Isuzu Amigo / Axiom / Trooper / Rodeo / VehiCross. Service manual — part 493
SECURITY AND LOCKS
8H–19
Main Data and Specifications
Torque Specifications
635R200011
SUN ROOF/CONVERTIBLE TOP
8I–1
AXIOM
BODY AND ACCESSORIES
SUNROOF/CONVERTIBLE TOP
CONTENTS
Service Precaution
8I–1
. . . . . . . . . . . . . . . . . . . . . .
Sunroof Glass
8I–2
. . . . . . . . . . . . . . . . . . . . . . . . . .
Sunroof Glass and Associated Parts
8I–2
. . . . .
Removal
8I–2
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation
8I–3
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Sunroof Deflector
8I–3
. . . . . . . . . . . . . . . . . . . . . . .
Removal
8I–3
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation
8I–3
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Sunshade
8I–4
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Disassembled View
8I–4
. . . . . . . . . . . . . . . . . . . .
Removal
8I–4
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation
8I–5
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Sunroof Frame Complete Assembly
8I–6
. . . . . . .
Sunroof Frame Complete Assembly and
Associated Parts
8I–6
. . . . . . . . . . . . . . . . . . . . . .
Removal
8I–6
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation
8I–7
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Sunroof Switch
8I–7
. . . . . . . . . . . . . . . . . . . . . . . . . .
Removal
8I–7
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation
8I–7
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Sunroof Control Unit
8I–8
. . . . . . . . . . . . . . . . . . . . .
Removal
8I–8
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation
8I–8
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Sunroof Motor
8I–8
. . . . . . . . . . . . . . . . . . . . . . . . . .
Removal
8I–8
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation
8I–8
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Main Data and Specifications
8I–9
. . . . . . . . . . . . .
Service Precaution
WARNING: THIS VEHICLE HAS A SUPPLEMENTAL
RESTRAINT SYSTEM (SRS). REFER TO THE SRS
COMPONENT AND WIRING LOCATION VIEW IN
ORDER TO DETERMINE WHETHER YOU ARE
PERFORMING SERVICE ON OR NEAR THE SRS
COMPONENTS OR THE SRS WIRING. WHEN YOU
ARE PERFORMING SERVICE ON OR NEAR THE SRS
COMPONENTS OR THE SRS WIRING, REFER TO
THE SRS SERVICE INFORMATION. FAILURE TO
FOLLOW WARNINGS COULD RESULT IN POSSIBLE
AIR BAG DEPLOYMENT, PERSONAL INJURY, OR
OTHERWISE UNNEEDED SRS SYSTEM REPAIRS.
CAUTION: Always use the correct fastener in the
proper location. When you replace a fastener, use
ONLY the exact part number for that application.
ISUZU will call out those fasteners that require a
replacement after removal. ISUZU will also call out
the fasteners that require thread lockers or thread
sealant. UNLESS OTHERWISE SPECIFIED, do not
use supplemental coatings (Paints, greases, or other
corrosion inhibitors) on threaded fasteners or
fastener joint interfaces. Generally, such coatings
adversely affect the fastener torque and the joint
clamping force, and may damage the fastener. When
you install fasteners, use the correct tightening
sequence and specifications. Following these
instructions can help you avoid damage to parts and
systems.
8I–2
SUN ROOF/CONVERTIBLE TOP
Sunroof Glass
Sunroof Glass and Associated Parts
665R200003
Legend
(1) Sunroof Weatherstrip
(2) Sunroof Glass
Removal
1. Tilt the sunroof and open the sunshade.
2. Disconnect the battery ground cable.
3. Pull out the front of sight shield (2).
4. Remove four sunroof glass fixing Torx screws (3) to
remove the sunroof glass (1).
665R200004
SUN ROOF/CONVERTIBLE TOP
8I–3
Installation
1. Be sure to install the sunroof weatherstrip so that the
joint of the weatherstrip is on the rear side of the
vehicle.
2. Temporary install the glass to the sunroof frame.
3. Open and shut the sunroof four to five times to
position correctly the sunroof weatherstrip and the
glass in the longitudinal and latitudinal setting
positions.
4. Adjust the setting position to flush the surface
between the roof panel and weatherstrip of sunroof
glass.
5. Tighten the sunroof glass fixing screws to the
specified torque.
Torque: 4 N·m (35 lb in)
6. Inspect the sunroof alignment after installing the
sunroof glass. Use the fixing screws to adjust the
sunroof if not aligned.
Sunroof Deflector
Removal
1. Open the sunroof.
D
Let a 5 mm (0.20 in) drill go through two blind rivets
(2) to disengage riveted portions.
2. Remove the sunroof deflector (1).
665R200001
Installation
To install, follow the removal steps in the reverse order.
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст