Nissan Tiida C11. Instruction — part 854
HAC-80
< SYMPTOM DIAGNOSIS >
[MANUAL AIR CONDITIONER]
INSUFFICIENT COOLING
Gauge indication
Refrigerant cycle
Probable cause
Corrective action
Low-pressure side becomes nega-
tive.
Liquid tank or front/rear side of
expansion valve’s pipe is frost-
ed or dewed.
High-pressure side is closed
and refrigerant does not flow.
↓
Expansion valve or liquid tank
is frosted.
Leave the system at rest until
no frost is present. Start it
again to check whether or not
the malfunction is caused by
water or foreign particles.
• If water is the cause, initially
cooling is okay. Then the wa-
ter freezes causing a block-
age. Drain water from
refrigerant or replace refrig-
erant.
• If due to foreign particles, re-
move expansion valve and
remove the particles with dry
and compressed air (not
shop air).
• If either of the above meth-
ods cannot correct the mal-
function, replace expansion
valve.
• Replace liquid tank.
• Check oil for contamination.
AC362A
INSUFFICIENT HEATING
HAC-81
< SYMPTOM DIAGNOSIS >
[MANUAL AIR CONDITIONER]
C
D
E
F
G
H
J
K
L
M
A
B
HAC
N
O
P
INSUFFICIENT HEATING
Component Function Check
INFOID:0000000001547078
SYMPTOM: Insufficient heating
INSPECTION FLOW
1.
CONFIRM SYMPTOM BY PERFORMING OPERATIONAL CHECK - TEMPERATURE DECREASE
1.
Turn temperature control dial clockwise to maximum heat position.
2.
Check for hot air at discharge air outlets.
Can the symptom be duplicated?
YES
>> GO TO 3.
NO
>> GO TO 2.
2.
CHECK FOR ANY SYMPTOMS
Perform a complete operational check for any symptoms. Refer to
Does another symptom exist?
YES
>> Refer to
HAC-5, "How to Perform Trouble Diagnosis For Quick and Accurate Repair"
.
NO
>> System OK.
3.
CHECK FOR SERVICE BULLETINS
Check for any service bulletins.
>> GO TO 4.
4.
CHECK COOLANT SYSTEM
1.
Check engine coolant level. Refer to XX-XX, "*****" .
2.
Check hoses for leaks or kinks.
3.
Check Radiator cap. Refer to XX-XX, "*****" .
OK or NG
OK
>> GO TO 5.
NG
>> Repair/replace as necessary.
5.
CHECK AIR MIX DOOR CABLE
Check air mix door cable operation. Refer to XXXX AIR MIX DOOR CABLE ADJUSTMENT .
OK or NG
YES
>> GO TO 6.
NO
>> Adjust or replace air mix door cable. Refer to XXXX AIR MIX DOOR CABLE ADJUST. .
6.
CHECK AIR DUCTS
Check ducts for air leaks.
OK or NG
OK
>> GO TO 7.
NG
>> Repair air leaks.
7.
CHECK HEATER HOSE TEMPERATURES
1.
Start engine and warm it up to normal operating temperature.
2.
Touch both the inlet and outlet heater hoses.
Is the inlet hose hot and the outlet hose warm?
YES
>> GO TO 8.
NO
>> Both hoses warm: GO TO 9.
8.
CHECK ENGINE COOLANT TEMPERATURE SENSOR
Check engine control temperature sensor. Refer to XX-XX, "*****" .
OK or NG
OK
>> System OK.
HAC-82
< SYMPTOM DIAGNOSIS >
[MANUAL AIR CONDITIONER]
INSUFFICIENT HEATING
NG
>> Repair or replace as necessary. Retest.
9.
CHECK HEATER HOSES
Check heater hoses for proper installation.
OK or NG
OK
>> GO TO 10.
NG
>> Repair /replace as necessary. Retest GO TO 7.
10.
BACK FLUSH HEATER CORE
1.
Back flush heater core.
2.
Drain the water from the system.
3.
Refill system with new engine coolant. Refer to XX-XX, "*****" .
4.
Start engine and warm it up to normal operating temperature.
5.
Touch both the inlet and outlet heater hoses.
Is the inlet hose hot and the outlet hose warm? YES or NO
YES
>> System OK.
NO
>> Replace heater core and refill engine coolant. Refer to XXXX .
NOISE
HAC-83
< SYMPTOM DIAGNOSIS >
[MANUAL AIR CONDITIONER]
C
D
E
F
G
H
J
K
L
M
A
B
HAC
N
O
P
NOISE
Component Function Check
INFOID:0000000001547079
SYMPTOM: Noise
INSPECTION FLOW
*1. XXXX OPER. CHECK
*2. XXXX REMOVE OF COMPRESSOR *3. XXXX MAIN. OF OIL QUALITY IM
COMPR.
*4. XX-XX, "*****"
*5. XXXX REMOVE COMPRESSOR
WJIA2226E
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст