Nissan Titan A60. Instruction — part 213
CHG
CHARGING SYSTEM
CHG-19
< SYMPTOM DIAGNOSIS >
C
D
E
F
G
H
I
J
K
L
B
A
O
P
N
SYMPTOM DIAGNOSIS
CHARGING SYSTEM
Symptom Table
INFOID:0000000006161771
Symptom
Reference
Battery discharged
The charge warning lamp does not illuminate when the ignition
switch is set to ON.
The charge warning lamp does not turn OFF after the engine
starts.
The charging warning lamp turns ON when increasing the engine
speed.
CHG-20
< REMOVAL AND INSTALLATION >
GENERATOR
REMOVAL AND INSTALLATION
GENERATOR
Removal and Installation
INFOID:0000000006161772
REMOVAL
1. Disconnect the negative battery terminal. Refer to
PG-76, "Removal and Installation"
2. Remove the fan shroud. Refer to
CO-16, "Removal and Installation"
3. Remove the drive belt. Refer to
EM-13, "Removal and Installation"
.
4. Remove lower bracket bolts and remove lower bracket, using power tools.
5. Remove the upper bolt, using power tools.
6. Remove the generator harness terminal nut connectors.
7. Remove the generator.
INSTALLATION
Installation is in the reverse order of removal.
• Install the generator and check the tension of the drive belt. Refer to
CAUTION:
Tighten terminal nut carefully.
• This model includes the variable voltage control system. Therefore be sure to inspect the variable voltage
control system after replacing the generator to ensure the system operates normally.
1.
Generator
2.
Lower bracket
A.
Upper bolts
B.
Lower bolts
AWMIA1197GB
Terminal nut
: 10.8 N·m (1.1 kg-m, 8 ft-lb)
CHG
GENERATOR
CHG-21
< SERVICE DATA AND SPECIFICATIONS (SDS)
C
D
E
F
G
H
I
J
K
L
B
A
O
P
N
SERVICE DATA AND SPECIFICATIONS (SDS)
GENERATOR
Generator
INFOID:0000000006161773
*: Always check with the Parts Department for the latest parts information
Model*
TG15S179
Manufacturer
Valeo
Nominal rating
14V-130A
Ground polarity
Negative
Minimum revolution under no-load
1,200 rpm
Hot output current (When 13.5 volts is applied)
More than 52A/1,500 rpm
More than 82A/1,800 rpm
More than 115A/2,500 rpm
More than 130A/5,000 rpm
Regulated output voltage
13.5V @ 5,000 rpm @ 20
°C
Adjustment range of power generation variable voltage control
11.7-15.3V
CO-1
ENGINE
C
D
E
F
G
H
I
J
K
L
M
SECTION
CO
A
CO
N
O
P
CONTENTS
ENGINE COOLING SYSTEM
PRECAUTION . . . . . . . . . . . ...
PRECAUTIONS . . . . . . . . . . . . ...
Precaution for Liquid Gasket . . . . . . . . .....
PREPARATION . . . . . . . . . . .
PREPARATION . . . . . . . . . . . . ...
Special Service Tool . . . . . . . . . . . .....
Commercial Service Tool . . . . . . . . . . ..
SYSTEM DESCRIPTION . . . . . . . ..
COOLING SYSTEM . . . . . . . . . . .
Cooling Circuit . . . . . . . . . . . . . . ...
Schematic . . . . . . . . . . . . . . . .....
OVERHEATING CAUSE ANALYSIS . . . . ..
Troubleshooting Chart . . . . . . . . . . . ...
PERIODIC MAINTENANCE . . . . . . .
ENGINE COOLANT . . . . . . . . . . ...
Inspection . . . . . . . . . . . . . . . .
Changing Engine Coolant . . . . . . . . . ...
RADIATOR . . . . . . . . . . . . . .
Checking Radiator . . . . . . . . . . . . ...
REMOVAL AND INSTALLATION . . . ...
RADIATOR . . . . . . . . . . . . . .
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
ENGINE COOLING FAN . . . . . . . . ...
Exploded View . . . . . . . . . . . . . . .
Removal and Installation (Crankshaft Driven
Type) . . . . . . . . . . . . . . . . . ...
WATER PUMP . . . . . . . . . . . . ..
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
THERMOSTAT AND WATER PIPING . . . ..
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
SERVICE DATA AND SPECIFICATIONS
(SDS) . . . . . . . . . . . . . . .
SERVICE DATA AND SPECIFICATIONS
(SDS) . . . . . . . . . . . . . . . . .
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст