Nissan Almera Tino V10. Instruction — part 276
YBR379
Removal and Installation
NLBR0206
REMOVAL
NLBR0206S01
1.
Remove center console. Refer to BT-27.
2.
Disconnect harness connector.
3.
Remove installation nuts. Remove yaw rate/side G sensor.
CAUTION:
I
Do not drop or strike the yaw rate/side G sensor, because
it has little endurance to impact.
I
Do not use power tool etc., because Yaw rate/side G sen-
sor is weak for the impact.
INSTALLATION
NLBR0206S02
Install in the revers order of removal.
CAUTION:
I
Do not drop or strike the yaw rate/side G sensor, because
it has little endurance to impact.
G SENSOR
ESP/TCS/ABS
Removal and Installation
BR-152
YBR355
Removal and Installation
NLBR0207
Refer to ST-10.
NOTE:
Steering angle sensor is built into the spiral cable.
GI
MA
EM
LC
EC
FE
CL
MT
AT
AX
SU
ST
RS
BT
HA
SC
EL
IDX
STEERING ANGLE SENSOR
ESP/TCS/ABS
Removal and Installation
BR-153
General Specifications
NLBR0077
Unit: mm (in)
Engine
QG18DE
YD22DDT
YD22DDTi
Front Brake
Brake model
CL25VCG
Cylinder bore diameter
57.2 (2.2529)
Pad
Length
×
width
×
thickness
110.6
×
54.2
×
11.0 (4.35
×
2.13
×
0.433)
Rotor outer
diameter
×
thickness
280
×
28 (11.02
×
1.10)
Rear Brake
Brake model
CL11HDG (disc brake)
Cylinder bore diam-
eter
Cam & Strut type
38 (1.496)
Ball & Ramp type
38.2 (1.504)
Pad
Length
×
width
×
thickness
79.8
×
38.5
×
9.3 (3.142
×
1.516
×
0.37)
Rotor outer diameter
×
thickness
278
×
10 (10.94
×
0.39)
Master cylinder
Cylinder bore diameter
23.81 (15/16)
Brake booster
Booster model
S255
M215T
Diaphragm
Primary
255 (10.04)
230 (9.06)
Secondary
—
205 (8.07)
Specified brake fluid
DOT 4
Disc Brake
NLBR0078
Unit: mm (in)
Brake model
CL25VCG
CL11HDG
Pad wear limit
Minimum thickness
2.0 (0.078)
2.0 (0.079)
Rotor repair limit
Maximum runout
0.07 (0.0028)
0.07 (0.0028)
Minimum thickness
26.0 (1.024)
9 (0.35)
Brake Pedal
NLBR0079
Unit: mm (in)
Free height “H”*
LHD
M/T
155.9 - 164.8 (6.14 - 6.49)
A/T
164.7 - 173.9 (6.48 - 6.85)
RHD
M/T
154.8 - 164.6 (6.09 - 6.48)
A/T
164.0 - 173.4 (6.46 - 6.83)
Clearance “C” between pedal stopper and threaded end of stop lamp switch or brake switch
0.75 - 2.00 (0.0295 - 0.0787)
*: Measured from surface of dash panel to surface of pedal pad
Parking Brake
NLBR0080
Type
Center lever
Number of notches
[under force of 196 N (20 kg, 44 lb)]
5 - 6
Number of notches
when warning lamp switch comes on
1
SERVICE DATA AND SPECIFICATIONS (SDS)
General Specifications
BR-154
BODY & TRIM
CONTENTS
PRECAUTIONS . . . . . . . . . . . . . . . ...3
Service Notice. . . . . . . . . . . . . . . ..3
Supplemental Restraint System (SRS)
. . . ...3
CLIP AND FASTENER. . . . . . . . . . . . . 4
Description . . . . . . . . . . . . . . . . ...4
CHASSIS AND BODY MAINTENANCE . . . . . . .6
Checking Body Corrosion. . . . . . . . . . . 6
BODY FRONT END. . . . . . . . . . . . . . .7
Removal and Installation . . . . . . . . . . . .7
. . . . . . . . . 7
BODY REAR END AND OPENER. . . . . . . . 10
Removal and Installation . . . . . . . . . . ...10
. . . . . . . . . 10
DOOR. . . . . . . . . . . . . . . . . . . .13
Adjustment . . . . . . . . . . . . . . . . .13
. . . . . . . . . . ..13
Front Door Glass . . . . . . . . . . . . . ...14
FRONT DOOR GLASS AND REGULATOR
. . . . 14
Front Door Limit Switch Reset (Driver side only). ..15
. . . . . . . . . . . ..15
. . . . . . . . . . . 15
Rear Door Glass. . . . . . . . . . . . . . 16
. . . . ..16
Front Door Lock. . . . . . . . . . . . . . .18
. . . . ...18
. . . . . . . . . . . . . . . ...18
Rear Door Lock . . . . . . . . . . . . . . .20
. . . . ...20
. . . . . . . . . . . . . . . ...21
INSTRUMENT PANEL ASSEMBLY . . . . . . . .22
Removal and Installation . . . . . . . . . . ...22
SIDE AND FLOOR TRIM. . . . . . . . . . . ...27
Removal and Installation . . . . . . . . . . ...27
LUGGAGE ROOM TRIM . . . . . . . . . . . ...30
Removal and Installation . . . . . . . . . . ...30
DOOR TRIM . . . . . . . . . . . . . . . . ...31
Removal and Installation . . . . . . . . . . ...31
ROOF TRIM . . . . . . . . . . . . . . . . ...34
Removal and Installation . . . . . . . . . . ...34
BACK DOOR TRIM . . . . . . . . . . . . . ...36
Removal and Installation . . . . . . . . . . ...36
EXTERIOR . . . . . . . . . . . . . . . . . .37
Removal and Installation . . . . . . . . . . ...37
FRONT SEAT . . . . . . . . . . . . . . . . 45
Removal and Installation . . . . . . . . . . ...45
. . . . . . . . . . . . . . 46
Heated Seat. . . . . . . . . . . . . . . ...47
Active Head Restraint. . . . . . . . . . . . 47
. . . . . . . . . . . 47
REAR SEAT. . . . . . . . . . . . . . . . ...48
Removal and Installation . . . . . . . . . . ...48
. . . . . . . . . . . ..49
SUNROOF. . . . . . . . . . . . . . . . . ..50
Adjustment . . . . . . . . . . . . . . . . .50
Removal. . . . . . . . . . . . . . . . . .50
Trouble Diagnoses. . . . . . . . . . . . . .54
. . . . . ..54
. . . . . . . . . . . . . . .55
. . . . . . . . . . . . . . 56
. . . . . . . . . . . . . .56
WINDSHIELD AND WINDOWS . . . . . . . . . 58
Removal and Installation . . . . . . . . . . ...58
. . . . . . . . . . . . . . . ...58
. . . . . . . . . . . . . . 58
. . . . . . . . . . . . . . ..59
. . . . . . . . . . . . . . 60
. . . . . . . . . . . 61
DOOR MIRROR . . . . . . . . . . . . . . . .62
Removal and Installation . . . . . . . . . . ...62
REAR VIEW MIRROR . . . . . . . . . . . . ...63
Removal and Installation . . . . . . . . . . ...63
. . . . . . . . . . . . . . . ...63
. . . . . . . . . . . . . . 63
BODY (ALIGNMENT) . . . . . . . . . . . . . 64
Alignment . . . . . . . . . . . . . . . . ...64
. . . . . . . . . . 65
GI
MA
EM
LC
EC
FE
CL
MT
AT
AX
SU
BR
ST
RS
HA
SC
EL
IDX
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст