RAM ProMaster (2019 year). Instruction — part 12
2. Using a suitable tool, pull open the metal bulb access on
the back of the housing.
3. Remove and install the replacement bulb.
4. Close the bulb access, connect the lamp and install the
lamp into place.
Dome Lamps
1. Using a suitable tool, insert the tip at the location shown
and press inward to the lamp to relieve the spring
tension. This will allow you to easily drop the dome
lamp assembly from its bracket and disconnect the
lamp.
Cargo Lamp Bulb Location
Dome Lamp Assembly Location
1. Spring Tension Relief Access
2. Dome Lamp Assembly
184
IN CASE OF EMERGENCY
-------------------------------------------------------------------------------------------------------------------------------------------------------------
2. Using a suitable tool, flex the housing to lift the light
pod cover away from the unit.
3. Remove and replace the bulbs as needed.
4. Close the housing cover making sure it snaps together
properly and connect the lamp.
5. Install overhead console into place making sure to seat
the assembly’s forward end first and then snapping it
flush so that the tension spring is fully seating in the
housing.
Dome Lamp Light Pod Cover
Dome Lamp Light Bulbs
7
IN CASE OF EMERGENCY
185
-------------------------------------------------------------------------------------------------------------------------------------------------------------
FUSES
WARNING!
• When replacing a blown fuse, always use an appro-
priate replacement fuse with the same amp rating as
the original fuse. Never replace a fuse with another
fuse of higher amp rating. Never replace a blown
fuse with metal wires or any other material. Do not
place a fuse inside a circuit breaker cavity or vice
versa. Failure to use proper fuses may result in
serious personal injury, fire and/or property damage.
• Before replacing a fuse, make sure that the ignition is
off and that all the other services are switched off
and/or disengaged.
• If the replaced fuse blows again, contact an autho-
rized dealer.
• If a general protection fuse for safety systems (air
bag system, braking system), power unit systems
(engine system, transmission system) or steering
system blows, contact an authorized dealer.
Underhood Fuses
The Front Power Distribution Center is located on the
driver’s side of the engine compartment. To access the
fuses, remove the cover.
The ID number of the electrical component corresponding
to each fuse can be found on the back of the cover.
Front Power Distribution Center
186
IN CASE OF EMERGENCY
-------------------------------------------------------------------------------------------------------------------------------------------------------------
Cavity
Maxi Fuse
Mini Fuse
Description
F01
40 Amp Orange
–
Electronic Stability Control (ESC) Pump
F02
20 Amp Yellow (3.6
Gasoline Engine)
–
Starter Relay 3.6L (3.6 Gasoline Engine)
F04
50 Amp Red (3.6 Gaso-
line Engine)
–
Secondary Power Distribution Center
(PDC) (Trans Power Relay, Vacuum Pump,
KL30 for the Shifter Transmission Module
[STM]) (3.6 Gasoline Engine)
F06
40 Amp Orange (non
A/C)
60 Amp Blue (A/C)
–
Engine Cooling Fan - 2nd Speed
F07
50 Amp Red (non
A/C)
60 Amp Blue (A/C)
–
Engine Cooling Fan - 1st Speed
F08
40 Amp Orange
–
Passenger Compartment Blower
F09
–
15 Amp Blue
Rear Power Outlet
F10
–
15 Amp Blue
Horn
F14
–
20 Amp Yellow
Power Outlet
F15
–
7.5 Amp Brown
USB Charger
F16
–
7.5 Amp Brown
KL15 Shifter Transmission Module (STM)
(3.6), KL15 Starter Relay Coil (3.6 Gasoline
Engine)
7
IN CASE OF EMERGENCY
187
-------------------------------------------------------------------------------------------------------------------------------------------------------------
Cavity
Maxi Fuse
Mini Fuse
Description
F17
–
20 Amp Yellow
Engine Control Module (ECM), Injectors
(3.6 Gasoline Engine)
F18
–
7.5 Amp Brown
KL30 Engine Control Module (ECM), KL30
Main Relay Coil (3.6 Gasoline Engine)
F19
–
7.5 Amp Brown
A/C Compressor — If Equipped
F20
–
30 Amp Green
Windshield Wiper
F21
–
15 Amp Blue
Fuel Pump
F22
–
20 Amp Yellow
Engine Control Module (ECM), Ignition
Coils (3.6 Gasoline Engine)
F23
–
20 Amp Yellow
Electronic Stability Control (ESC) Valves
F24
–
7.5 Amp Brown
KL15 Vacuum Pump Relay Coil (3.6 Gaso-
line Engine) — If Equipped
F30
–
15 Amp Blue
Heated Mirrors
188
IN CASE OF EMERGENCY
-------------------------------------------------------------------------------------------------------------------------------------------------------------
Front PDC Additional Fuses
The additional fuse box is located inside the front PDC Box.
Cavity
Mini Fuse
Description
F61
20 Amp Yellow
Vacuum Pump (3.6 Gasoline Engine)
F62
30 Amp Green
Transmission Power RELE (3.6 Gasoline Engine)
F66
5 Amp Beige
Shifter Transmission Module (STM) (3.6 Gasoline Engine)
Front Power Distribution Center Additional Fuses
7
IN CASE OF EMERGENCY
189
-------------------------------------------------------------------------------------------------------------------------------------------------------------
Interior Fuses
The interior fuse panel is part of the Body Control Module
(BCM) and is located on the driver’s side under the
instrument panel.
Fuse Panel
190
IN CASE OF EMERGENCY
-------------------------------------------------------------------------------------------------------------------------------------------------------------
Cavity
Mini Fuse
Description
F31
5 Amp Beige
INT/A
F34
7.5 Amp Brown
Clearance Lights
F36
15 Amp Blue
+30 (ACM – TPCU – RRM – DLC)
F37
5 Amp Beige
INT (BRAKE NO – IPC)
Fuse Panel Cavity Locations
7
IN CASE OF EMERGENCY
191
-------------------------------------------------------------------------------------------------------------------------------------------------------------
Cavity
Mini Fuse
Description
F38
15 Amp Blue
Central Locking
F42
5 Amp Beige
INT (BSM – SAS – BRAKE NC)
F43
20 Amp Yellow
Bi-Directional Washer Pump
F47
20 Amp Yellow
Driver Power Window
F48
20 Amp Yellow
Passenger Power Window
F49
5 Amp Beige
INT (PAM – CCS – RRM – ECM)
F50
7.5 Amp Brown
INT (ORC)
F51
5 Amp Beige
INT (REAR CAMERA-AUX)
F53
5 Amp Beige
+30 (IPC) + FTM
F92
7.5 Amp Brown
Left Fog Lamp
F93
7.5 Amp Brown
Right Fog Lamp
192
IN CASE OF EMERGENCY
-------------------------------------------------------------------------------------------------------------------------------------------------------------
Right Central Pillar Fuses
The right central pillar fuse panel is located on the interior
side at the base of the passenger side B pillar.
Cavity
Mini Fuse
Description
F81
7.5 Amp Brown
Seat Heater
F83
20 Amp Yellow
Rear Left Windows Heater
F84
20 Amp Yellow
Rear Right Windows Heater
F86
20 Amp Yellow
Auxiliary Switch (From Battery) — If Equipped
F87
20 Amp Yellow
Auxiliary Switch (From Ignition) — If Equipped
Fuse Panel Location
Fuse Panel
7
IN CASE OF EMERGENCY
193
-------------------------------------------------------------------------------------------------------------------------------------------------------------
JACKING AND TIRE CHANGING
WARNING!
• Do not attempt to change a tire on the side of the
vehicle close to moving traffic. Pull far enough off
the road to avoid the danger of being hit when
operating the jack or changing the wheel.
• Being under a jacked-up vehicle is dangerous. The
vehicle could slip off the jack and fall on you. You
could be crushed. Never put any part of your body
under a vehicle that is on a jack. If you need to get
under a raised vehicle, take it to a service center
where it can be raised on a lift.
• Never start or run the engine while the vehicle is on
a jack.
• The jack is designed to be used as a tool for changing
tires only. The jack should not be used to lift the
vehicle for service purposes. The vehicle should be
jacked on a firm level surface only. Avoid ice or
slippery areas.
Jack Location
The jack and jack tools are stored under the front passenger
seat.
To release the jack kit for it’s storage location, turn the lock
knob 1/4 turn counter clockwise to the unlock position.
Jack Kit Location
194
IN CASE OF EMERGENCY
-------------------------------------------------------------------------------------------------------------------------------------------------------------
CAUTION!
Do not force lock knob over limit. Damage to lock
knob may occur.
To open the jack kit container, you must push the contain-
er’s release to separate the top and bottom.
Lock Knob
1 — Unlock Position
2 — Lock Position
Container Release
7
IN CASE OF EMERGENCY
195
-------------------------------------------------------------------------------------------------------------------------------------------------------------
Spare Tire Removal
1. Remove the spare tire before attempting to jack up the
vehicle. Attach the lug bolt adapter to the winch exten-
sion and insert it into the winch mechanism.
Jacking Tools
1 — Wrench Handle
2 — Tow Eye
3 — Lug Bolt Adaptor
4 — Jack
5 — Tool Handle
6 — Reversible Tool
7 — Winch Extension
Jack Tools
1 — Wrench Handle
2 — Lug Bolt Adapter
3 — Winch Extension
196
IN CASE OF EMERGENCY
-------------------------------------------------------------------------------------------------------------------------------------------------------------
The winch mechanism is located under the rear of the
vehicle to the right of the spare tire.
2. Rotate the wheel wrench handle counterclockwise until
the spare tire is on the ground with enough cable slack
to allow you to pull it out from under the vehicle.
Winch Location
Winch Extension
7
IN CASE OF EMERGENCY
197
-------------------------------------------------------------------------------------------------------------------------------------------------------------
NOTE:
The winch mechanism is designed for use with the
winch extension tube only. Use of an air wrench or other
power tools is not recommended and can damage the
winch.
3. Pull the spare tire out from under the vehicle to gain
access to the spare tire retainer.
Lowering Spare Tire
Spare Tire
198
IN CASE OF EMERGENCY
-------------------------------------------------------------------------------------------------------------------------------------------------------------
4. Lift the spare tire with one hand to give clearance to tilt
the retainer at the end of the cable.
5. Pull the retainer through the center of the wheel.
Lifting Spare Tire
Retainer
7
IN CASE OF EMERGENCY
199
-------------------------------------------------------------------------------------------------------------------------------------------------------------
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст