Dacia Pick-Up 1304/1305/1307. Service manual — part 117
HEATING
61
61 - 2
( for the commercials with dashboard type 1325 )
D
ISMO UNTING
Disconnect the battery.
Dismount the switch knob (1), the climate control switch and the luminous plate (2).
Disconnect the connections of the luminous plate and the vacuum hoses.
Dismount the attachment screws (3) of the climate control.
Take out the climate control block from its housing.
Disconnect the climate control valve cable (4) and the climate control cable.
R
EMO UNTING
Perform the dismounting operations in the reverse order.
CLIMATE CONTROL BLOCK
1
2
3
4
61
HEATING
61 - 3
D
ISMO UNTING
In case AC system can not be used, the classis climate control system may be used
according to necessities.
Dismount the dashboard.
Disconnect the wires from the dashboard wiring.
Dismount the control cables of the distribution flaps and mixing flaps from the control
levers and the recycling flaps cable from the climate control panel.
Dismount the ducts of the heating valve and the aeration connection.
Dismount the attachment nuts of the climate control unit (4) - positions (1),(2) and (3).
Detach the climate control unit through inside cockpit, together with the ducts, through
the iron plate shutter.
R
EMO UNTING
Perform the dismounting operations in the reverse order.
CLIMATE CONTROL UNIT
1
2
3
4
HEATING
61
61 - 4
D
ISMO UNTING
Clamp the heating hoses (1) , (2) by means of the clamp (3) – MOT 453 and dismount
the hoses from the valve.
Dismount the control cable (4) of the valve (5) and bring the valve in the OFF position.
Dismount the climate control valve.
NOTE: The valve cannot be repaired.
R
EMO UNTING
Valve remounting is to be done by performing the dismounting operations in the
reverse order, observing the following conditions:
- the valve control cable is mounted at the valve control lever so that valve is set in
open position and the control lever is moved to the right, leaving a clearance of 3-4 mm.
In this position attach the cable sheath by means of clip, than check the correct operation
of the lever and valve closing;
- after remounting the climate control valve, the purging of the cooling system and
the checking of the cooling fluid in the expansion vessel must be obligatory performed.
CLIMATE CONTROL VALVE
1
2
3
4
5
61
HEATING
61 - 5
CLIMATE CONTROL G.M.V.
A.COMMERCIALS EQUIPPED WITH DASH BOARD TYPE SERIES
Climate control GMV is located under the dashboard, in the right side and can be with
one or two rotation steps.
D
ISMO UNTING
Disconnect the battery.
Disconnect the GMV connectors from
the right connection plate (+DC).
Dismount the attachment screws of the
GMV on the iron plate.
R
EMO UNTING
Perform the dismounting operations in
the reverse order.
B
.COMMERCIALS EQUIPPED WITH DASHBOARD TYPE 1325
The climate control GMV is mounted in the climate control unit. It is located under
the dashboard, in the central zone, being attached on the iron plate and it has 4 rotation
steps. Dismount the GMV, after previously the climate control unit has been dismounted
from the vehicle.
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст