Nissan Teana J32. Instruction — part 1098
SRC-146
< SYMPTOM DIAGNOSIS >
SRS AIR BAG WARNING LAMP DOES NOT TURN ON
SRS AIR BAG WARNING LAMP DOES NOT TURN ON
Diagnosis Procedure
INFOID:0000000003814107
1.
CHECK METER FUSE
Check the meter fuse. Refer to
Is 10A fuse [No.4, located in fuse block (J/B)] normal?
YES
>> GO TO 3.
NO
>> Replace the fuse GO TO 2.
2.
CHECK METER FUSE AGAIN
Turn ignition switch ON.
Check the meter fuse. Refer to
Did the meter fuse blow again?
YES
>> Repair or replace the related harness.
NO
>> INSPECTION END
3.
CHECK HARNESS CONNECTION
1.
Check harness connection between air bag diagnosis sensor unit and combination meter.
2.
Disconnect air bag diagnosis sensor unit connector and turn ignition switch ON.
Did air bag warning lamp turn ON?
YES
>> Replace air bag diagnosis sensor unit. Refer to
NO
>> Replace combination meter assembly. Refer to
PRECAUTIONS
SRC-147
< PRECAUTION >
C
D
E
F
G
I
J
K
L
M
A
B
SRC
N
O
P
PRECAUTION
PRECAUTIONS
Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT
PRE-TENSIONER"
INFOID:0000000003814141
The Supplemental Restraint System such as “AIR BAG” and “SEAT BELT PRE-TENSIONER”, used along
with a front seat belt, helps to reduce the risk or severity of injury to the driver and front passenger for certain
types of collision. Information necessary to service the system safely is included in the “SRS AIRBAG” and
“SEAT BELT” of this Service Instruction.
WARNING:
• To avoid rendering the SRS inoperative, which could increase the risk of personal injury or death in
the event of a collision which would result in air bag inflation, all maintenance must be performed by
an authorized NISSAN/INFINITI dealer.
• Improper maintenance, including incorrect removal and installation of the SRS, can lead to personal
injury caused by unintentional activation of the system. For removal of Spiral Cable and Air Bag
Module, see the “SRS AIRBAG”.
• Never use electrical test equipment on any circuit related to the SRS unless instructed to in this Ser-
vice Instruction. SRS wiring harnesses can be identified by yellow and/or orange harnesses or harness
connectors.
Service
INFOID:0000000003814109
• Do not use electrical test equipment to check SRS circuits unless instructed to in this Service Instruction.
• Before servicing the SRS, turn ignition switch OFF, disconnect battery negative terminal and wait at least 3
minutes.
For approximately 3 minutes after the battery negative terminal is removed, it is still possible for the air bag
and seat belt pre-tensioner to deploy. Therefore, do not work on any SRS connectors or wires until at least 3
minutes have elapsed.
• Diagnosis sensor unit must always be installed with their arrow marks “
⇐
” pointing towards the front of the
vehicle for proper operation. Also check diagnosis sensor unit for cracks, deformities or rust before installa-
tion and replace as required.
• The spiral cable must be aligned in the neutral position since its rotations are limited. Do not turn steering
wheel and column after removal of steering gear.
• Handle air bag module carefully. Always place driver and front passenger air bag modules with the pad side
facing upward and seat mounted front side air bag module standing with the stud bolt side facing down.
• Conduct self-diagnosis to check entire SRS for proper function after replacing any components.
• After air bag inflates, the front instrument panel assembly should be replaced if damaged.
• Always replace instrument panel pad following front passenger air bag deployment.
ST-1
STEERING
C
D
E
F
H
I
J
K
L
M
SECTION
ST
A
B
ST
N
O
P
CONTENTS
STEERING SYSTEM
SYMPTOM DIAGNOSIS . . . . . . . ...
NOISE, VIBRATION AND HARSHNESS
(NVH) TROUBLESHOOTING . . . . . . . .
NVH Troubleshooting Chart . . . . . . . . . ..
PRECAUTION . . . . . . . . . . . ...
PRECAUTIONS . . . . . . . . . . . . ...
Precaution Necessary for Steering Wheel Rota-
tion after Battery Disconnect . . . . . . . . .....
Service Notice or Precautions for Steering System
. ..
PREPARATION . . . . . . . . . . .
PREPARATION . . . . . . . . . . . . ...
Special Service Tools . . . . . . . . . . . ....
ON-VEHICLE MAINTENANCE . . . . . .
POWER STEERING FLUID . . . . . . . .
Inspection . . . . . . . . . . . . . . . . ..
STEERING WHEEL . . . . . . . . . . . .
Inspection . . . . . . . . . . . . . . . . ..
ON-VEHICLE REPAIR . . . . . . . . .
STEERING WHEEL . . . . . . . . . . .
Exploded View . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
STEERING COLUMN . . . . . . . . . . .
Exploded View . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
Inspection . . . . . . . . . . . . . . . .
LOWER SHAFT . . . . . . . . . . . .
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
Inspection . . . . . . . . . . . . . . . .
STEERING GEAR AND LINKAGE . . . . ...
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
Disassembly and Assembly . . . . . . . . . .
Inspection . . . . . . . . . . . . . . . .
POWER STEERING OIL PUMP . . . . . ...
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
Disassembly and Assembly . . . . . . . . . .
Inspection . . . . . . . . . . . . . . . .
HYDRAULIC LINE . . . . . . . . . . .
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
SERVICE DATA AND SPECIFICATIONS
(SDS) . . . . . . . . . . . . . . .
SERVICE DATA AND SPECIFICATIONS
(SDS) . . . . . . . . . . . . . . . . .
General Specifications . . . . . . . . . . . .
Steering Wheel Axial End Play and Play . . . . .
Steering Wheel Turning Force . . . . . . . . .
Steering Angle . . . . . . . . . . . . . . .
Steering Column Length . . . . . . . . . . ..
Steering Column Mounting Dimensions . . . . ..
Steering Column Operating Range . . . . . . .
Lower Shaft Sliding Range . . . . . . . . . ..
Rack Sliding Force . . . . . . . . . . . . ..
Rack Stroke . . . . . . . . . . . . . . . .
Socket Swing Force and Rotating Torque . . . ...
Socket Axial End Play . . . . . . . . . . . .
Inner Socket Length . . . . . . . . . . . .
ST-2
< SYMPTOM DIAGNOSIS >
NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING
SYMPTOM DIAGNOSIS
NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING
NVH Troubleshooting Chart
INFOID:0000000003806305
Use the chart below to find the cause of the symptom. If necessary, repair or replace these parts.
×
: Applicable
Reference
—
NVH in DLN
section.
NVH in DLN
section.
NVH in F
AX, RAX
, FSU, RSU section.
NVH in WT
se
ct
io
n.
NVH in WT
se
ct
io
n.
NVH in F
AX section.
NVH in BR section.
Possible cause and SUSPECTED PARTS
F
lui
d l
e
v
e
l
Air i
n
h
y
drau
lic s
y
s
te
m
Oute
r/in
ne
r s
o
c
k
e
t b
a
ll jo
in
t s
w
ing
in
g
t
o
rq
ue
Oute
r/in
ne
r socke
t b
a
ll jo
in
t ro
ta
ti
ng
to
rqu
e
Oute
r/in
ne
r s
o
c
k
e
t b
a
ll jo
in
t e
n
d
pl
ay
S
tee
rin
g
f
lui
d l
e
a
k
a
g
e
S
te
e
ri
ng
whe
e
l
pl
ay
S
te
e
ri
ng
ge
ar ra
c
k
s
lid
in
g
forc
e
Driv
e b
e
lt
lo
os
en
es
s
Im
prop
er ste
e
ri
ng
whe
e
l
Im
prop
er ins
ta
lla
ti
on or
lo
o
s
e
n
e
s
s
o
f
ti
lt loc
k
le
ve
r
M
o
u
n
ti
ng
lo
os
en
es
s
S
tee
rin
g
c
o
lu
m
n
d
e
fo
rm
at
io
n
or da
ma
ge
Im
prop
er
ins
ta
lla
ti
on
or l
o
o
s
e
n
e
s
s
o
f s
tee
rin
g
c
o
lu
m
n
S
tee
rin
g
l
in
ka
g
e
lo
os
en
es
s
PROPELLER SHAF
T
DIFFERE
N
T
IAL
AXLE
and
SUSPENSION
TIRE
ROA
D
WHEEL
DRIVE SHA
F
T
BRAKE
Symptom
Steering
Noise
× × × × × × × × ×
× ×
× × × × × × ×
Shake
×
×
×
× × × × ×
Vibration
×
× × ×
×
× ×
×
Shimmy
×
×
×
× × ×
×
Judder
×
×
× × ×
×
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст