Ford F150 Pickup. Manual — part 363
component.
z
Circuitry.
z
Rear anti-lock brake
sensor.
z
Anti-lock brake control
module.
z
DTC 10-speed
sensor low
resistance/short to
ground
z
Bulkhead connector
between engine
compartment and
instrument panel sensor
terminals shorted
together.
z
Circuitry.
z
Rear anti-lock brake
sensor.
z
Anti-lock brake control
module.
z
Go To PINPOINT TEST L:
DIAGNOSTIC TROUBLE CODE
(DTC) 10 - LOW SPEED
SENSOR RESISTANCE .
z
DTC 11-brake pedal
position (BPP)
switch always
closed
z
Stoplamps.
z
Circuitry.
z
BPP switch.
z
Anti-lock brake control
module.
z
Go To PINPOINT TEST M:
DIAGNOSTIC TROUBLE CODE
(DTC) 11 - BRAKE PEDAL
POSITION (BPP) SWITCH
ALWAYS CLOSED .
z
DTC 12-loss of
hydraulic brake fluid
during an anti-lock
stop
z
Low master cylinder fill
level.
z
Fluid leaks in vehicle
brake system.
z
Brake fluid level warning
switch.
z
Master cylinder float.
z
Diode/resistor element.
z
Ignition switch.
z
Circuitry.
z
Anti-lock brake control
module.
z
Go To PINPOINT N:
DIAGNOSTIC TROUBLE CODE
(DTC) 12 - LOSS OF
HYDRAULIC BRAKE FLUID
DURING AN ANTI-LOCK
STOP .
z
DTC 13-RABS
module failure
z
Anti-lock brake control
module.
z
INSTALL a new anti-lock brake
control module. TEST the system
for normal operation.
z
REPEAT the system pre-check.
z
DTC 16-RABS
system OK
z
No system faults detected.
z
STOP. Rear anti-lock brake system
functioning properly.
2003 Ford Pickup F150
2003 BRAKES Anti-Lock Control-Rear - F150 Pickup
z
Intermittent problem
diagnosis
z
Intermittent voltage to
antilock brake control
module.
z
Less than 11 volts feed to
anti-lock brake control
module.
z
Intermittent connections
at rear anti-lock brake
sensor, RABS valve, anti-
lock brake control
module.
z
Go To PINPOINT TEST P:
INTERMITTENT PROBLEM
DIAGNOSIS .
z
Unwarranted RABS
activity
z
Metal chips on sensor
pole piece.
z
Gap between the anti-lock
brake sensor and the anti-
lock brake sensor
indicator is too large.
z
Anti-lock brake
sensor/sensor indicator
interference.
z
Go To PINPOINT TEST H:
DIAGNOSTIC TROUBLE CODE
(DTC) 6 - ERRATIC REAR
ANTI-LOCK BRAKE SENSOR
CIRCUIT .
z
Intermittent open rear
anti-lock brake sensor
circuit at intermediate
connections especially
bulkhead.
z
Go To PINPOINT TEST P:
INTERMITTENT PROBLEM
DIAGNOSIS .
z
Wire insulation.
z
INSPECT wiring harness from rear
axle assembly to frame side rail for
chafing or rub marks.
z
Rear brake adjustment.
z
REFER to DISC - BLACKWOOD,
F150 HERITAGE PICKUP &
F150 .
z
Brake linings.
z
REFER to DISC - BLACKWOOD,
F150 HERITAGE PICKUP &
F150 .
z
One or both wheels
lock up
z
Brake related concern:
{
Rear brake shoe
linings.
{
Rear wheel
cylinder.
{
Rear brake
adjustment.
{
Contaminated brake
z
REFER to DISC - BLACKWOOD,
F150 HERITAGE PICKUP &
F150 .
2003 Ford Pickup F150
2003 BRAKES Anti-Lock Control-Rear - F150 Pickup
fluid.
z
Parking brake.
z
REFER to DISC - BLACKWOOD,
F150 HERITAGE PICKUP &
F150 .
z
Rear axle seal.
z
REFER to REAR DRIVE
AXLE/DIFFERENTIAL-FORD
8.8-INCH - or REAR DRIVE
AXLE/DIFFERENTIAL-FORD
9.75-INCH - .
z
Hubs engaged although
shift lever is in 4x2
position.
z
REFER to MANUAL
TRANSMISSION, CLUTCH &
TRANSFER CASE - GENERAL
INFORMATION - F150
PICKUP .
z
Faulty 4WD indicator
switch or short to 12v in
4x4 circuit 210 (LB).
z
Go To PINPOINT TEST G:
DIAGNOSTIC TROUBLE CODE
(DTC) 5 - EXCESSIVE DUMP
SOLENOID ACTIVITY .
z
Low/soft brake
pedal
z
Hydraulic leak.
z
REFER to DISC - BLACKWOOD,
F150 HERITAGE PICKUP &
F150 .
z
Air in brake system.
z
REFER to DISC - BLACKWOOD,
F150 HERITAGE PICKUP &
F150 .
z
Brake related concern:
{
Vacuum.
{
Rear wheel cylinder
or front disc brake
caliper.
{
Rear brake
tube/hose.
z
REFER to DISC - BLACKWOOD,
F150 HERITAGE PICKUP &
F150 .
z
Excessive dump solenoid
activity
z
Go To PINPOINT TEST G:
DIAGNOSTIC TROUBLE CODE
(DTC) 5 - EXCESSIVE DUMP
SOLENOID ACTIVITY .
z
Lack of deceleration
during medium/hard
brake applications
z
RABS valve.
z
Go To PINPOINT TEST F:
DIAGNOSTIC TROUBLE CODE
(DTC) 4 - GROUNDED/OPEN
RABS VALVE RESET SWITCH
CIRCUIT .
z
Short/open in frame or
instrument panel harness
z
Go To PINPOINT TEST H:
DIAGNOSTIC TROUBLE CODE
2003 Ford Pickup F150
2003 BRAKES Anti-Lock Control-Rear - F150 Pickup
(circuits 519 [LG/BK]
and/or 523 [RD/BK]).
{
At anti-lock brake
control module
connector (pins 3
and 10).
{
At rear anti-lock
brake sensor
connector.
{
At bulkhead or
other
interconnection.
{
Wire or insulation
due to improper
routing.
{
Test connector (in
engine
compartment).
(DTC) 6 - ERRATIC REAR
ANTI-LOCK BRAKE SENSOR
CIRCUIT .
z
Rear anti-lock brake
sensor.
z
Go To PINPOINT TEST H:
DIAGNOSTIC TROUBLE CODE
(DTC) 6 - ERRATIC REAR
ANTI-LOCK BRAKE SENSOR
CIRCUIT .
z
Rear anti-lock brake
sensor ring radial runout,
rear antilock brake sensor
indicator teeth damaged
or missing.
z
Go To PINPOINT TEST H:
DIAGNOSTIC TROUBLE CODE
(DTC) 6 - ERRATIC REAR
ANTI-LOCK BRAKE SENSOR
CIRCUIT .
z
Hydraulic leak.
z
REFER to DISC - BLACKWOOD,
F150 HERITAGE PICKUP &
F150 .
z
Air in brake system.
z
REFER to DISC - BLACKWOOD,
F150 HERITAGE PICKUP &
F150 .
z
Brake related concern:
{
Vacuum.
{
Wheel cylinder or
caliper.
{
Rear brake
tube/hose.
{
Brake shoe and
linings.
z
REFER to DISC - BLACKWOOD,
F150 HERITAGE PICKUP &
F150 .
2003 Ford Pickup F150
2003 BRAKES Anti-Lock Control-Rear - F150 Pickup
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст