RAM 2500 Diesel (2007 year). Instruction — part 32
Miles
82,500
90,000
97,500
100,000
105,000
(Kilometers)
(132 000)
(144 000)
(156 000)
(160 000)
(168 000)
Change engine oil and engine oil filter.
X
X
X
X
Lubricate Front Drive Shaft Fitting (2500/3500,
4X4).
X
X
X
X
Rotate tires.
X
X
X
X
Check spare tire for proper pressure and correct
stowage.
X
X
X
X
Lubricate outer tie rod ends 2500/3500 (4X4)
models.
X
X
X
X
Flush and replace engine coolant, if not replaced
at 60 mos.
X
Check transfer case fluid level (4X4).
X
Change front axle fluid (4x4).
X
X
Change rear axle fluid.
X
X
Inspect drive belt, replace as required.
X
Replace fuel filter element.
X
X
502
SCHEDULE “B”
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S
-------------------------------------------------------------------------------------------------------------------------------------------------------------
Miles
82,500
90,000
97,500
100,000
105,000
(Kilometers)
(132 000)
(144 000)
(156 000)
(160 000)
(168 000)
Inspect front wheel bearings.
X
Inspect brake linings.
X
X
Inspect and adjust parking brake if necessary.
X
X
Drain and refill automatic transmission fluid. Re-
place filter and adjust bands (48 RE only).
X
SCHEDULE “B”
503
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S
-------------------------------------------------------------------------------------------------------------------------------------------------------------
Miles
112,500
120,000
127,500
135,000
142,500
150,000
(Kilometers)
(181 000)
(193 000)
(205 000) (217 000) (229 000) (241 000)
Change engine oil and engine oil filter.
X
X
X
X
X
X
Lubricate Front Drive Shaft Fitting (2500/
3500, 4X4).
X
X
X
X
X
X
Rotate tires.
X
X
X
X
X
X
Check spare tire for proper pressure and cor-
rect stowage.
X
X
X
X
X
X
Lubricate outer tie rod ends 2500/3500 (4X4)
models.
X
X
X
X
X
X
Flush and replace engine coolant at 120
months, if not replaced at 100,000 miles (160
000 km).
X
Clean engine air filter assembly.
X
Inspect drive belt, replace as required.
X
X
Change front axle fluid (4x4).
X
X
X
Change rear axle fluid.
X
X
X
504
SCHEDULE “B”
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S
-------------------------------------------------------------------------------------------------------------------------------------------------------------
Miles
112,500
120,000
127,500
135,000
142,500
150,000
(Kilometers)
(181 000)
(193 000)
(205 000) (217 000) (229 000) (241 000)
Drain and refill transfer case fluid (4X4).
X
Check transfer case fluid level (4X4).
X
Replace fuel filter element.
X
X
X
Inspect front wheel bearings.
X
X
Inspect brake linings.
X
X
X
Inspect and adjust parking brake if necessary.
X
X
X
Adjust valve lash clearance.
X
Change 6 — speed instruction transmission (G-
56) fluid.
X
Drain and refill automatic transmission fluid.
Replace filter and adjust bands (48RE only)
X
Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
SCHEDULE “B”
505
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S
-------------------------------------------------------------------------------------------------------------------------------------------------------------
Schedule “A”
Miles
7,500
15,000
22,500
30,000
37,500
(Kilometers)
(12 000)
(24 000)
(36 000)
(48 000)
(60 000)
[Months]
[6]
[12]
[18]
[24]
[30]
Change engine oil and engine oil filter.
X
X
Lubricate Front Drive Shaft Fitting (2500/3500, 4X4).
X
X
X
X
X
Rotate tires.
X
X
X
X
X
Check spare tire for proper pressure and correct
stowage.
X
X
X
X
X
Lubricate outer tie rod ends 2500/3500 (4X4) models.
X
X
X
X
X
Check transfer case fluid level (4X4).
X
Replace fuel filter element.
X
X
Inspect drive belts, replace as necessary.
X
Inspect brake linings.
X
Inspect and adjust parking brake if necessary.
X
Inspect front wheel bearings.
X
506
SCHEDULE “A”
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S
-------------------------------------------------------------------------------------------------------------------------------------------------------------
Miles
45,000
52,500
60,000
67,500
75,000
(Kilometers)
(72 000)
(84 000)
(96 000)
(108 000)
(120 000)
[Months]
[36]
[42]
[48]
[54]
[60]
Change engine oil and engine oil filter.
X
X
X
Lubricate Front Drive Shaft Fitting (2500/3500, 4X4).
X
X
X
X
X
Rotate tires.
X
X
X
X
X
Check spare tire for proper pressure and correct
stowage.
X
X
X
X
X
Lubricate outer tie rod ends 2500/3500 (4X4) models.
X
X
X
X
X
Check transfer case fluid level.
X
Flush and replace engine coolant at 60 months, if not
replaced at 100,000 miles (160 000 km).
X
Inspect drive belts, replace as necessary.
X
X
Replace fuel filter element.
X
X
X
Inspect brake linings.
X
X
Inspect and adjust parking brake if necessary.
X
X
Inspect front wheel bearings.
X
SCHEDULE “A”
507
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S
-------------------------------------------------------------------------------------------------------------------------------------------------------------
Miles
82,500
90,000
97,500
100,000
105,000
(Kilometers)
(132 000)
(144 000)
(156 000)
(160 000)
(168 000)
[Months]
[66]
[72]
[78]
[84]
Change engine oil and engine oil filter.
X
X
Lubricate Front Drive Shaft Fitting (2500/3500, 4X4).
X
X
X
X
Rotate tires.
X
X
X
X
Check spare tire for proper pressure and correct stowage.
X
X
X
X
Lubricate outer tie rod ends 2500/3500 (4X4) models.
X
X
X
X
Flush and replace engine coolant, if not replaced at 60 mos.
X
Check transfer case fluid level (4X4).
X
Inspect drive belt, replace as required.
X
Replace fuel filter element.
X
X
Inspect front wheel bearings.
X
Inspect brake linings.
X
Inspect and adjust parking brake if necessary.
X
Drain and refill automatic transmission fluid. Replace filter
and adjust bands (48 RE only).
X
508
SCHEDULE “A”
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S
-------------------------------------------------------------------------------------------------------------------------------------------------------------
Miles
112,500
120,000
127,500
135,000
142,500
150,000
(Kilometers)
(181 000)
(193 000)
(205 000) (217 000) (229 000) (241 000)
[Months]
[90]
[96]
[102]
[108]
[114]
[120]
Change engine oil and engine oil filter.
X
X
X
Lubricate Front Drive Shaft Fitting (2500/
3500, 4X4).
X
X
X
X
X
X
Rotate tires.
X
X
X
X
X
X
Check spare tire for proper pressure and cor-
rect stowage.
X
X
X
X
X
X
Lubricate outer tie rod ends 2500/3500 (4X4)
models.
X
X
X
X
X
X
Flush and replace engine coolant at 120
months, if not replaced at 100,000 miles
(160 000 km).
X
Inspect drive belt, replace as required.
X
X
Drain and refill transfer case fluid (4X4).
X
Check transfer case fluid level (4X4).
X
Replace fuel filter element.
X
X
X
SCHEDULE “A”
509
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S
-------------------------------------------------------------------------------------------------------------------------------------------------------------
Miles
112,500
120,000
127,500
135,000
142,500
150,000
(Kilometers)
(181 000)
(193 000)
(205 000) (217 000) (229 000) (241 000)
[Months]
[90]
[96]
[102]
[108]
[114]
[120]
Inspect front wheel bearings.
X
X
Inspect brake linings.
X
X
Inspect and adjust parking brake if necessary.
X
X
Adjust valve lash clearance.
X
Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
WARNING!
You can be badly injured working on or around a
motor vehicle. Do only that service work for which
you have the knowledge and the right equipment. If
you have any doubt about your ability to perform a
service job, take your vehicle to a competent
mechanic.
510
SCHEDULE “A”
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S
-------------------------------------------------------------------------------------------------------------------------------------------------------------
MAINTENANCE SCHEDULES — 6.7L TURBO
DIESEL
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
At Each Stop for Fuel
• Check the engine oil level about 30 minutes after a
fully warmed engine is shut off. Checking the oil level
while the vehicle is on level ground will improve the
accuracy of the oil level reading. Add oil only when
the level is at or below the ADD or MIN mark.
• Check the windshield washer solvent and add if
required. When refilling the washer fluid reservoir,
take some washer fluid and apply it to a cloth or towel
and wipe clean the wiper blades, this will help blade
performance.
Once a Month
• Check tire pressure and look for unusual wear or
damage.
• Inspect the batteries and clean and tighten the termi-
nals as required.
• Check the fluid levels of coolant reservoir, brake
master cylinder, and transmission and transfer case (if
equipped), add as needed.
• Check Filter Minder™. Replace air cleaner filter
element if necessary.
• Check all lights and all other electrical items for correct
operation.
• Drain water from the fuel filter.
SCHEDULE “A”
511
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S
-------------------------------------------------------------------------------------------------------------------------------------------------------------
At Each Oil Change
• Change the engine oil filter.
• Inspect the exhaust system.
• Inspect the brake hoses.
• Inspect the U-Joints ( if equipped) and front suspen-
sion components.
• Check the automatic transmission fluid level.
• Check the instruction transmission fluid level.
• Check the coolant level, hoses, and clamps.
• Lubricate outer tie rod ends (4X4) models only.
• Lubricate Front Drive Shaft Fitting ( 4X4).
Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
Oil Change Indicator System
Your vehicle is equipped with an engine oil change
indicator system. This system will alert you when it is
time to change your engine oil by displaying the words
“Oil Change Required” on your Electronic Vehicle Infor-
mation Center (EVIC). The engine oil change indicator
system is duty cycle based, which means the engine oil
change interval may fluctuate depending on your per-
sonal driving style. Driving styles such as frequent stop
and go type driving can increase the frequency of the
engine oil change. This is the result of more frequent
regeneration of the exhaust aftertreatment system, which
can decrease the life of the engine oil. Failure to change
the engine oil per the maintenance schedule can result in
internal engine damage.
512
SCHEDULE “A”
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S
-------------------------------------------------------------------------------------------------------------------------------------------------------------
For information on resetting the Oil Change Indicator
message, refer to “Oil Change Required – If Equipped,”
under “Personal Settings (Customer Programmable Fea-
tures),” in the “Electronic Vehicle Information Center
(EVIC)” Section of this manual.
Perform Service Indicator
Your vehicle will require emissions maintenance at a set
interval. To help remind you when this maintenance is
due, the Electronic Vehicle Information Center (EVIC)
will display “Perform Service”. When the “Perform Ser-
vice” message is displayed on the EVIC it is necessary to
have the emissions maintenance performed. Emissions
maintenance includes replacing the Closed Crankcase
Ventilation (CCV) filter element, cleaning or replacement
of the EGR Cooler, and cleaning or replacement of the
EGR Valve. The procedure for clearing and resetting the
⬙Perform Service⬙ indicator message is located in the
appropriate Service Information.
SCHEDULE “A”
513
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S
-------------------------------------------------------------------------------------------------------------------------------------------------------------
Maintenance Schedule
Miles
7,500
15,000
22,500
30,000
37,500
(Kilometers)
(12 000)
(24 000)
(36 000)
(48 000)
(60 000)
[Months]
[6]
[12]
[18]
[24]
[30]
Change engine oil and engine oil filter. (Under no
circumstances should oil change intervals exceed
7,500 miles (12 000 km) or 6 months, which ever
comes first).
X
X
X
X
X
Lubricate Front Drive Shaft Fitting (4X4).
X
X
X
X
X
Rotate tires.
X
X
X
X
X
Check spare tire for proper pressure and correct
stowage.
X
X
X
X
X
Lubricate outer tie rod ends.
X
X
X
X
X
Check transfer case fluid level (4X4).
X
Change front and rear axle fluid (4X4).
X
X
Replace fuel filter element.
X
X
Inspect brake linings.
X
Inspect and adjust parking brake if necessary.
X
514
SCHEDULE “A”
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S
-------------------------------------------------------------------------------------------------------------------------------------------------------------
Miles
7,500
15,000
22,500
30,000
37,500
(Kilometers)
(12 000)
(24 000)
(36 000)
(48 000)
(60 000)
[Months]
[6]
[12]
[18]
[24]
[30]
Inspect fan hub.
X
Inspect damper.
X
Inspect front wheel bearings.
X
Inspect drive belt, replace as necessary.
X
SCHEDULE “A”
515
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S
-------------------------------------------------------------------------------------------------------------------------------------------------------------
Miles
45,000
52,500
60,000
67,500
75,000
(Kilometers)
(72 000)
(84 000)
(97 000)
(109 000)
(121 000)
[Months]
[36]
[42]
[48]
[54]
[60]
Change engine oil and engine oil filter.
X
X
X
X
X
Lubricate Front Drive Shaft Fitting (4X4).
X
X
X
X
X
Rotate tires.
X
X
X
X
X
Check spare tire for proper pressure and correct
stowage.
X
X
X
X
X
Lubricate outer tie rod ends.
X
X
X
X
X
Drain and refill transfer case fluid (4X4).
X
Change front and rear axle fluid (4X4).
X
X
X
Drain and refill automatic transmission fluid,
change main sump filter and spin-on cooler filter
(if equipped). If your vehicle is used for police,
taxi, fleet or frequent trailer towing.
X
Change manual transmission fluid.
X
Flush and replace engine coolant at 60 months, if
not replaced at 100,000 miles (160 000 km).
X
516
SCHEDULE “A”
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S
-------------------------------------------------------------------------------------------------------------------------------------------------------------
Miles
45,000
52,500
60,000
67,500
75,000
(Kilometers)
(72 000)
(84 000)
(97 000)
(109 000)
(121 000)
[Months]
[36]
[42]
[48]
[54]
[60]
Inspect drive belt, replace as necessary.
X
X
Replace fuel filter element.
X
X
X
Inspect brake linings.
X
X
Inspect and adjust parking brake if necessary.
X
X
Inspect fan hub.
X
Inspect damper.
X
Inspect front wheel bearings.
X
Replace Crankcase Ventilation Filter (CCV).
X
Clean or replace (if necessary), EGR Valve.
X
Clean or replace (if necessary), EGR Cooler.
X
SCHEDULE “A”
517
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S
-------------------------------------------------------------------------------------------------------------------------------------------------------------
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст