
Others
Replace at first 96,000 km (60,000 miles) or 4 years; after that,
every 2 years
Engine coolant level
I
I
I
I
I
I
I
I
I
I
I
I
FUEL SYSTEM
Air filter
Puerto Rico
R
R
Others
R
Fuel lines and hoses
*2
I
I
Hoses and tubes for emission
*2
I
IGNITION SYSTEM
Spark plugs (Except MZR 2.3 DISI Turbo)
Replace every 120,000 km (75,000 miles)
Spark plugs
(for MZR 2.3 DISI Turbo)
USA
Replace every 96,000 km (60,000 miles)
Others
*3
Replace every 120,000 km (75,000 miles)
ELECTRICAL SYSTEM
Function of all lights
I
I
I
I
I
I
I
I
I
I
I
I
Maintenance and Care
Scheduled Maintenance
8-7
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст