Nissan Terrano r20e. Instruction — part 368
Chassis and Body Maintenance
Abbreviations: R = Replace
I = Inspect. Correct or replace if necessary
L = Lubricate
T = Tighten
MAINTENANCE OPERATION
MAINTENANCE INTERVAL
Refer-
ence
page
Perform on a kilometer basis only.
km x 1,000
10
20
30
40
50
60
70
80
90
100
110
120
(miles x 1,000)
(6)
(12)
(18)
(24)
(30)
(36)
(42)
(48)
(54)
(60)
(66)
(72)
Underhood and under vehicle
Headlamp aiming
I
I
I
I
Wheel alignment (it necessary, rotate & balance wheels)
I
I
I
I
Brake pads, discs & other components*
I
I
I
I
Brake linings, drums & other components*
I
I
I
I
Foot brake, parking brake & clutch (for free play, stroke &
operation)
I
I
I
I
Brake booster vacuum hoses, connections, check valve
I
I
Brake & clutch, systems and fluid (for level and leaks)
I
I
I
I
Brake fluid*
R
R
Power steering fluid and lines (for level and leaks)
I
I
I
I
Air bag system
See NOTE (1)
Ventilation air filter*
R
R
R
R
Transfer and standard differential gear oil*
I
R
I
R
Instruction transmission oil
I
I
R
I
LSD gear oil*
I
R
I
R
Steering gar & linkage, axle & suspension parts, propeller shaft
and exhaust system*
I
I
I
I
Greasing points of steering gear linkage,
propeller shaft and suspension*
See NOTE (2)
L
L
L
L
Drive shafts*
I
I
I
I
Front wheel bearing grease*
I
R
I
R
Free running hub grease*
I
I
I
I
Body mounting bolts and nuts
T
T
T
T
Body corrosion
See NOTE (3)
NOTE: (1) Inspect after 10 years, then every 2 years.
(2) The propeller shaft should be re-greased daily if it is immersed in water.
(3) Inspect once per year.
* Maintenance items with “*” should be performed more frequently according to “Maintenance under severe driving
conditions”.
PERIODIC MAINTENANCE
Maintenance Schedule for Diesel Engine
Models (annual mileage > 30,000 km/year)
(Cont’d)
MA-10
Maintenance Under Severe Driving Conditions
(annual mileage < 30,000 km/year)
The maintenance intervals shown on the preceding pages are for normal operating conditions. If the vehicle
is mainly operated under severe driving conditions as shown below, more frequent maintenance must be per-
formed on the following items as shown in the table.
TD27Ti engine
Severe driving conditions
A — Driving under dusty conditions
B — Driving repeatedly short distances
C — Towing a trailer
D — Extensive idling
E — Driving in extremely adverse weather conditions or in areas where ambient temperature is either
extremely low or extremely high
F — Driving in high humidity areas or in mountainous areas
G — Driving in areas using salt or other corrosive materials
H — Driving on rough and/or muddy roads or in the desert
I — Driving with frequent use of brakes or in mountainous areas
J — Frequent driving in water
Driving condition
Maintenance item
Maintenance
operation
Maintenance interval
Reference page
A
B
C
D
.
.
.
.
.
.
Engine oil & engine oil filter
Replace
Every 5,000 km (3,000 miles) or
3 months
A
.
.
.
.
.
.
.
.
.
Air cleaner filter (dry paper type)
Clean
Every 10,000 km (6,000 miles) or
6 months
Replace
Every 20,000 km (12,000 miles)
or 12 months
A
.
.
.
E
.
.
.
.
.
Fuel filter
Replace
Every 20,000 km (12,000 miles)
or 12 months
A
.
.
.
.
F
.
.
.
.
Ventilation air filter
Replace
Every 20,000 km (12,000 miles)
or 12 months
.
.
.
.
.
F
.
.
.
.
Brake fluid
Replace
Every 20,000 km (12,000 miles)
or 12 months
.
.
C
.
.
.
.
H
.
.
Limited-slip differential (L.S.D.) gear oil
Replace
Every 30,000 km (18,000 miles)
or 18 months
.
.
C
.
.
.
.
H
.
.
Transfer & standard differential gear oil
Replace
Every 60,000 km (36,000 miles)
or 24 months
A
.
C
.
.
.
G
H
I
.
Brake pads/linings, discs/drums & other brake system components
Inspect
Every 10,000 km (6,000 miles) or
6 months
.
.
.
.
.
.
G
H
.
J
Greasing points of steering linkage, propeller shafts and suspension
Lubricate
Every 10,000 km (6,000 miles) or
6 months
.
.
.
.
.
.
G
H
.
.
Steering gear & linkage, axle & suspension parts, propeller shaft & exhaust system
Inspect
Every 10,000 km (6,000 miles) or
6 months
PERIODIC MAINTENANCE
MA-11
Driving condition
Maintenance item
Maintenance
operation
Maintenance interval
Reference page
.
.
C
.
.
.
.
H
.
.
Drive shafts
Inspect
Every 10,000 km (6,000 miles) or
6 months
.
.
.
.
.
.
.
.
.
J
Front wheel bearing grease & free running hub grease
Inspect
Every 10,000 km (6,000 miles) or
6 months
ZD30DDTi engine
Severe driving conditions
A — Driving under dusty conditions
B — Driving repeatedly short distances
C — Towing a trailer or caravan
D — Extensive idling
E — Driving in extremely adverse weather conditions or in areas where ambient temperatures are either
extremely low or extremely high
F — Driving in high humidity areas or in mountainous areas
G — Driving in areas using salt or other corrosive materials
H — Driving on rough and/or muddy roads or in the desert
I — Driving with frequent use of braking or in mountainous areas
J — Frequent off road use or driving in water
Driving condition
Maintenance item
Maintenance
operation
Maintenance interval
A
B
C
D
.
.
.
.
.
.
Engine oil & engine oil filter
Replace
Every 7,500 km (4,500 miles) or 6 months
A
.
.
.
.
.
.
.
.
.
Air cleaner filter
Replace
Every 30,000 km (18,000 miles) or 24 months
A
.
.
.
E
.
.
.
.
.
Fuel filter
Replace
Every 22,500 km (13,500 miles) or 18 months
A
.
C
.
.
.
G
H
I
.
Brake pads, rotors & other brake components
Inspect
Every 7,500 km (4,500 miles) or 6 months
.
.
.
.
.
F
.
.
.
.
Brake fluid
Replace
Every 15,000 km (9,000 miles) or 12 months
A
.
.
.
.
.
.
.
.
.
Ventilation air filter
Replace
Every 15,000 km (9,000 miles) or 12 months
.
.
C
.
.
.
.
H
.
.
Automatic transmission fluid
Replace
Every 30,000 km (18,000 miles) or 24 months
.
.
C
.
.
.
.
H
.
.
Transfer fluid and limited-slip differential (LSD) gear oil
Replace
Every 30,000 km (18,000 miles) or 24 months
.
.
C
.
.
.
.
H
.
.
Drive shaft & steering damper
Inspect
Every 7,500 km (4,500 miles) or 6 months
.
.
.
.
.
.
.
.
.
J
Front wheel bearing grease
Inspect
Every 7,500 km (4,500 miles) or 6 months
.
.
.
.
.
.
.
.
.
J
Free-running hub grease
Inspect
Every 7,500 km (4,500 miles) or 6 months
.
.
.
.
.
.
G
H
.
.
Steering gear & linkage, axle & suspension parts, propeller shaft & exhaust system
Inspect
Every 7,500 km (4,500 miles) or 6 months
PERIODIC MAINTENANCE
Maintenance Under Severe Driving Conditions
(annual mileage < 30,000 km/year) (Cont’d)
MA-12
Maintenance for off-road driving
Whenever you drive off-road through sand, mud or water as deep as the wheel hub, more frequent mainte-
nance may be required of the following items:
G
Brake pads and discs
G
Brake lining and drums
G
Brake lines and hoses
G
Wheel bearing grease and free-running hub grease
G
Differential, transmission and transfer oil
G
Steering linkage
G
Propeller shafts and front drive shafts
G
Air cleaner filter
G
Clutch housing (Check water entry.)
PERIODIC MAINTENANCE
Maintenance Under Severe Driving Conditions
(annual mileage < 30,000 km/year) (Cont’d)
MA-13
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст