Harley Davidson 2008 Touring Models. Electrical Diagnostics Manual — page 34
TABLE OF CONTENTS
SUBJECT
PAGE NO.
B.1 CONNECTORS
B-1
B.2 WIRING DIAGRAMS
B-18
NOTES
HOME
CONNECTORS
B.1
CONNECTOR LOCATIONS
Connector Number
On wiring diagrams and in service/repair instructions, con-
Function/Location
nectors are identified by a number in brackets.
Refer to Table B-1, Table B-2 or Table B-3. On the motorcycle,
a connector can be identified by its function and location.
Repair Instructions
The repair instructions in this Service Manual are by connector
Place and Color
type. Refer to Table B-1, Table B-2 or Table B-3.
The place (number of wire cavities of a connector housing)
and color of the connector can also aid identification.
ed01271
[108]
[39]
[21]
[22]
[204]
[1]
[50]
[24]
[31R]
[107]
[31L]
[6]
[2]
[184]
[167]
[15]
[32]
[105]
[28]
[27]
[33]
[51]
[38]
Figure B-1. Inner Fairing Connectors (FLHX, FLHT/C/U)
2008 Touring Diagnostics: Appendix B Wiring B-1
HOME
Table B-1. FLHX, FLHT/C/U Connector Locations
NO.
DESCRIPTION
TYPE
LOCATION
[1]
Main to interconnect harness
16-place Molex (black)
Inner fairing
- right radio support
bracket
[2]
Main to interconnect harness
12-place Molex (gray)
Inner fairing - left radio support bracket
[4]
Accessory
4-place Deutsch
Under seat
[5]
MAXIFUSE
2-place Packard
Under left side cover
[7]
Rear fender lights harness
8-place Multilock
Top of rear fender (under seat)
[12]
T
our-Pak lights
(rear facia lamp on
3-place Multilock
Inside Tour-Pak
(inboard of upper
FLHX)
frame tube on FLHX)
[13]
Fuel tank harness
4-place Multilock
Behind fuel tank (under seat)
[15]
Main to interconnect harness
4-place Delphi
Inner fairing - right fairing bracket
[18]
Left rear turn signal
2-place Multilock
Circuit board under tail lamp assembly
[19]
Right rear turn signal
2-place Multilock
Circuit board under tail lamp assembly
[20]
Console harness
16-place Molex
Under seat
[21]
Indicator lamps
10-place Multilock
Inner fairing - above radio
[22]
Interconnect to right handlebar
12-place Molex (black)
Inner fairing - right fairing support brace
switches
[24]
Interconnect
to left handlebar switches
16-place Molex (gray)
Inner fairing - left fairing support brace
[27]
Radio*
23-place Amp (T
yco)
Inner fairing - back of radio (right side)
[28]
Radio**
35-place Amp (T
yco)
Inner fairing - back of radio (left side)
[30]
TSM/TSSM/HFSM
12-place Deutsch
Crossmember at rear of battery box
(under seat)
[31L]
Left front turn signal/auxiliary lamp
4-place Multilock
Inner fairing - left fairing support brace
(outboard side)
[31R]
Right front turn signal/auxiliary lamp
4-place Multilock
Inner fairing - right fairing support brace
(outboard side)
[32]
Front fender tip lamp jumper harness
2-place Multilock (black)
Inner fairing - below upper for bracket
(DOM)
(left side)
[33]
Ignition Switch
3-place Packard
Inner fairing
- under radio
(front of
ignition switch housing)
[34]
Right front speaker
Spade terminals
Inner fairing (back of speaker)
[34]
Left front speaker
Spade terminals
Inner fairing (back of speaker)
[38]
Headlamp
Headlamp connector
Inner fairing (back of headlamp)
[39]
Speedometer
12-place Packard
Inner fairing - back of speedometer
[41]
Rear right speaker/passenger con-
6-place Deutsch
Inside rear right speaker box
trols**
[42]
Rear
left speaker/passenger controls**
6-place Deutsch
Inside rear left speaker box
[45]
Rear fender tip lamp (DOM)
3-place Multilock
Circuit board under tail lamp assembly
[47]
Stator
3-place Lyall
Bottom of voltage regulator (left side)
[50]
CB antenna cable**
-
Inner fairing - back of CB module
[51]
Radio antenna cable**
-
Inner fairing - back of radio (left side)
[53]
Console pod**
12-place Deutsch
Rear of battery box (under seat)
[64]
Fuse block
Packard
Under left side cover
[65]
Vehicle Speed Sensor (VSS)
3-place Delphi
Top of transmission case
(under
starter)
[76]
Passenger headset
7-place DIN
Below rear left speaker box
[77]
Voltage regulator
2-place Lyall
Bottom of voltage regulator (right side)
B-2 2008 Touring Diagnostics: Appendix B Wiring
HOME
Table B-1. FLHX, FLHT/C/U Connector Locations
NO.
DESCRIPTION
TYPE
LOCATION
[78]
Electronic Control Module (ECM)
73-place Delphi
Under seat
[79]
Crankshaft Position (CKP) sensor
2-place Deutsch
Electrical caddy at bottom of lower
frame crossmember
[80]
T
emperature Manifold Absolute Pres-
4-place Bosch
Top of induction module
sure (TMAP) sensor
[83]
Ignition coil
4-place Delphi
Below fuel tank (left side)
[84]
Front injector
2-place Delphi
Below fuel tank (left side)
[85]
Rear injector
2-place Delphi
Below fuel tank (left side)
[87]
Idle Air Control (IAC)
4-place Delphi
Top of induction module
[90]
Engine
Temperature (ET) sensor
2-place Delphi
Back of front cylinder (left side)
[91]
Data link connector
4-place Deutsch
Under left side cover
[93]
T
ail lamp
4-place Multilock
Circuit board under tail lamp assembly
[94]
Rear fender lights harness in circuit
6-place Multilock
Circuit board under tail lamp assembly
board
[95]
Purge solenoid
2-place Delphi
Below fuel tank (left side)
[105]
Fairing cap switches
12-place Multilock
Inner fairing - above upper fork bracket
(right side)
[107]
Ambient Air T
emperature
(AAT)
3-place Multilock
Inner fairing - left fairing bracket (out-
sensor*
board side)
[108]
T
achometer
12-place Packard
Inner fairing (back of tachometer)
[111]
Voltmeter lamp
Spade terminals
Inner fairing (back of voltmeter)
[112]
Oil pressure gauge lamp
Spade terminals
Inner fairing
(back of oil pressure
gauge)
[113]
Oil pressure gauge
Spade terminals
Inner fairing
(back of oil pressure
gauge)
[114]
Air temperature gauge lamp
Spade terminals
Inner fairing (back of air temperature
gauge)
[115]
Air temperature gauge
Spade terminals
Inner fairing (back of air temperature
gauge)
[116]
Fuel gauge lamp
Spade terminals
Inner fairing (back of fuel gauge)
[117]
Fuel gauge
Spade terminals
Inner fairing (back of fuel gauge)
[119]
EFI fuses
Fuse terminals
Fuse block (under right side cover)
[121]
Rear brake light switch
Spade terminals
Bottom of rear frame downtube (right
side)
[122]
Horn
Spade terminals
Between cylinders (right side)
[126]
Lighting relay
Relay
Crossmember at rear of battery box
(under seat)
[128]
Starter solenoid
Spade terminals
Top of starter
[129]
Harness grounds
Ring terminals
Upper frame crossmember (under seat)
[131]
Neutral switch
Post terminals
Top of transmission (right side)
[132]
Cigarette lighter*
Spade terminals
Inner fairing
[133]
Jiffy Stand Sensor
3-place Molex (black)
Domestic (not used): Electrical caddie
at bottom of lower frame crossmember.
HDI: Electrical caddie at bottom of
lower frame crossmember.
[134]
Sidecar Bank Angle Sensor (BAS)
3-place Packard
Under seat
2008 Touring Diagnostics: Appendix B Wiring B-3
HOME
Table B-1. FLHX, FLHT/C/U Connector Locations
NO.
DESCRIPTION
TYPE
LOCATION
[136]
Neutral switch
1-place molded jumper, black
Right side frame, beneath gearcase
cover
[137]
O
sensor rear exhaust header
2-place Amp (T
yco)
Under chrome starter cover
2
[138]
O
sensor front exhaust header
2-place Amp (Tyco)
Back of cross brace between front
2
frame downtubes (left side)
[141]
Fuel pump and fuel level sender
4-place Packard
Front right crankcase
[142]
Security siren (optional)
3-place Delphi
Under right side cover (behind elec-
trical bracket)
[143]
Front fender tip lamp (DOM)
2-place Multilock
Under front fender tip lamp bracket
[160]
B+
1-place Delphi
Upper frame crossmember (under seat)
[166]
ABS module
20-place Molex
Under right side cover
[167]
Front wheel speed sensor
2-place Packard
Inner fairing - below upper fork bracket
(left side)
[168]
Rear wheel speed sensor
2-place Packard
Under right side cover
[179]
Active exhaust actuator
5-place Amp (Tyco)
Domestic (not used): Under right side
cover
HDI: Under right side cover (behind
electrical bracket)
[184]
CB module
12-place Deutsch
Inner fairing - left side of radio
[201]
ABS diode
4-place Deutsch
Under left side cover (below fuse box)
[204]
T
wist Grip Sensor (TGS) harness
6-place Molex (black)
Inner fairing
- right radio support
bracket
[208]
HFSM antenna jumper harness
4-place Deutsch
HFSM in crossmember at rear of bat-
tery box (under seat)
[209]
HFSM antenna
2-place Molex
Top of rear fender - under seat
[211]
Throttle Control Actuator
6-place Molex
Throttle body
[222]
Main to ignition harness
4-place Packard
Rear of fuel tank
[224]
T
wist Grip Sensor (TGS)
7-place Amp (Tyco)
Handlebar throttle
(inside right side
handlebar)
*Classic and Ultra
**Ultra Only
B-4 2008 Touring Diagnostics: Appendix B Wiring
HOME
ed01274
ed01275
[166]
[168]
[211]
[179]
1.
[166] ABS Control Module
1.
[211] Throttle Control Actuator and TP Sensor
2.
[167] Front Wheel Speed Sensor
Figure B-3. Throttle Control Connector
3.
[168] Rear Wheel Speed Sensor
Figure B-2. ABS Connector
ed01276
[80]
1.
[80] TMAP Sensor
Figure B-4. TMAP Connector
2008 Touring Diagnostics: Appendix B Wiring B-5
HOME
ed01260
1
2
3
4
19
5
18
6
7
17
8
16
9
15
14
13
12
11
10
1. Accessory
11. Spare
2. Battery
12. Lights
3. P&A
13. Headlamp
4. Radio power/Siren (if equipped)
14. ABS (if equipped)
5. ECM power
15. Brake relay
6. System relay
16. Instruments
7. Start relay
17. Fuel pump
8. Engine control
18. Radio memory (if equipped)
9. MAXIFUSE
19. Brake/Cruise
10. Ignition
Figure B-5. Fuse and Relay Locations
B-6 2008 Touring Diagnostics: Appendix B Wiring
HOME
ed01270
2
1
3
4
12
11
10
5
9
7
8
6
1. Negative Battery Terminal
2.
[78] ECM
3.
[30] HFSM
4.
[7] Tail Light Connector
5.
[126] Lighting Relay
6.
[4] P&A Accessory Connector
7.
Positive Battery Terminal
8.
[13] Fuel Pump Subharness Connector
9.
[GND2] Rear (clean) Ground
10. [GND1] Front (dirty) Ground
11. [160] B+ Connector
12. [209] Hands-Free Antenna Connector
Figure B-6. Electrical Connectors - Under Seat
2008 Touring Diagnostics: Appendix B Wiring B-7
HOME
ed02690
ed01265
1
2
3
1. Voltage Regulator [77]
Figure B-7. Tour-Pak Connectors (Left Side)
2. CKP Sensor [79]
3. Stator [47]
Figure B-9. Voltage Regulator (Left Side View)
ed02691
ed02694
45
19
18
93
94
Figure B-8. Tour-Pak Connectors (Right Side)
1.
[18] Left Turn Signal Lamp
2.
[19] Right Turn Signal Lamp
3.
[45] Fender Tip Lamp
4.
[91] Tail Lamp
5.
[94] Fender Lights Harness
Figure B-10. Rear Fender Lights Assembly
B-8 2008 Touring Diagnostics: Appendix B Wiring
HOME
ed01272
[24]
[27]
[51]
[1]
[15]
[22]
[2]
[204]
[31R]
[31L]
[38]
[167]
Figure B-11. Inner Fairing Connectors (FLTR)
2008 Touring Diagnostics: Appendix B Wiring B-9
HOME
ed02696
[21]
[105A/B]
[39]
[10B]
[105C/D]
[107]
1.
[21] Indicator Lamps
2.
[39] Speedometer
3.
[105A/B] Instrument Nacelle Switches
4.
[105C/D] Speaker Switch
5.
[107] Ambient Temperature Sensor
6.
[108] Tachometer
Figure B-12. Instrument Nacelle Connectors (FLTR)
Table B-2. FLTR Connector Locations
NO.
DESCRIPTION
TYPE
LOCATION
[1]
Main to interconnect harness
16-place Molex (black)
Inner fairing
- right radio support
bracket
[2]
Main to interconnect harness
12-place Molex (gray)
Inner fairing - leftt radio support bracket
[4]
Accessory
4-place Deutsch
Upper frame crossmember (under seat)
[5]
MAXIFUSE
2-place Packard
Under left side cover
[7]
Rear fender lights harness
8-place Multilock
Top of rear fender (under seat)
[13]
Fuel tank harness
4-place Multilock
Behind fuel tank (under seat)
[15]
Main to interconnect harness
4-place Delphi
Inner fairing - below radio (right side)
[18]
Left rear turn signal
2-place Multilock
Circuit board under tail lamp assembly
[19]
Right rear turn signal
2-place Multilock
Circuit board under tail lamp assembly
[21]
Indicator lamps
10-place Multilock
Inner fairing - above radio
[22]
Interconnect to right handlebar
12-place Molex (black)
Inner fairing - right fairing support brace
switches
[24]
Interconnect
to left handlebar switches
16-place Molex (gray)
Inner fairing - left fairing support brace
[27]
Radio
23-place Amp (Tyco)
Inner fairing - back of radio (right side)
B-10 2008 Touring Diagnostics: Appendix B Wiring
HOME
Table B-2. FLTR Connector Locations
NO.
DESCRIPTION
TYPE
LOCATION
[30]
TSM/HFSM
12-place Deutsch
Crossmember at rear of battery box
(under seat)
[31L]
Left front turn signal/auxiliary lamp
4-place Multilock
Inner fairing - left fairing support brace
(outboard side)
[31R]
Right front turn signal/auxiliary lamp
4-place Multilock
Inner fairing - right fairing support brace
(outboard side)
[33]
Ignition switch
3-place Packard
Inner fairing
- under radio
(front of
ignition switch housing)
[34]
Right front speaker
Spade terminals
Inner fairing (back of speaker)
[34]
Left front speaker
Spade terminals
Inner fairing (back of speaker)
[38]
Headlamp
Headlamp connector
Inner fairing (back of headlamp)
[39]
Speedometer
12-place Packard
Inner fairing - back of speedometer
[45]
Rear fender tip lamp (DOM)
3-place Multilock
Circuit board under tail lamp assembly
[47]
Stator
3-place Lyall
Bottom of voltage regulator (left side)
[51]
Radio antenna cable
-
Inner fairing - back of radio (left side)
[64]
Fuse block
Packard
Under left side cover
[65]
Vehicle Speed Sensor (VSS)
3-place Delphi
Top of transmission case
(under
starter)
[77]
Voltage regulator
2-place Lyall
Bottom of voltage regulator (right side)
[78]
Electronic Control Module (ECM)
73-place Delphi
Under seat
[79]
Crankshaft Position (CKP) sensor
2-place Deutsch
Electrical caddie at bottom of lower
frame crossmember
[80]
T
emperature Manifold Absolute Pres-
4-place Bosch
Top of induction module
sure (TMAP) sensor
[83]
Ignition coil
4-place Delphi
Below fuel tank (left side)
[84]
Front injector
2-place Delphi
Below fuel tank (left side)
[85]
Rear injector
2-place Delphi
Below fuel tank (left side)
[87]
Idle Air Control (IAC)
4-place Delphi
Below fuel tank (right side)
[90]
Engine
Temperature (ET) sensor
2-place Delphi
Back of front cylinder (left side)
[91]
Data link connector
4-place Deutsch
Under left side cover
[93]
T
ail lamp
4-place Multilock
Circuit board under tail lamp assembly
[94]
Rear fender lights harness in circuit
6-place Multilock
Circuit board under tail lamp assembly
board
[95]
Purge solenoid
2-place Delphi
Below fuel tank (left side)
[105]
Instrument nacelle switches
Interconnect
to nacelle switch harness
12-place Multilock
Inside instrument nacelle (under bezel)
(105A, 105B)
Nacelle switch harness to speaker
4-place Multilock
Inside instrument nacelle (under bezel)
switch (105C, 105D)
[107]
Ambient
Air Temperature (AAT) sensor
3-place Multilock
Inside instrument nacelle (under bezel)
[108]
T
achometer
12-place Packard (gray)
Inside instrument nacelle
(back of
tachometer)
[111]
Voltmeter lamp
Spade terminals
Inner fairing (back of voltmeter)
[112]
Oil pressure gauge lamp
Spade terminals
Inner fairing
(back of oil pressure
gauge)
[113]
Oil pressure gauge
Spade terminals
Inner fairing
(back of oil pressure
gauge)
2008 Touring Diagnostics: Appendix B Wiring B-11
HOME
Table B-2. FLTR Connector Locations
NO.
DESCRIPTION
TYPE
LOCATION
[114]
Air temperature gauge lamp
Spade terminals
Inner fairing (back of air temperature
gauge)
[115]
Air temperature gauge
Spade terminals
Inner fairing (back of air temperature
gauge)
[116]
Fuel gauge lamp
Spade terminals
Inner fairing (back of fuel gauge)
[117]
Fuel gauge
Spade terminals
Inner fairing (back of fuel gauge)
[119]
EFI fuses
Fuse terminals
Fuse block (under right side cover)
[121]
Rear brake light switch
Spade terminals
Bottom of rear frame downtube (right
side)
[122]
Horn
Spade terminals
Between cylinders (right side)
[123]
Start relay
Relay
Fuse block (under left side cover)
[124]
Brake light relay
Relay
Fuse block (under left side cover)
[126]
Lighting relay
Relay
Crossmember at rear of battery box
(under seat)
[128]
Starter solenoid
Spade terminals
Top of starter
[129]
Harness grounds
Ring terminals
Upper frame crossmember (under seat)
[131]
Neutral switch
Post terminals
Top of transmission (right side)
[132]
Cigarette lighter
Spade terminals
Inner fairing
[133]
Jiffy Stand Sensor
3-place Molex (black)
Domestic (not used): Electrical caddie
at bottom of lower frame crossmember.
HDI: Electrical caddy at bottom of lower
frame crossmember.
[135]
EFI system relay
Relay
Fuse block (under right side cover)
[137]
O
2
sensor rear exhaust header
2-place Amp (T
yco)
Under chrome starter cover
[138]
O
2
sensor front exhaust header
2-place Amp (Tyco)
Back of cross brace between front
frame downtubes (left side)
[141]
Fuel pump and fuel level sender
4-place Packard
Top of canopy (under console)
[142]
Security siren (optional)
3-place Delphi
Under right side cover (behind elec-
trical bracket)
[160]
B+
1-place Delphi
Upper frame crossmember (under seat)
[166]
ABS module
20-place Molex
Under right side cover
[167]
Front wheel speed sensor
2-place Delphi (black)
Inner fairing - below upper fork bracket
(left side)
[168]
Rear wheel speed sensor
2-place Delphi (black)
Under right side cover
[179]
Active exhaust actuator
5-place Amp (Tyco)
Domestic (not used): Under right side
cover
HDI: Under right side cover (behind
electrical bracket)
[201]
ABS diode
4-place Deutsch
Under left side cover (below fuse box)
[204]
T
wist Grip Sensor (TGS)
6-place Molex (black)
Inner fairing
- right radio support
bracket
[208]
HFSM antenna jumper harness
4-place Deutsch
HFSM in crossmember at rear of bat-
tery box (under seat)
[209]
HFSM antenna
2-place Molex
Top of rear fender - under seat
[211]
Throttle Control Actuator (TCA)
6-place Molex
Throttle body
[222]
Console ignition switch interconnect
4-place Packard
Under seat
B-12 2008 Touring Diagnostics: Appendix B Wiring
HOME
ed01277
[95]
1.
[95] Purge Solenoid
Figure B-13. Below Fuel Tank (Left Side)
Table B-3. FLHR/C/S Connector Locations
NO.
DESCRIPTION
TYPE
LOCATION
[4]
Accessory
4-place Deutsch
Upper frame crossmember (under seat)
[5]
MAXIFUSE
2-place Packard
Under left side cover
[7]
Rear fender lights harness
6-place Multilock
Top of rear fender (under seat)
[18]
Left rear turn signal
2-place Multilock
Circuit board under tail lamp assembly
[19]
Right rear turn signal
2-place Multilock
Circuit board under tail lamp assembly
[20]
Console harness
16-place Molex
Under seat
[21]
Indicator lamps
8-place Deutsch
Under console
[22]
Right handlebar switches
6-place Molex (black)
Inside headlamp nacelle - fork stern
nut lock plate (right side)
[24]
Left handlebar switches
8-place Molex (gray)
Inside headlamp nacelle - fork stern
nut lock plate (left side)
[30]
TSM//HFSM
12-place Deutsch
Crossmember at rear of battery box
(under seat)
[31]
Front turn signals
6-place Multilock
Inside headlamp nacelle - fork stern
nut lock plate (left side)
[32]
Front fender tip lamp jumper harness
2-place Multilock
Inside headlamp nacelle
(DOM)
[33]
Ignition switch
3-place Packard
Under console
[38]
Headlamp
Headlamp connector
Inside headlamp nacelle
[39]
Speedometer
12-place Packard
Back of speedometer (back of console)
[45]
Rear fender tip lamp (DOM)
3-place Multilock
Circuit board under tail lamp assembly
[47]
Stator
3-place Lyall
Bottom of voltage regulator (left side)
[64]
Fuse block
Packard
Under left side cover
[65]
Vehicle Speed Sensor (VSS)
3-place Delphi
Top of transmission case
(under
starter)
[67]
Accessory switch
4-place Amp (Tyco)
Inside headlamp nacelle
2008 Touring Diagnostics: Appendix B Wiring B-13
HOME
Table B-3. FLHR/C/S Connector Locations
NO.
DESCRIPTION
TYPE
LOCATION
[73]
Auxiliary lamps
2-place Multilock (white)
Inside headlamp nacelle
[75]
Cruise roll-off switch**
Spade terminals
Right side of steering head
[77]
Voltage regulator
2-place Lyall
Bottom of voltage regulator (right side)
[78]
Electronic Control Module (ECM)
73-place Delphi
Under seat
[79]
Crankshaft Position (CKP) sensor
2-place Deutsch
Electrical caddie at bottom of lower
frame crossmember
[80]
T
emperature Manifold Absolute Pres-
3-place Packard
Top of induction module
sure (TMAP) sensor
[83]
Ignition coil
4-place Delphi
Below fuel tank (left side)
[84]
Front injector
2-place Delphi
Below fuel tank (left side)
[85]
Rear injector
2-place Delphi
Below fuel tank (left side)
[87]
Idle Air Control (IAC)
4-place Delphi
Below fuel tank (right side)
[90]
Engine
Temperature (ET) sensor
2-place Delphi
Back of front cylinder (left side)
[91]
Data link connector
4-place Deutsch
Under right side cover
[93]
T
ail lamp
4-place Multilock
Circuit board under tail lamp assembly
[94]
Rear fender lights harness in circuit
6-place Multilock
Circuit board under tail lamp assembly
board
[95]
Purge solenoid
2-place Delphi
Below fuel tank (left side)
[108]
Optional tachometer
1-place Amp (T
yco)
Inside headlamp nacelle
[109]
Auxiliary lamps switch
4-place Amp (T
yco)
Inside headlamp nacelle
[117]
Fuel gauge
Spade terminals
Inner fairing (back of fuel gauge)
[119]
EFI fuses
Fuse terminals
Fuse block (under right side cover)
[121]
Rear brake light switch
Spade terminals
Bottom of rear frame downtube (right
side)
[119]
Oil pressure switch
Post terminal
Front right crankcase
[122]
Horn
Spade terminals
Between cylinders (right side)
[123]
Start relay
Relay
Fuse block (under left side cover)
[124]
Brake light relay
Relay
Fuse block (under left side cover)
[126]
Lighting relay
Relay
Crossmember at rear of battery box
(under seat)
[128]
Starter solenoid
Spade terminals
Top of starter
[129]
Harness grounds
Ring terminals
Upper frame crossmember (under seat)
[131]
Neutral switch
Post terminals
Top of transmission (right side)
[133]
Jiffy Stand Sensor
3-place Molex (black)
Domestic (not used): Electrical caddie
at bottom of lower frame crossmember.
HDI: Electrical caddie at bottom of
lower frame crossmember.
[135]
EFI system relay
Relay
Fuse block (under right side cover)
[137]
O
2
sensor rear exhaust header
2-place Amp (T
yco)
Under chrome starter cover
[138]
O
2
sensor front exhaust header
2-place Amp (Tyco)
Back of cross brace between front
frame downtubes (left side)
[141]
Fuel pump and fuel level sender
4-place Packard
Top of canopy (under console)
[142]
Security siren (optional)
3-place Delphi
Under right side cover (behind elec-
trical bracket)
[143]
Front fender tip lamp (DOM)
2-place Multilock (black)
Under front fender tip lamp bracket
B-14 2008 Touring Diagnostics: Appendix B Wiring
HOME
Table B-3. FLHR/C/S Connector Locations
NO.
DESCRIPTION
TYPE
LOCATION
[158]
Left handlebar switches (cruise con-
3-place Molex (black)
Inside headlamp nacelle
trol)**
[159]
Right handlebar switches (cruise con-
3-place Molex (gray)
Inside headlamp nacelle
trol)**
[160]
B+
1-place Packard
Upper frame crossmember (under seat)
[166]
ABS module
20-place Molex
Under right side cover
[167]
Front wheel speed sensor
2-place Delphi (black)
Inner fairing - below upper fork bracket
(left side)
[168]
Rear wheel speed sensor
2-place Delphi (black)
Under right side cover
[178]
Active intake solenoid
2-place Amp (Tyco)
[179]
Active exhaust actuator
5-place Amp (Tyco)
Domestic (not used): Under right side
cover
HDI: Under right side cover (behind
electrical bracket)
[201]
ABS diode
4-place Deutsch
Under left side cover (below fuse box)
[204]
T
wist Grip Sensor (TGS)
6-place Molex (black)
Inner fairing
- right radio support
bracket
[208]
HFSM antenna jumper harness
4-place Deutsch
HFSM in crossmember at rear of bat-
tery box (under seat)
[209]
HFSM antenna
2-place Molex
Top of rear fender (under seat)
[211]
Throttle Control Actuator (TCA)
6-place Molex
Throttle body
[222]
Console ignition switch interconnect
4-place Packard
Under seat
** FLHRC Only
2008 Touring Diagnostics: Appendix B Wiring B-15
HOME
ed01273
[159]
[31]
[24]
[22]
[158]
[67]
[32]
[109]
[167]
[38]
[204]
[73]
1.
[22] Right Handlebar Switches
2.
[24] Left Handlebar Switches
3.
[31] Front Turn Signals
4.
[32] Front Fender Tip Lamp (Used on FLHR Only)
5.
[38] Headlamp
6.
[67] Accessory Switch
7.
[73] Auxiliary Lamps (Used on FLHR/C Only)
8.
[109] Auxiliary Lamps Switch (Used on FLHR/C Only)
9.
[158] Cruise On/Off Switch (Used on FLHR/C Only)
10. [159] Cruise Set/Resume Switch (Used on FLHR/C Only)
Figure B-14. Headlamp Nacelle Connectors (FLHR/C/S)
B-16 2008 Touring Diagnostics: Appendix B Wiring
HOME
ed02699
33
39
21
1.
[21] Indicator Lights
2.
[33] Ignition/Light Key Switch
3.
[39] Speedometer
Figure B-15. Instrument Console Connectors (FLHR/C)
2008 Touring Diagnostics: Appendix B Wiring B-17
HOME
WIRING DIAGRAMS
B.2
WIRING DIAGRAM INFORMATION
ed01269
Wire Color Codes
Wire traces on wiring diagrams are labeled with alpha codes.
3
4
Refer to Table B-4.
For Solid Color Wires: See Figure B-16. The alpha code
5
identifies wire color (3).
1
2
For Striped Wires: The code is written with a slash (/) between
the solid color code and the stripe code (4). For example, a
6
trace labeled GN / Y is a green wire with a yellow stripe.
[21A]
1
2
4
Wiring Diagram Symbols
[21B]
1
2
4
7
See Figure B-16. On wiring diagrams and in service/repair
instructions, connectors are identified by a number in brackets
(1). The letter (2) inside the brackets identifies whether the
8
1
2
housing is a socket or pin housing.
A=Pin: The letter A after a connector number and the pin
10
9
symbol (6) identifies a pin housing.
B=Socket: The letter B after a connector number and the
socket symbol (5) identifies a socket housing.
Other symbols found on the wiring diagrams include the symbol
for a diode (7), a symbol for a wire-to-wire connection (8), a
1.
Connector number
symbol that verifies that no connection (9) between two wire
2.
Terminal code (A=pin, B=socket)
traces exists and a symbol identifying two wires that are twisted
3.
Solid wire color
together (10).
4.
Striped wire color
5.
Socket symbol
6.
Pin symbol
7.
Diode
8.
Connection
9.
No connection
10. Twisted pair
Figure B-16. Connector/Wiring Diagram Symbols (typical)
Table B-4. Wire Color Codes
ALPHA CODE
WIRE COLOR
BE
Blue
BK
Black
BN
Brown
GN
Green
GY
Grey
LGN
Light Green
O
Orange
PK
Pink
R
Red
TN
Tan
V
Violet
W
White
Y
Yellow
B-18 2008 Touring Diagnostics: Appendix B Wiring
Большое спасибо!
Ваше мнение очень важно для нас.
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст