Isuzu Amigo / Axiom / Trooper / Rodeo / VehiCross. Service manual — part 479
8F–37
BODY STRUCTURE
Rear Door Assembly
Parts Location
650R200001
Legend
(1) Rear Door Assembly
(2) Lower Hinge Bolt
(3) Door Check Arm
(4) Door Harness Connector
(5) Upper Hinge Bolt
Removal
1. Disconnect the battery ground cable.
2. Apply a setting mark on the body side hinge.
3. Remove the door check arm bolt.
650R200002
4. Remove the upper and lower hinge bolts.
D
Position a wood block under the door for protection
and support the door assembly with hands during
removal or installation.
650R200004
8F–38
BODY STRUCTURE
5. Remove the door harness connectors.
D
Pull the door harness grommet out in order to
disconnect the door harness connectors.
650R200003
6. Remove the rear door assembly.
Installation
To install, follow the removal steps in the reverse order,
noting the following points:
1. Align the door fitting to the body by referring to Front
Door Assembly in this section.
2. Tighten the door hinge bolts to the specified torque.
Torque : 34 N·m (25 lb ft)
3. Tighten the door check arm bolt and nuts to the
specified torque.
Torque : 9 N·m (78 lb in)
8F–39
BODY STRUCTURE
Front Window Regulator, Glass and Glass Run
Parts Location
635R200012
Legend
(1) Glass
(2) Glass Run
(3) Door Mirror Assembly
(4) Door Mirror Cover
(5) Tweeter
(6) Speaker Spacer
(7) Speaker Assembly
(8) Inner Waist Seal
(9) Door Trim Panel
(10) Power Window Switch
(11) Inside Lock Bracket
(12) Inside Handle
(13) Pull Box
(14) Courtesy Light
(15) Pull Box Bracket
(16) Waterproof Sheet
(17) Front Door Panel
(18) Door Lock Assembly
(19) Door Lock Cylinder
(20) Outside Handle
(21) Window Regulator
(22) Outer Waist Seal
8F–40
BODY STRUCTURE
Removal
1. Disconnect the battery ground cable.
2. Remove the pull box.
D
Remove the one fixing screw.
635R200004
3. Remove the power window switch (1).
D
Pull the power window switch and remove the
connector.
635R200002
4. Remove the inside handle.
D
Open the screw cover (1) and remove the screw.
D
Disconnect the cable.
635R200003
5. Remove the door mirror cover.
6. Remove the trim panel at the 8 clip positions (1).
D
Disconnect the tweeter and courtesy light
connectors.
635R200005
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст