Nissan Altima L32. Instruction — part 616
SERVICE DATA AND SPECIFICATIONS (SDS)
EC-1585
< SERVICE DATA AND SPECIFICATIONS (SDS)
[VQ35DE]
C
D
E
F
G
H
I
J
K
L
M
A
EC
N
P
O
SERVICE DATA AND SPECIFICATIONS (SDS)
SERVICE DATA AND SPECIFICATIONS (SDS)
Idle Speed
INFOID:0000000004460289
*: Under the following conditions
• A/C switch: OFF
• Electric load: OFF (Lights, heater fan & rear window defogger)
• Steering wheel: Kept in straight-ahead position
Ignition Timing
INFOID:0000000004460290
*: Under the following conditions
• A/C switch: OFF
• Electric load: OFF (Lights, heater fan & rear window defogger)
• Steering wheel: Kept in straight-ahead position
Calculated Load Value
INFOID:0000000004362414
Mass Air Flow Sensor
INFOID:0000000004362415
*: Engine is warmed up to normal operating temperature and running under no load.
Transmission
Condition
Specification
CVT
No load* (in P or N position)
600
± 50 rpm
M/T
No load* (in neutral position)
600
± 50 rpm
Transmission
Condition
Specification
CVT
No load* (in P or N position)
18
± 2°BTDC
M/T
No load* (in neutral position)
18
± 2°BTDC
Condition
Specification (Using CONSULT-III or GST)
At idle
10 – 35 %
At 2,500 rpm
10 – 35 %
Supply voltage
Battery voltage (11 – 14 V)
Output voltage at idle (in N position)
0.9 – 1.2 V*
Mass air flow (Using CONSULT-III or GST)
2.0 – 6.0 g·m/sec at idle*
7.0 – 20.0 g·m/sec at 2,500 rpm*
EM-1
ENGINE
C
D
E
F
G
H
I
J
K
L
M
SECTION
EM
A
EM
N
O
P
CONTENTS
ENGINE MECHANICAL
QR25DE
PRECAUTION . . . . . . . . . . . ...
PRECAUTIONS . . . . . . . . . . . . ...
Necessary for Steering Wheel Rotation After Bat-
tery Disconnect . . . . . . . . . . . . . .....
Precaution for Draining Coolant . . . . . . . ....
Precaution for Disconnecting Fuel Piping . . . .....
Precaution for Removal and Disassembly . . . ....
Precaution for Inspection, Repair and Replace-
ment . . . . . . . . . . . . . . . . . . ..
Precaution for Assembly and Installation . . . . ..
Parts Requiring Angular Tightening . . . . . . ..
Precaution for Liquid Gasket . . . . . . . . .....
PREPARATION . . . . . . . . . . .
PREPARATION . . . . . . . . . . . . ...
Special Service Tool . . . . . . . . . . . .....
Commercial Service Tool . . . . . . . . . . ..
FUNCTION DIAGNOSIS . . . . . . . ..
NOISE, VIBRATION, AND HARSHNESS
(NVH) TROUBLESHOOTING . . . . . . .
NVH Troubleshooting - Engine Noise . . . . . .
Use the Chart Below to Help You Find the Cause
of the Symptom . . . . . . . . . . . . . ...
ON-VEHICLE MAINTENANCE . . . . .
SPARK PLUG . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
DRIVE BELTS . . . . . . . . . . . . .
Checking Drive Belts . . . . . . . . . . . ...
Tension Adjustment . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
Removal and Installation of Drive Belt Auto-ten-
sioner . . . . . . . . . . . . . . . . . ...
AIR CLEANER FILTER . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
CAMSHAFT VALVE CLEARANCE . . . . ..
Camshaft valve clearance . . . . . . . . . ...
COMPRESSION PRESSURE . . . . . . ...
Compression pressure . . . . . . . . . . .
ON-VEHICLE REPAIR . . . . . . . . .
AIR CLEANER AND AIR DUCT . . . . . ...
Removal and Installation . . . . . . . . . . .
INTAKE MANIFOLD . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
EXHAUST MANIFOLD AND THREE WAY
CATALYST . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
OIL PAN AND OIL STRAINER . . . . . . .
Removal and Installation . . . . . . . . . . .
IGNITION COIL . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
FUEL INJECTOR AND FUEL TUBE . . . .
Removal and Installation . . . . . . . . . . .
ROCKER COVER . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
CAMSHAFT . . . . . . . . . . . . . ...
Removal and Installation . . . . . . . . . . .
Inspection After Installation . . . . . . . . . .
Valve Clearance . . . . . . . . . . . . . ..
TIMING CHAIN . . . . . . . . . . . . ..
EM-2
OIL SEAL . . . . . . . . . . . . . . ...
Removal and Installation of Valve Oil Seal . . . .
Removal and Installation of Front Oil Seal . . . .
Removal and Installation of Rear Oil Seal . . . ..
CYLINDER HEAD . . . . . . . . . . . ..
Removal and Installation . . . . . . . . . ....
Disassembly and Assembly . . . . . . . . ....
Inspection After Disassembly . . . . . . . . .
REMOVAL AND INSTALLATION . . . ...
ENGINE ASSEMBLY . . . . . . . . . . .
Removal and Installation . . . . . . . . . ....
DISASSEMBLY AND ASSEMBLY . . . .
CYLINDER BLOCK . . . . . . . . . . ...
Disassembly and Assembly . . . . . . . . ....
Inspection After Disassembly . . . . . . . . .
HOW TO SELECT PISTON AND BEARING . .
How to Select Piston and Bearing . . . . . . ..
SERVICE DATA AND SPECIFICATIONS
(SDS) . . . . . . . . . . . . . . ...
SERVICE DATA AND SPECIFICATIONS
(SDS) . . . . . . . . . . . . . . . . ..
Standard and Limit . . . . . . . . . . . . .
VQ35DE
PRECAUTION . . . . . . . . . . .
PRECAUTIONS . . . . . . . . . . . ...
Necessary for Steering Wheel Rotation After Bat-
tery Disconnect . . . . . . . . . . . . . ..
Precaution for Drain Coolant . . . . . . . . .
Precaution for Disconnecting Fuel Piping . . . ..
Precaution for Removal and Disassembly . . . .
Precaution for Inspection, Repair and Replace-
ment . . . . . . . . . . . . . . . . . ...
Precaution for Assembly and Installation . . . ..
Parts Requiring Angular Tightening . . . . . ...
Precaution for Liquid Gasket . . . . . . . . .
PREPARATION . . . . . . . . . . ..
PREPARATION . . . . . . . . . . . ...
Special Service Tool . . . . . . . . . . . ..
Commercial Service Tool . . . . . . . . . ..
FUNCTION DIAGNOSIS . . . . . . .
NOISE, VIBRATION, AND HARSHNESS
(NVH) TROUBLESHOOTING . . . . . . ..
NVH Troubleshooting - Engine Noise . . . . .
Use the Chart Below to Help You Find the Cause
of the Symptom . . . . . . . . . . . . . .
ON-VEHICLE MAINTENANCE . . . . .
SPARK PLUG . . . . . . . . . . . . ...
Removal and Installation . . . . . . . . . ...
DRIVE BELTS . . . . . . . . . . . . ..
Checking Drive Belts . . . . . . . . . . . .
Tension Adjustment . . . . . . . . . . . ..
Removal and Installation . . . . . . . . . ...
Removal and Installation of Drive Belt Auto-ten-
sioner . . . . . . . . . . . . . . . . .
AIR CLEANER FILTER . . . . . . . . .
Removal and Installation . . . . . . . . . ...
CAMSHAFT VALVE CLEARANCE . . . . .
Valve Clearance . . . . . . . . . . . . .
COMPRESSION PRESSURE . . . . . . ..
On-Vehicle Service . . . . . . . . . . . ...
ON-VEHICLE REPAIR . . . . . . . ..
AIR CLEANER AND AIR DUCT . . . . . ...
Removal and Installation . . . . . . . . . ...
INTAKE MANIFOLD COLLECTOR . . . . .
Removal and Installation . . . . . . . . . ...
INTAKE MANIFOLD . . . . . . . . . . .
Removal and Installation . . . . . . . . . ...
EXHAUST MANIFOLD AND THREE WAY
CATALYST . . . . . . . . . . . . . ...
Removal and Installation . . . . . . . . . ...
OIL PAN AND OIL STRAINER . . . . . .
Removal and Installation . . . . . . . . . ...
IGNITION COIL . . . . . . . . . . . . .
Exploded View . . . . . . . . . . . . . ..
Removal and Installation LH . . . . . . . . .
Removal and Installation RH . . . . . . . .
FUEL INJECTOR AND FUEL TUBE . . . .
Removal and Installation . . . . . . . . . ...
ROCKER COVER . . . . . . . . . . . .
Exploded View . . . . . . . . . . . . . ..
Removal and Installation LH . . . . . . . . .
Removal and Installation RH . . . . . . . .
FRONT TIMING CHAIN CASE . . . . . . .
Removal and Installation . . . . . . . . . ...
TIMING CHAIN . . . . . . . . . . . . .
Component . . . . . . . . . . . . . . ...
Removal . . . . . . . . . . . . . . . .
Inspection . . . . . . . . . . . . . . . ..
EM-3
C
D
E
F
G
H
I
J
K
L
M
EM
A
N
O
P
REAR TIMING CHAIN CASE . . . . . . ...
Component . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . ...
CAMSHAFT . . . . . . . . . . . . . ..
Removal and Installation . . . . . . . . . ...
Inspection after Installation . . . . . . . . ...
OIL SEAL . . . . . . . . . . . . . . .
Removal and Installation of Valve Oil Seal . . ...
Removal and Installation of Front Oil Seal . . .
Removal and Installation of Rear Oil Seal . . .
CYLINDER HEAD . . . . . . . . . . .
Removal and Installation . . . . . . . . . ...
Disassembly and Assembly . . . . . . . . ..
Inspection After Disassembly . . . . . . . .
REMOVAL AND INSTALLATION . . . .
ENGINE ASSEMBLY . . . . . . . . . ...
Removal and Installation . . . . . . . . . ...
DISASSEMBLY AND ASSEMBLY . . .
CYLINDER BLOCK . . . . . . . . . . .
Disassembly and Assembly . . . . . . . . ...
Inspection . . . . . . . . . . . . . . . ..
Dowel Pin Alignment . . . . . . . . . . . .
SERVICE DATA AND SPECIFICATIONS
(SDS) . . . . . . . . . . . . . . ..
SERVICE DATA AND SPECIFICATIONS
(SDS) . . . . . . . . . . . . . . . ...
General Specification . . . . . . . . . . .
Drive Belt . . . . . . . . . . . . . . . ...
Spark Plug . . . . . . . . . . . . . . . .
Intake Manifold . . . . . . . . . . . . . ..
Exhaust Manifold . . . . . . . . . . . . ..
Camshaft . . . . . . . . . . . . . . . ...
Cylinder Head . . . . . . . . . . . . . ...
Cylinder Block . . . . . . . . . . . . . ...
Main Bearing . . . . . . . . . . . . . . .
Connecting Rod Bearing . . . . . . . . . ..
Drive Plate . . . . . . . . . . . . . . . .
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст