JAC Trucks. Service manual — part 87
schematic of different fuse installation
15A 10A 15A 15A 15A 15A 20A 15A 15A 30A
15A 20A 30A 20A 15A 20A 15A 15A 10A 30A
Normal
broken
If the fuse is found broken, check and try to find out the reason for that. Take
necessary maintenance measures before fuse replacement.
Before changing the fuse, turn the start switch to "LOCK" position, and must
use fuses of the same current rating.
134
OWNER爷S MANUAL
JAC High end Light Trucks
Front light set
When replacing bulbs, take down the cover first, then the decoration bands for
the headlights screw off the 4 screws, and the bulbs can be taken out.
Rear light set
When replacing the bulbs, you have to take down the tail light before taking out
the bulb from behind the tail light.
Non-return reflector
Turn signal light
Brake light
Rear light
Rear fog light
Reverse light
135
136
Battery electrolyte level
The battery electrolyte level should be between the upper and lower scale
marks. If the level is too low, it is necessary to add more distilled water.
Headlights
Properly adjust the headlights, to ensure adequate illumination level on the
highways and no dazzle lighting to drivers in other vehicles head-on. When you
need to adjust the headlights, you'd better contact the authorized JAC service
stations that have special equipment.
The headlights' lighting
Tighten the Screw A for vertical adjustment, and tighten Screw B for horizontal
adjustment.
OWNER爷S MANUAL
JAC High end Light Trucks
User
Power(W)
User
Power(W)
User
Power(W)
Front windshield wiper
60
Rear fog light
25
Brake light
25伊2
Front fog light
55伊2
High beam
60伊2
Low beam
55伊2
Reverse light
20伊2
CD set
80
Electric horn
42
Marker light
10伊5
Blower
120
Turn signal light
21伊4
Ceiling light
10
Instruments
70
Others
30
Replacement of bulbs
The removable parts of all lamps are illustrated respectively for reference.
The switches must be turned off when replacing the bulbs and only bulbs of the same rating can be used. The standard
bulb ratings are listed below:
137
Washing of battery
If the exterior parts of the battery are dirty, use warm water to wash them. To
prevent corrosion, apply a thin layer of Vaseline or grease to the surface of the
terminal stud of the battery.
Specific gravity of the battery electrolyte
If the electrolyte hydrometer reads 1.26 at 20益, it can be deemed that the bat鄄
tery is fully charged.
If the specific gravity is lower than 1.23, the battery needs recharging.
138
OWNER爷S MANUAL
JAC High end Light Trucks
Recommended brands of lubricants and diesels
For the best performance and the longest service life of your vehicle, proper brands of lube oils and diesels should be
used according to the recommendation in the list below.
Location
Oil products recommended
Quantity
Engine oil sump
diesel engine lube oil
Above CE class
For the viscosity, refer to the list of engine lube oil viscosity vs. temperature
6
Gearbox
Summer: GL-4/85W-90
2.7
Winter: GL-4/80W-90
Power steering gear
Auto gearbox oil
As needed
Rear axle
Medium load automotive gear oil
Class GL-4
For the viscosity, refer to the list of gear oil viscosity vs. temperature
3.5
Brake fluid reservoir
DOT3 or DOT4
As needed
Clutch fluid reservoir
DOT3 or DOT4
As needed
Wheel bearings
Multipurpose grease or lithium-based wheel bearing grease
As needed
Intermediate bearing of drive shaft
No.2 or 3 universal lithium-based grease for automobiles
As needed
Clutch yoke
No.2 or 3 universal lithium-based grease for automobiles
As needed
Drive shaft slide bushing
Foss EPT-2.5 grease
As needed
Driving universal joint
Foss EPT-2.5 grease
As needed
Engine cooling system
Glycol anti-freezing fluid
with preservative
As needed
Fuel tank
Summer: No.0 quality light diesel
Winter: No.-10 quality light diesel
Ambient temperature below -30益: No.-35 quality light diesel
92
139
140
Lube oils must be selected and used carefully according to the lubricated points, and it is especially important to select
proper lube oil viscosity according to the ambient temperature;
Table of diesel viscosity for diesel engines
Table of gear oil viscosity
Infill diesel engine lube oil
Infill gear oil
Lubrication
渊single class冤
enviromment
temperature
渊multilevel冤
Correlation of engine lube oil
viscosity vs ambient temperature
OWNER爷S MANUAL
JAC High end Light Trucks
渊single class冤
Correlation of engine lube oil
viscosity vs ambient temperature
渊multilevel冤
enviromment
temperature
List of lubrication points
Steering gear
drag link
clutch fluid&brake fluid
king steering pin
front hub bearing
tie rod end
engine
rear leaf spring pin
rear hub bearing
differential
rear leaf spring lifting lug pin
king steering pin
front hub bearing
tie rod end
gearbox
drive shaft universal joint
drive shaft universal joint
drive shaft slide bushing
rear leaf spring pin
drive shaft universal joint
rear hub bearing
rear leaf spring lifting lug pin
at the first 1000km
every other month or 3000km
every 6 months or 18000km
every 8 months or 24000km
every other year or 36000km
Lubrication points
replace
W:wheel bearing grease
check, infill or lubricate
C: multipurpose grease
E: engine oil
M: lithium-based grease
G: gear oil
B: brake fluid
141
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст