Nissan Teana J32. Instruction — part 643
GW-26
< ON-VEHICLE REPAIR >
REAR REGULATOR
Install in the reverse order of removal.
Disassembly and Assembly
INFOID:0000000003825391
DISASSEMBLY
Remove power window motor from regulator assembly.
ASSEMBLY
Assemble in the reverse order of disassembly.
Inspection and Adjustment
INFOID:0000000003825392
Inspection after Removal
Check the regulator assembly for the following items. Replace or grease it if a malfunction is detected.
• Wire wear
• Regulator deformation
The arrows in the figure show the application points of the multi-purpose grease.
FITTING INSPECTION
• Check that the glass is fit securely into the sash groove.
• Lower the glass slightly [approximately 10 to 20 mm (0.394 to 0.787 in)], and check that the clearance to the
sash is parallel. Loosen the regulator mounting bolts, guide rail mounting bolts, and glass and carrier plate
mounting bolts to correct the glass position if the clearance between the glass and sash is not parallel.
: Grease application point
JMKIA2318ZZ
HA-1
VENTILATION, HEATER & AIR CONDITIONER
C
D
E
F
G
H
J
K
L
M
SECTION
HA
A
B
HA
N
O
P
CONTENTS
HEATER & AIR CONDITIONING SYSTEM
BASIC INSPECTION . . . . . . . . .
DIAGNOSIS AND REPAIR WORK FLOW . . .
Work Flow . . . . . . . . . . . . . . . .....
FUNCTION DIAGNOSIS . . . . . . . ...
REFRIGERATION SYSTEM . . . . . . . ...
System Diagram . . . . . . . . . . . . . ....
System Description . . . . . . . . . . . . ...
Component Parts Location . . . . . . . . . ....
Component Description . . . . . . . . . . .....
SYMPTOM DIAGNOSIS . . . . . . . ...
REFRIGERATION SYSTEM SYMPTOMS . . ..
Trouble Diagnosis For Unusual Pressure . . . .....
Symptom Table . . . . . . . . . . . . . .....
COMPRESSOR SYSTEM SYMPTOMS . . . .
Symptom Table . . . . . . . . . . . . . ...
PRECAUTION . . . . . . . . . . . ..
PRECAUTIONS . . . . . . . . . . . . ..
Precaution Necessary for Steering Wheel Rota-
tion after Battery Disconnect . . . . . . . . ...
Precaution for Procedure without Cowl Top Cover
Precautions For Xenon Headlamp Service . . . .
Working with HFC-134a (R-134a) . . . . . . ...
General Refrigerant Precaution . . . . . . . ..
Refrigerant Connection . . . . . . . . . . ...
Service Equipment . . . . . . . . . . . . ..
COMPRESSOR . . . . . . . . . . . . ..
General Precautions . . . . . . . . . . . ...
FLUORESCENT LEAK DETECTOR . . . . .
General Precautions . . . . . . . . . . . ...
PREPARATION . . . . . . . . . . ...
PREPARATION . . . . . . . . . . . . .
Special Service Tool . . . . . . . . . . . .
Sealant or/and Lubricant . . . . . . . . . . .
ON-VEHICLE MAINTENANCE . . . . .
REFRIGERANT . . . . . . . . . . . . .
Collection and Charge . . . . . . . . . . . .
LUBRICANT . . . . . . . . . . . . . ..
Maintenance of Lubricant Quantity . . . . . . ..
Lubricant Adjusting Procedure for Components
Replacement Except Compressor . . . . . . ...
Lubricant Adjusting Procedure for Compressor
Replacement . . . . . . . . . . . . . . ...
REFRIGERATION SYSTEM . . . . . . . .
Inspection . . . . . . . . . . . . . . . .
Performance Chart . . . . . . . . . . . . ..
Refrigerant Leakages . . . . . . . . . . . ..
FLUORESCENT LEAK DETECTOR . . . .
Inspection . . . . . . . . . . . . . . . .
ELECTRICAL LEAK DETECTOR . . . . .
Inspection . . . . . . . . . . . . . . . .
ON-VEHICLE REPAIR . . . . . . . . .
COMPRESSOR . . . . . . . . . . . . .
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
Inspection . . . . . . . . . . . . . . . .
LOW-PRESSURE FLEXIBLE HOSE . . . .
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
HIGH-PRESSURE FLEXIBLE HOSE . . . ...
Exploded View . . . . . . . . . . . . . . .
HA-2
LOW-PRESSURE PIPE . . . . . . . . . .
Exploded View . . . . . . . . . . . . . ....
Removal and Installation . . . . . . . . . ....
HIGH-PRESSURE PIPE . . . . . . . . .
Exploded View . . . . . . . . . . . . . ....
Removal and Installation . . . . . . . . . ....
CONDENSER . . . . . . . . . . . . .
Exploded View . . . . . . . . . . . . . ....
Removal and Installation . . . . . . . . . ....
CONDENSER PIPE ASSEMBLY . . . . . ..
Exploded View . . . . . . . . . . . . . ....
Removal and Installation . . . . . . . . . ....
LIQUID TANK . . . . . . . . . . . . .
Exploded View . . . . . . . . . . . . . ....
Removal and Installation . . . . . . . . . ....
REFRIGERANT PRESSURE SENSOR . . .
Exploded View . . . . . . . . . . . . . ....
Removal and Installation . . . . . . . . . ....
EVAPORATOR . . . . . . . . . . . . ..
Exploded View . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
EVAPORATOR PIPE ASSEMBLY . . . . .
Exploded View . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
EXPANSION VALVE . . . . . . . . . . .
Exploded View . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
SERVICE DATA AND SPECIFICATIONS
(SDS) . . . . . . . . . . . . . . ..
SERVICE DATA AND SPECIFICATIONS
(SDS) . . . . . . . . . . . . . . . . .
Compressor . . . . . . . . . . . . . . .
Lubricant . . . . . . . . . . . . . . . . .
Refrigerant . . . . . . . . . . . . . . . ..
Engine Idling Speed . . . . . . . . . . . .
DIAGNOSIS AND REPAIR WORK FLOW
HA-3
< BASIC INSPECTION >
C
D
E
F
G
H
J
K
L
M
A
B
HA
N
O
P
BASIC INSPECTION
DIAGNOSIS AND REPAIR WORK FLOW
Work Flow
INFOID:0000000003795801
OVERALL SEQUENCE
*1: Refer to the following.
•
(WITHOUT 7 INCH DISPLAY)
•
HAC-212, "WITHOUT INTELLIGENT AIR CONDITIONER SYSTEM : DTC Index"
[WITH 7 INCH DISPLAY
(WITHOUT INTELLIGENT AIR CONDITIONER SYSTEM)]
•
HAC-224, "WITH INTELLIGENT AIR CONDITIONER SYSTEM : DTC Index"
[WITH 7 INCH DISPLAY
(WITH INTELLIGENT AIR CONDITIONER SYSTEM)]
*2: Refer to the following.
•
HAC-87, "Diagnosis Chart By Symptom"
(WITHOUT 7 INCH DISPLAY)
•
HAC-226, "Diagnosis Chart By Symptom"
(WITH 7 INCH DISPLAY)
DETAILED FLOW
1.
OBTAIN INFORMATION ABOUT SYMPTOM
Interview the customer to obtain as much information as possible about the conditions and environment under
which the malfunction occurred.
>> GO TO 2.
JSIIA0943GB
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст