Nissan Teana J32. Instruction — part 507
EX-4
< ON-VEHICLE MAINTENANCE >
EXHAUST SYSTEM
ON-VEHICLE MAINTENANCE
EXHAUST SYSTEM
Inspection
INFOID:0000000003793260
Check exhaust pipes, muffler and mounting for improper attachment,
leakage, cracks, damage or deterioration.
• If anything is found, repair or replace damaged parts.
SMA211A
EXHAUST SYSTEM
EX-5
< ON-VEHICLE REPAIR >
C
D
E
F
G
H
I
J
K
L
M
A
EX
N
P
O
ON-VEHICLE REPAIR
EXHAUST SYSTEM
Exploded View
INFOID:0000000003793261
Removal and Installation
INFOID:0000000003793262
REMOVAL
Disconnect each joint and mounting using power tool.
INSTALLATION
Note the following, and install in the reverse order of removal.
• If exhaust front tube stud bolts were removed, and install them and tighten to the specified torque below.
CAUTION:
• Always replace exhaust tube gaskets with new ones when reassembling.
• If heat insulator is badly deformed, repair or replace exhaust front tube/center muffler. If deposits
such as mud pile up on the heat insulator, remove them.
1.
Main muffler (RH)
2.
Mounting rubber
3.
Gasket
4.
Exhaust front tube
5.
Ring gasket
6.
Mounting rubber
7.
Mounting rubber
8.
Center muffler
9.
Mounting rubber
10. Main muffler (LH)
11. Ring gasket
12. Mounting rubber
13. Dynamic damper
JPBIA2203GB
: 14.7 N·m (1.5 kg-m, 11 ft-lb)
EX-6
< ON-VEHICLE REPAIR >
EXHAUST SYSTEM
• Remove deposits from the sealing surface of each connection. Connect them securely to avoid
gases leakage.
• When installing each mounting rubber, use silicon oil to avoid twisting.
• Temporarily tighten mounting nuts and bolts. Check each part for unusual interference, and then
tighten them to the specified torque.
• When installing each mounting rubber, avoid twisting or unusual extension in up/down, front/rear
and right/left directions.
Inspection
INFOID:0000000003793263
INSPECTION AFTER INSTALLATION
• Check clearance between tail tube and rear bumper is even.
• With engine running, check exhaust tube joints for gas leakage and unusual noises.
• Check to ensure that mounting brackets and mounting rubbers are installed properly and free from undue
stress. Improper installation could result in excessive noise and vibration.
EXL-1
DRIVER CONTROLS
C
D
E
F
G
H
I
J
K
M
SECTION
EXL
A
B
EXL
N
O
P
CONTENTS
EXTERIOR LIGHTING SYSTEM
XENON TYPE
BASIC INSPECTION . . . . . . . . .
DIAGNOSIS AND REPAIR WORKFLOW . . ..
Work Flow . . . . . . . . . . . . . . . .....
INSPECTION AND ADJUSTMENT . . . . . .
ADDITIONAL SERVICE WHEN REPLACING
CONTROL UNIT . . . . . . . . . . . . . . ..
ADDITIONAL SERVICE WHEN REPLACING
CONTROL UNIT : Description . . . . . . . . ..
ADDITIONAL SERVICE WHEN REPLACING
CONTROL UNIT : Special Repair Requirement . ...
CONFIGURATION (HEADLAMP LEVELIZER) . . ..
CONFIGURATION (HEADLAMP LEVELIZER) :
Description . . . . . . . . . . . . . . . ....
CONFIGURATION (HEADLAMP LEVELIZER) :
Special Repair Requirement . . . . . . . . .....
SENSOR INITIALIZE . . . . . . . . . . . . ...
SENSOR INITIALIZE : Description . . . . . . .
SENSOR INITIALIZE : Special Repair Require-
ment (HEADLAMP AIMING CONTROL SYSTEM)
.
FUNCTION DIAGNOSIS . . . . . . . ..
HEADLAMP SYSTEM . . . . . . . . . .
System Diagram . . . . . . . . . . . . . ..
System Description . . . . . . . . . . . . .
Component Parts Location . . . . . . . . . ..
Component Description . . . . . . . . . . ..
AUTO LIGHT SYSTEM . . . . . . . . . ..
System Diagram . . . . . . . . . . . . . ..
System Description . . . . . . . . . . . . .
Component Parts Location . . . . . . . . . ..
Component Description . . . . . . . . . . ..
HEADLAMP AIMING CONTROL SYSTEM
(AUTO) . . . . . . . . . . . . . . . ..
System Diagram . . . . . . . . . . . . . ..
System Description . . . . . . . . . . . . ..
Component Parts Location . . . . . . . . . ..
Component Description . . . . . . . . . . ...
FRONT FOG LAMP SYSTEM . . . . . . ...
System Diagram . . . . . . . . . . . . . ..
System Description . . . . . . . . . . . . ..
Component Parts Location . . . . . . . . . ..
Component Description . . . . . . . . . . ..
TURN SIGNAL AND HAZARD WARNING
LAMP SYSTEM . . . . . . . . . . . . .
System Diagram . . . . . . . . . . . . . ..
System Description . . . . . . . . . . . . ..
Component Parts Location . . . . . . . . . ..
Component Description . . . . . . . . . . ..
PARKING, LICENSE PLATE AND TAIL
LAMPS SYSTEM . . . . . . . . . . . ..
System Diagram . . . . . . . . . . . . . ..
System Description . . . . . . . . . . . . ..
Component Parts Location . . . . . . . . . ..
Component Description . . . . . . . . . . ..
REAR FOG LAMP SYSTEM . . . . . . . .
System Diagram . . . . . . . . . . . . . ..
System Description . . . . . . . . . . . . ..
Component Parts Location . . . . . . . . . ..
Component Description . . . . . . . . . . ..
EXTERIOR LAMP BATTERY SAVER SYS-
TEM . . . . . . . . . . . . . . . . ...
System Diagram . . . . . . . . . . . . . ..
System Description . . . . . . . . . . . . ..
Component Parts Location . . . . . . . . . ..
Component Description . . . . . . . . . . ..
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст