Lexus RX300 (MCU15). Service manual — part 83
AC2810
AC1ME–02
AC2811
N11084
Wrong
Okay
HI
LO
HI
LO
–
AIR CONDITIONING
AIR CONDITIONING SYSTEM
AC–1
LEXUS RX300 (RM785E)
AIR CONDITIONING SYSTEM
PRECAUTION
1.
DO NOT HANDLE REFRIGERANT IN AN ENCLOSED
AREA OR WEAR A NAKED FLAME
2.
ALWAYS WEAR EYE PROTECTION
3.
BE CAREFUL NOT TO GET LIQUID REFRIGERANT IN
YOUR EYES OR ON YOUR SKIN
If liquid refrigerant gets in your eyes or on your skin.
(a)
Wash the area with lots of cool water.
CAUTION:
Do not rub your eyes or skin.
(b)
Apply clean petroleum jelly to the skin.
(c)
Go immediately to a physician or hospital for professional
treatment.
4.
NEVER HEAT CONTAINER OR EXPOSE IT TO NAKED
FLAME
5.
BE CAREFUL NOT TO DROP CONTAINER AND NOT
TO APPLY PHYSICAL SHOCKS TO IT
6.
DO NOT OPERATE COMPRESSOR WITHOUT
ENOUGH REFRIGERANT IN REFRIGERANT SYSTEM
If there is not enough refrigerant in the refrigerant system oil lu-
brication will be insufficient and compressor burnout may occur,
so take care to avoid this, necessary care should be taken.
7.
DO NOT OPEN HIGH PRESSURE MANIFOLD VALVE
WHILE COMPRESSOR IS OPERATING
If the high pressure valves opened, refrigerant flows in the re-
verse direction and could cause the charging cylinder to rup-
ture, so open and close the only low pressure valve.
8.
BE CAREFUL NOT TO OVERCHARGE SYSTEM WITH
REFRIGERANT
If refrigerant is overcharged, it causes problems such as insuffi-
cient cooling, poor fuel economy, engine overheating etc.
AC–2
–
AIR CONDITIONING
AIR CONDITIONING SYSTEM
LEXUS RX300 (RM785E)
9.
SUPPLEMENTAL RESTRAINT SYSTEM (SRS)
The LEXUS RX300 is equipped with an SRS (Supplemental
Restraint System) such as the driver, front passenger and side
airbag. Failure to carry out service operation in the correct se-
quence could cause the SRS to unexpectedly deploy during
servicing, possibly leading to a serious accident. Before servic-
ing (including removal or installation of parts, inspection or re-
placement), be sure to read the precautionary notices in the RS
section.
AC1MF–02
I07796
Sight Glass
–
AIR CONDITIONING
AIR CONDITIONING SYSTEM
AC–3
LEXUS RX300 (RM785E)
ON–VEHICLE INSPECTION
1.
INSPECT REFRIGERANT VOLUME
Observe the sight glass on the liquid tube.
Test conditions:
S
Running engine at 1,500 rpm
S
Blower speed control switch at ”HI” position
S
A/C switch ON
S
Temperature control dial at ”COOL” position
S
Fully open the doors
Item
Symptom
Amount of refrigerant
Remedy
1
Bubbles present in sight glass
Insufficient*
(1) Check for gas leakage with gas leak de-
tector and repair if necessary
(2) Add refrigerant until bubbles disappear
2
No bubbles present in sight glass
None, sufficient or too much
Refer item 3 and 4
3
No temperature difference between com-
pressor inlet and outlet
Empty or nearly empty
(1) Check for gas leakage with gas leak de-
tector and repair if necessary
(2) Add refrigerant until bubbles disappear
4
Temperature between compressor inlet and
outlet is noticeably different
Correct or too much
Refer to items 5 and 6
5
Immediately after air conditioning is turned
off, refrigerant in sight glass stays clear
Too much
(1) Discharge refrigerant
(2) Evacuate air and charge proper amount
of purified refrigerant
6
When air conditioning is turned off, refriger-
ant foams and then stays clear
Correct
–
*: Bubbles in the sight glass with ambient temperatures higher than usual can be considered normal if cooling
is sufficient.
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст