Hyundai H350 (2016 year). Manual — part 27
Operating precautions for cat-
Your vehicle is equipped with a cat-
Failure to observe these precautions
alytic converters (if equipped)
alytic converter emission control
could result in damage to the catalyt-
device.
ic converter and to your vehicle.
Additionally, such actions could void
WARNING
Therefore, the following precautions
your warranties.
must be observed:
Fire
•
Do not operate the vehicle when
there are signs of engine malfunc-
•
A hot exhaust system can
tion, such as misfire or a noticeable
ignite flammable items under
loss of performance.
your vehicle. Do not park,
idle, or drive the vehicle over
•
Do not misuse or abuse the
or near flammable objects,
engine. Examples of misuse are
such as dry grass, paper,
coasting with the ignition off and
leaves, etc.
descending steep grades in gear
with the ignition off.
•
The exhaust system and cat-
alytic system are very hot
•
Do not operate the engine at high
while the engine is running or
idle speed for extended periods (5
immediately after the engine
minutes or more).
is turned off. Keep away from
•
Do not modify or tamper with any
the exhaust system and cat-
part of the engine or emission con-
alytic, you may get burned.
trol system. We recommend that
7
Also, do not remove the heat
the system be inspected by an
sink around the exhaust sys-
authorized HYUNDAI dealer.
tem, do not seal the bottom of
•
Avoid driving with a extremely low
the vehicle or do not coat the
fuel level. Running out of fuel
vehicle for corrosion control.
cause the engine to misfire, dam-
It may present a fire risk under
aging the catalytic converter.
certain conditions.
7-89
Maintenance
Diesel Particulate Filter
In order to start the DPF regenera-
CAUTION
(if equipped)
tion and to stop the DPF warning
lamp illuminating, drive the vehicle in
The Diesel Particulate Filter (DPF)
Diesel Fuel
a safety driving circumstance with
system removes the soot emitted
(if equipped with DPF)
more than 60km/h (37 mph) vehicle
from the vehicle.
speed or with more than second
It is recommended to use the
Unlike a disposable air filter, the DPF
gear engaged and
~ 2000
1500
regulated automotive diesel
system automatically burns
(oxi-
engine rpm for a certain time (for
fuel for diesel vehicle equipped
dizes) and removes the accumulated
about 25 minutes).
with the DPF system.
soot according to the driving condi-
If the DPF warning indicator(
)
tion. In other words, the active burn-
If you use diesel fuel including
continues to blink or "check emission
ing by engine control system and
high sulfur (more than 50 ppm
high exhaust gas temperature
system" message comes on in the
sulfur) and unspecified addi-
cluster in spite of the above proce-
caused by normal/high driving condi-
tives, it can cause the DPF sys-
tion burns and removes the accumu-
dure, we recommend that the system
tem to be damaged and white
be checked by an authorized
lated soot.
smoke can be emitted.
HYUNDAI dealer.
However, if the vehicle continues to
If you continue to drive with the indi-
be driven in short distance repeated-
cator light blinking for a long time, the
ly or at low speed for a long time, the
DPF system can be damaged and
accumulated soot may not be auto-
fuel consumption can be worsen.
matically removed because of low
exhaust gas temperature. In this par-
ticular case, if the amount of soot is
out of detection limit, the DPF warn-
ing indicator (
) will illuminate.
7-90
Specifications & Consumer information
Dimensions
8-2
Engine
8-3
Air conditioning system
8-3
Bulb wattage
8-4
Tires and wheels
8-5
Load and speed capacity tires
8-5
Gross vehicle weight
8-6
Recommended lubricants and capacities
8-7
Available engine oil (For Europe)
8-8
Recommended SAE viscosity number
8-9
Vehicle identification number (VIN)
8-10
Vehicle certification label
8-10
Tire specification and pressure label
8-11
Engine number
8-11
Air conditioner compressor label
8-11
Declaration of conformity
8-12
8
Specifications & Consumer information
DIMENSIONS
unit : mm (in)
VAN
Truck
ITEM
BUS
Long
Short
Long
Short
Overall length
6,195 (243.9)
5,515 (217.1)
6,195 (243.9)
6,167 (242.8)
5,724 (225.4)
[With rear step]
[6,365 (250.6)]
[5,685 (223.9)]
Overall width
2,038 (80.2)
2,038 (80.2)
2,038 (80.2)
2,038 (80.2)
2,038 (80.2)
[With outside rear view mirror]
[2,436 (96.0)]
[2,436 (96.0)]
[2,436 (96.0)]
[2,436 (96.0)]
[2,436 (96.0)]
Roof panel
2,665 (105.0)
2,690 (106.0)
2,685 (105.7)
2,320 (91.3)
2,320 (91.3)
Roof hatch
2,673 (105.2)
-
-
-
-
Overall height
Electric vent
2,777 (109.3)
-
-
-
-
A/CON
2,856 (111.6)
-
-
-
-
Front tread
1,712 (67.4)
1,712 (67.4)
1,712 (67.4)
1,712 (67.4)
1,712 (67.4)
Rear tread
1,718 (67.6)
1,718 (67.6)
1,718 (67.6)
1,718 (67.6)
1,718 (67.6)
Wheelbase
3,670 (144.5)
3,670 (144.5)
3,435 (135.2)
3,670 (144.5)
3,435 (135.2)
8-2
ENGINE
Item
D4CB
Displacement
2,497 (152.38)
cc (cu. in)
Bore x Stroke
91X96 (3.58X3.77)
mm (in.)
Firing order
1-3-4-2
No. of cylinders
4. In-line
AIR CONDITIONING SYSTEM
unit : g
Bus
VAN, Truck
Item
Driver + Passenger
Driver
Driver + Passenger
Driver
(Twin compressor)
Weight of volume
700
1,150
2,100 (700 +1,400)
700
Refrigerant
Classification
R134a
Weight of volume
130
270
Driver (130), Passenger (270)
130
Compressor lubricant
Classification
PAG oil
8
8-3
Specifications & Consumer information
BULB WATTAGE
Wattage
Light Bulb
MFR
Projection
Headlights (Low/High)
55
Front fog lights*
35
Front turn signal lights
21
21
Front position lights
5
LED
DRL lights*
21
LED
Side repeater
LED
Side marker lights*
5
Rear stop / tail lamp
21/5
Back up lamp
16
Rear turn signal lamp
21
Rear fog lights
21
License plate light
5
High mounted stop light
LED
Over head console lamps
10
Room lamps*
LED (if equipped)
10
Step lamp*
5
Cargo lamps*
10
Reading lamps*
LED
* If equipped
8-4
TIRES AND WHEELS
Inflation pressure bar (psi, kPa)
Normal load
Maximum load
Wheel lug nut torque
Item
Tire size
Wheel size
(
)
kg•m (lb•ft, N•m)
(
)
Front
Rear
Front
Rear
VAN, Truck
235/65R16C
16x6.5J
49 (338)
64 (442)
49 (338)
64 (442)
9~11
BUS
235/65R16C
16x6.5J
49 (338)
69 (476)
49 (338)
69 (476)
(67~81, 90~110)
CAUTION
When replacing tires, use the same size originally supplied with the vehicle.
Using tires of a different size can damage the related parts or make it work irregularly.
LOAD AND SPEED CAPACITY TIRES
Load Capacity
Speed Capacity
Item
Tire size
Wheel size
LI *1
kg
SS *2
km/h
Full size tire
235/65R16C
16x6.5J
115/113
1,215/1,150
R
170
*1 LI
: LOAD INDEX
*2 SS : SPEED SYMBOL
8
8-5
Specifications & Consumer information
GROSS VEHICLE WEIGHT
unit : kg (lbs)
VAN
Item
BUS
Truck
N1*1
N2*1
BUS, VAN, Truck
4,000 (8,818)
3,500 (7,716)
4,100 (9,039)
3,500 (7,716)
❇ *1 : N1:GVW
3.5 ton, N2 : 3.5 ton < GVW <12 ton
8-6
RECOMMENDED LUBRICANTS AND CAPACITIES
To help achieve proper engine and powertrain performance and durability, use only lubricants of the proper quality.
The correct lubricants also help promote engine efficiency that results in improved fuel economy.
These lubricants and fluids are recommended for use in your vehicle.
Lubricant
Volume
Classification
Engine oil *1 *2
(drain and refill)
ACEA C2
SAE 15W-40 : -15°C above
Recommends
Diesel Engine
8.7 l (9.19 US qt.)
SAE 10W-30/40 : -20°C above
SAE 5W-30/40 : -25°C above
SAE 0W-30/40 : -30°C below
Engine Oil
Normal driving condition
MAX. 1L /1500 Km
-
Consumption
Severe driving condition
MAX. 1L /1000 Km
-
Manual transmission
With PTO
3.5 l (3.7 US qt.)
API GL-4, SAE 75W/85 (Synthetic)
fluid
Without PTO
3.2 l (3.38 US qt.)
Tropical zone
2.5 ± 0.25 l (2.64 ± 0.26 US qt.)
API GL-5, SAE 140
Rear axle oil
Temperated/frigid zone
2.5 ± 0.25 l (2.64 ± 0.26 US qt.)
API GL-5, SAE 80W90
15 l (15.9 US qt.)
Mixture of antifreeze and distilled water
BUS
Coolant
15.2 l (16.1 US qt.) (with preheat)
(Ethylene glycol base coolant for
VAN, Truck
11.2 l (11.8 US qt.)
aluminum radiator)
8
Power steering fluid
1.15 l (1.2 US qt.)
PSF-3
*1 Refer to the recommended SAE viscosity numbers on 8-9 page.
*2 Engine oils labeled Energy Conserving Oil are now available. Along with other additional benefits, they contribute to fuel econo-
my by reducing the amount of fuel necessary to overcome engine friction. Often, these improvements are difficult to measure in
everyday driving, but in a year’s time, they can offer significant cost and energy savings.
8-7
Specifications & Consumer information
Lubricant
Volume
Classification
Brake/clutch fluid
0.984 l (1.04 US qt.)
FMVSS116 DOT-4
AUS 32 DIN V70070, ISO/DIS 22241-1 (If the vehicle is driven with
Urea solution
22 l (23.2 US qt.)
urea solution volume less than 4%, engine output will be limited.
And if it is less than 1%, vehicle speed will be limited to 20 km/h.)
Fuel
75 l (79.3 US gal.)
Refer to “Fuel requirements” in foreword
Urea consumption per liter
580 km
Available Engine oil (For Europe)
Product
Supplier
Diesel Engine
Shell
HELIX ULTRA AP-L 5W-30
8-8
Recommended SAE viscosity
Engine oil viscosity (thickness) has an effect on fuel economy and cold
number
weather operating (engine start and engine oil flowability). Lower viscosity
engine oils can provide better fuel economy and cold weather performance,
however, higher viscosity engine oils are required for satisfactory lubrication
CAUTION
in hot weather.
Always be sure to clean the area
Using oils of any viscosity other than those recommended could result in
around any filler plug, drain
engine damage.
plug, or dipstick before check-
When choosing an oil, consider the range of temperature your vehicle will be
ing or draining any lubricant.
operated in before the next oil change. Proceed to select the recommended
This is especially important in
oil viscosity from the chart.
dusty or sandy areas and when
the vehicle is used on unpaved
Temperature Range for SAE Viscosity Numbers
roads. Cleaning the plug and
°C
-30
-20
-10
0
10
20
30
40
50
dipstick areas will prevent dirt
Temperature
and grit from entering the
(°F)
-10
0
20
40
60
80
100
120
engine and other mechanisms
15W-40
that could be damaged.
10W-30/40
Diesel
Engine Oil
5W-30/40
0W-30/40
8
8-9
Specifications & Consumer information
VEHICLE IDENTIFICATION NUMBER (VIN)
VEHICLE CERTIFICATION
Frame number
VIN label (if equipped)
LABEL
OEU074057
OEU084002
The vehicle identification number
The VIN is also on a plate attached
OEU084003
(VIN) is the number used in register-
to the top of the dashboard. The
The vehicle certification label
ing your vehicle and in all legal mat-
number on the plate can easily be
attached on the driver’s (or front pas-
ters pertaining to its ownership, etc.
seen through the windshield from
senger’s) side center pillar gives the
outside.
The number is punched on the
vehicle identification number (VIN).
engine compartment bulkhead.
8-10
TIRE SPECIFICATION AND
ENGINE NUMBER
AIR CONDITIONER
PRESSURE LABEL
COMPRESSOR LABEL
OEU084005
OEU084004
The engine number is stamped on
OHC081001
the engine block as shown in the
The tires supplied on your new vehi-
A compressor label informs you the
drawing.
cle are chosen to provide the best
type of compressor your vehicle is
performance for normal driving.
equipped with such as model, suppli-
The tire label located on the driver's
er part number, production number,
refrigerant (1) and refrigerant oil (2).
side center pillar gives the tire pres-
sures recommended for your vehicle.
8
8-11
Specifications & Consumer information
DECLARATION OF
CONFORMITY
■ Example
CE0678
The radio frequency components of
the vehicle comply with requirements
and other relevant provisions of
Directive 1995/5/EC.
Further information including the
manufacturer's declaration of con-
formity is available on HYUNDAI web
site as follows;
8-12
Большое спасибо!
Ваше мнение очень важно для нас.
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст