Suzuki Grand Vitara JB416 / JB420. Service manual — part 262
5C-12 Clutch:
Table of Contents 6- i
6
Section 6
CONTENTS
Steering
Precautions . . . . . . . . . . . . .6-1
Precautions. . . . . . . . . . . . . . . . 6-1
Precautions for Steering . . . . . . . . . ... 6-1
Steering General Diagnosis. . . . . 6A-1
Diagnostic Information and Procedures. . . 6A-1
Steering Symptom Diagnosis. . . . . . . .. 6A-1
Steering Wheel and Column. . . . ... 6B-1
Precautions. . . . . . . . . . . . . . ...6B-1
Service Precautions of Air Bag Steering
Wheel and Column . . . . . . . . . . ... 6B-1
Precautions on Handling and Storage of Air
Bag Steering Wheel and Column. . . . . .. 6B-1
Precautions on Disposal of Air Bag Steering
Wheel and Column . . . . . . . . . . ... 6B-1
General Description . . . . . . . . . . . .6B-1
Steering Wheel and Column Construction . . .. 6B-1
Diagnostic Information and Procedures. . . 6B-3
Air Bag Steering Wheel and Column
Symptom Diagnosis . . . . . . . . . . .. 6B-3
Air Bag Steering Wheel and Column
Inspection and Repair Required after
Accident . . . . . . . . . . . . . . . 6B-3
Diagnosis and Servicing of Air Bag Steering
Wheel and Column . . . . . . . . . . ... 6B-3
Repair Instructions . . . . . . . . . . . ..6B-3
Checking Steering Column for Accident
Damage . . . . . . . . . . . . . . . 6B-3
Steering Wheel Removal and Installation . . ... 6B-4
Contact Coil Cable Assembly Removal and
Installation. . . . . . . . . . . . . . . 6B-5
Installation. . . . . . . . . . . . . . . 6B-7
Steering Column Assembly Inspection . . . .6B-10
Ignition Switch Cylinder Assembly Removal
and Installation (Without Keyless Start
System). . . . . . . . . . . . . . ... 6B-10
Steering Lock Assembly (Ignition Switch)
Removal and Installation. . . . . . . . . 6B-11
Adjustable Steering Column Release Lever
Inspection. . . . . . . . . . . . . . 6B-11
Steering Upper Shaft Assembly Removal and
Installation . . . . . . . . . . . . . ...6B-11
Steering Upper Shaft Assembly Inspection. ...6B-12
Steering Lower Shaft Assembly Removal and
Installation . . . . . . . . . . . . . ...6B-13
Specifications. . . . . . . . . . . . . .6B-14
Tightening Torque Specifications. . . . . ..6B-14
Special Tools and Equipment . . . . . . ...6B-14
Special Tool . . . . . . . . . . . . . ..6B-14
Power Assisted Steering System. . ... 6C-1
Precautions. . . . . . . . . . . . . . ...6C-1
P/S System Note. . . . . . . . . . . . .6C-1
General Description . . . . . . . . . . . .6C-1
P/S System Construction . . . . . . . . . 6C-1
Steering Gear Case Construction . . . . . ...6C-2
P/S Pump Construction. . . . . . . . . ...6C-2
Schematic and Routing Diagram. . . . . . 6C-3
P/S Fluid Flow Diagram . . . . . . . . . ..6C-3
Diagnostic Information and Procedures. . . 6C-3
P/S System Symptom Diagnosis . . . . . . 6C-3
Steering Wheel Check . . . . . . . . . . 6C-4
Steering Force Check . . . . . . . . . . .6C-5
Steering Wheel Recovery Check . . . . . . 6C-5
Idle Up System Check. . . . . . . . . . .6C-5
Hydraulic Pressure in P/S Circuit Check. . . .6C-5
Repair Instructions . . . . . . . . . . . ..6C-7
P/S Fluid Change . . . . . . . . . . . . 6C-7
P/S Fluid Level Check. . . . . . . . . . .6C-7
P/S Fluid Leakage Check. . . . . . . . . 6C-8
P/S System Air Bleeding Procedure . . . . ...6C-8
P/S Pump and A/C Compressor (If Equipped)
Drive Belt Inspection and Adjustment for
M16 Engine Model . . . . . . . . . . . 6C-9
P/S Pump and A/C Compressor (If Equipped)
Drive Belt Inspection and Adjustment for J20
Engine Model . . . . . . . . . . . . . 6C-9
P/S Pump and A/C Compressor (If Equipped)
Drive Belt Removal and Installation for M16
Engine Model . . . . . . . . . . . . . 6C-9
P/S Pump and A/C Compressor (If Equipped)
Drive Belt Removal and Installation for J20
Engine Model . . . . . . . . . . . . ..6C-10
6-ii Table of Contents
Tie-Rod End Boot Check . . . . . . . . ..6C-10
Tie-Rod End Removal and Installation. . . ..6C-10
Tie-Rod End Ball Joint Inspection . . . . . .6C-11
P/S Gear Case Assembly Components . . . 6C-12
P/S Gear Case Assembly Removal and
Installation. . . . . . . . . . . . . ...6C-13
Steering Gear Case Mount Bushing Removal
and Installation . . . . . . . . . . . . 6C-14
Steering Gear Case Mount Bushing
Inspection. . . . . . . . . . . . . . 6C-14
Rack Boot / Tie-Rod Removal and Installation ..6C-15
P/S Hose / Pipe Components . . . . . . ...6C-16
P/S Pump Removal and Installation for M16
Engine Model . . . . . . . . . . . . ..6C-18
P/S Pump Removal and Installation for J20
Engine Model . . . . . . . . . . . . ..6C-18
P/S Pump Components for M16 Engine
Model . . . . . . . . . . . . . . . ..6C-19
P/S Pump Assembly Components for J20
Engine Model . . . . . . . . . . . . ..6C-20
P/S Pump Disassembly and Assembly for
M16 Engine Model . . . . . . . . . . ..6C-20
P/S Pump Inspection for M16 Engine Model . 6C-22
P/S Pump Inspection for J20 Engine Model. ..6C-23
Specifications . . . . . . . . . . . . . .6C-23
Tightening Torque Specifications. . . . . ..6C-23
Special Tools and Equipment . . . . . . ...6C-24
Recommended Service Material . . . . . ...6C-24
Special Tool . . . . . . . . . . . . . ..6C-24
Precautions: 6-1
Steering
Precautions
Precautions
Precautions for Steering
S5JB0A6000001
Air Bag Warning
Refer to “Air Bag Warning in Section 00”.
Fastener Caution
Refer to “Fastener Caution in Section 00”.
Service Precautions of Air Bag Steering Wheel and Column
Refer to “Service Precautions of Air Bag Steering Wheel and Column in Section 6B”.
Handling and Storage of Air Bag Steering Wheel and Column
Refer to “Precautions on Handling and Storage of Air Bag Steering Wheel and Column in Section 6B”.
Disposal of Air Bag Steering Wheel and Column
Refer to “Precautions on Disposal of Air Bag Steering Wheel and Column in Section 6B”.
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст