Nissan Teana J32. Instruction — part 469
EC-414
< SERVICE DATA AND SPECIFICATIONS (SDS)
[VQ25DE, VQ35DE]
SERVICE DATA AND SPECIFICATIONS (SDS)
SERVICE DATA AND SPECIFICATIONS (SDS)
SERVICE DATA AND SPECIFICATIONS (SDS)
Idle Speed
INFOID:0000000003856889
Ignition Timing
INFOID:0000000003856890
Calculated Load Value
INFOID:0000000003856891
Mass Air Flow Sensor
INFOID:0000000003856892
*: Engine is warmed up to normal operating temperature and running under no load.
Condition
Specification
No load (in P or N position)
600
±
50 rpm
Condition
Specification
No load (in P or N position)
12
±
5
°
BTDC
Condition
Specification (Using CONSULT-III or GST)
At idle
10 – 35 %
At 2,500 rpm
10 – 35 %
Supply voltage
Battery voltage (11 – 14 V)
Output voltage at idle (in N position)
0.9 – 1.2 V*
Mass air flow (Using CONSULT-III or GST)
2.0 – 6.0 g·m/sec at idle*
7.0 – 20.0 g·m/sec at 2,500 rpm*
EM-1
ENGINE
C
D
E
F
G
H
I
J
K
L
M
SECTION
EM
A
EM
N
O
P
CONTENTS
ENGINE MECHANICAL
SYMPTOM DIAGNOSIS . . . . . . . ...
NOISE, VIBRATION AND HARSHNESS
(NVH) TROUBLESHOOTING . . . . . . . .
NVH Troubleshooting - Engine Noise . . . . . ...
Use the Chart Below to Help You Find the Cause
of the Symptom . . . . . . . . . . . . . .....
PRECAUTION . . . . . . . . . . . ...
PRECAUTIONS . . . . . . . . . . . . ...
Precaution for Procedure without Cowl Top Cover
. ..
Precaution Necessary for Steering Wheel Rota-
tion after Battery Disconnect . . . . . . . . .....
Precaution for Drain Engine Coolant and Engine
Oil . . . . . . . . . . . . . . . . . . . ..
Precaution for Disconnecting Fuel Piping . . . .....
Precaution for Removal and Disassembly . . . ....
Precaution for Inspection, Repair and Replace-
ment . . . . . . . . . . . . . . . . . . ..
Precaution for Assembly and Installation . . . . ..
Precaution for Angle Tightening . . . . . . . ....
Precaution for Liquid Gasket . . . . . . . . .....
PREPARATION . . . . . . . . . . .
PREPARATION . . . . . . . . . . . . ...
Special Service Tool . . . . . . . . . . . .....
Commercial Service Tool . . . . . . . . . . ..
ON-VEHICLE MAINTENANCE . . . . .
DRIVE BELT . . . . . . . . . . . . . ...
Exploded View . . . . . . . . . . . . . .
Checking . . . . . . . . . . . . . . . . .
Tension Adjustment . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
AIR CLEANER FILTER . . . . . . . . . ..
Removal and Installation . . . . . . . . . . .
SPARK PLUG . . . . . . . . . . . . ...
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
Inspection . . . . . . . . . . . . . . . .
CAMSHAFT VALVE CLEARANCE . . . . ..
Inspection and Adjustment . . . . . . . . . ..
COMPRESSION PRESSURE . . . . . . ...
Inspection . . . . . . . . . . . . . . . .
ON-VEHICLE REPAIR . . . . . . . . .
ENGINE COVER . . . . . . . . . . . ...
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
DRIVE BELT AUTO TENSIONER AND IDLER
PULLEY . . . . . . . . . . . . . . . .
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
AIR CLEANER AND AIR DUCT . . . . . ...
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
Inspection . . . . . . . . . . . . . . . .
INTAKE MANIFOLD COLLECTOR . . . . ..
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
INTAKE MANIFOLD . . . . . . . . . . .
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
Inspection . . . . . . . . . . . . . . . .
EXHAUST MANIFOLD AND THREE WAY
CATALYST . . . . . . . . . . . . . .
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
EM-2
OIL PAN AND OIL STRAINER . . . . . . ..
Exploded View . . . . . . . . . . . . . ....
Removal and Installation . . . . . . . . . ....
Inspection . . . . . . . . . . . . . . . ...
FUEL INJECTOR AND FUEL TUBE . . . . .
Exploded View . . . . . . . . . . . . . ....
Removal and Installation . . . . . . . . . ....
Inspection . . . . . . . . . . . . . . . ...
IGNITION COIL, SPARK PLUG AND ROCK-
ER COVER . . . . . . . . . . . . . . .
Exploded View . . . . . . . . . . . . . ....
Removal and Installation . . . . . . . . . ....
TIMING CHAIN . . . . . . . . . . . . ..
Exploded View . . . . . . . . . . . . . ....
Removal and Installation . . . . . . . . . ....
Inspection . . . . . . . . . . . . . . . ...
REMOVAL AND INSTALLATION . . . ...
ENGINE ASSEMBLY . . . . . . . . . . .
Exploded View . . . . . . . . . . . . . ....
Removal and Installation . . . . . . . . . ....
Inspection . . . . . . . . . . . . . . . ...
DISASSEMBLY AND ASSEMBLY . . . .
ENGINE STAND SETTING . . . . . . . .
Setting . . . . . . . . . . . . . . . . ....
ENGINE UNIT . . . . . . . . . . . . .
Disassembly . . . . . . . . . . . . . . ...
Assembly . . . . . . . . . . . . . . . ....
REAR TIMING CHAIN CASE . . . . . . .
Exploded View . . . . . . . . . . . . . ....
Disassembly and Assembly . . . . . . . . ....
CAMSHAFT . . . . . . . . . . . . . ...
Exploded View . . . . . . . . . . . . . ....
Removal and Installation . . . . . . . . . ....
Inspection . . . . . . . . . . . . . . . ...
OIL SEAL . . . . . . . . . . . . . . ...
VALVE OIL SEAL . . . . . . . . . . . . . .
VALVE OIL SEAL : Removal and Installation . . .
FRONT OIL SEAL . . . . . . . . . . . . . .
FRONT OIL SEAL : Removal and Installation . .
REAR OIL SEAL . . . . . . . . . . . . . ...
REAR OIL SEAL : Removal and Installation . . ...
CYLINDER HEAD . . . . . . . . . . . ..
Exploded View . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
Disassembly and Assembly . . . . . . . . ..
Inspection . . . . . . . . . . . . . . . ..
CYLINDER BLOCK . . . . . . . . . . ..
Exploded View . . . . . . . . . . . . . ..
Disassembly and Assembly . . . . . . . . ..
Inspection . . . . . . . . . . . . . . . ..
HOW TO SELECT PISTON AND BEARING ...
Description . . . . . . . . . . . . . . .
Piston . . . . . . . . . . . . . . . . .
Connecting Rod Bearing . . . . . . . . . .
Main Bearing . . . . . . . . . . . . . .
SERVICE DATA AND SPECIFICATIONS
(SDS) . . . . . . . . . . . . . . .
SERVICE DATA AND SPECIFICATIONS
(SDS) . . . . . . . . . . . . . . . .
General Specification . . . . . . . . . . ...
Drive Belt . . . . . . . . . . . . . . . ..
Spark Plug . . . . . . . . . . . . . . .
Intake Manifold . . . . . . . . . . . . . ..
Exhaust Manifold . . . . . . . . . . . . ..
Camshaft . . . . . . . . . . . . . . . ...
Cylinder Head . . . . . . . . . . . . . ..
Cylinder Block . . . . . . . . . . . . . ..
Main Bearing . . . . . . . . . . . . . .
NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING
EM-3
< SYMPTOM DIAGNOSIS >
C
D
E
F
G
H
I
J
K
L
M
A
EM
N
P
O
SYMPTOM DIAGNOSIS
NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING
NVH Troubleshooting - Engine Noise
INFOID:0000000003802222
JPBIA1711GB
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст