SsangYong Rexton. Service manual — part 530
ABS AND TCS 4E-87
SSANGYONG Y200
Yes
Step
Use the scan tool to determine if any other DTCs are
set.
Are other DTCs set?
Clear all DTCs and road test the vehicle.
Does DTC 550 set again?
1. Check all wiring harness connectors and terminals,
especially those at the EBCM, for any condition
that could cause an intermittent.
2. Repair any problems found.
Is the repair complete?
1. Turn the ignition to OFF.
2. Disconnect the EBCM connector.
3. Turn the ignition to ON.
4. Measure the voltage between ground and terminals
15, 17 and 18 of the EBCM harness connector.
Is the voltage equal to the specified value?
1. Check the voltage supply and the ground
connections to the EBCM.
2. Repair any open or high resistance found.
Is the repair complete?
Check the EBCM connector for any damaged
terminals.
Are there any problems?
Repair any connector problem found.
Is the repair complete?
Clear all DTCs and road test the vehicle.
Does DTC 550 set again?
Replace the EBCM.
Is the repair complete?
DTC 550 - EBCM Internal Fault
1
Action
No
Value
2
3
Go to the
applicable
Diagnostic
Table
Go to Step 2
-
4
5
6
System OK
-
-
System OK
-
-
Go to Step 4
Go to Step 3
-
Go to Step 6
Go to Step 5
11 - 14 V
Go to Step 7
Go to Step 8
-
7
System OK
-
-
Go to Step 9
System OK
-
System OK
-
-
8
9
SSANGYONG Y200
4E-88 ABS AND TCS
SCHEMATIC AND ROUTING DIAGRAMS
YAD4E280
ABS 5.3 CIRCUIT
ABS AND TCS 4E-89
SSANGYONG Y200
YAD4E290
ABD 5.3 CIRCUIT
SSANGYONG Y200
4E-90 ABS AND TCS
Wire Color
WHT
BLK/GRN
-
BLK/RED
WHT/RED
BRN
BLK/WHT
BRN/BLK
BRN/WHT
RED/BLK
BLU/BLK
-
WHT/GRN
YEL
BRN/RED
BLK
CONNECTOR END VIEWS
EBCM (HYDRAULIC MODULATOR/UNIT INTEGRATED)
YAD4E300
Pin
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
Circuit
Right Rear Speed Sensor Ground
Right Rear Speed Sensor
Not Used
Right Front Speed Sensor Ground
Right Front Speed Sensor
Left Front Speed Sensor Ground
Left Front Speed Sensor
Left Rear Speed Sensor Ground
Left Rear Speed Sensor
Acceleration Sensor Signal
Data Link Connector
Not Used
TOD
Stoplamp SW
Ignition
Ground
Wire Color
RED/WHT
RED/WHT
BLK
GRN/BRN
GRN/BLK
BLU
YEL/GRN
-
-
-
-
RED/GRN
-
-
-
Pin
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
Circuit
Battery
Battery
Ground
ABS Warning Lamp
EBD Warning Lamp
TCS Warning Lamp
Acceleration Sensor Supply
Voltage (5V)
Not Used
Not Used
Not Used
Not Used
Acceleration Sensor Ground
Not Used
Not Used
Not Used
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст