Daewoo Nubira. Manual — part 16
Description
Page
Paint Codes
3 of 3
November, 1998
Paint Manufacturer Telephone Numbers:
Akzo
Customer Assistance . . . . . . . . . . . . . . .(800) 618-1010
Dupont
Customer Assistance . . . . . . . . . . . . . . .(800) 338-7668
PPG
Color Library/Codes/Formulas . . . . . . .(440) 572-6100
Technical Assistance . . . . . . . . . . . . . . .(440) 572-6111
Sherwin Williams
Customer Assistance . . . . . . . . . . . . . . .(800) 798-5872
Martin Senour
Customer Assistance . . . . . . . . . . . . . . .(800) 526-6704
TECHNICAL SERVICE BULLETIN
TECHNICAL SERVICE BULLETIN
Description:
Reference:
Prod. Dates:
Bulletin No.:
Model(s):
Date:
VIN Range:
Group:
TSB-002-98
1998-99 Nubira 5-Door
November 25, 1998
See Attached
Rear Hatch Lock Rod
Body
N/A
N/A
General Manager
Service Manager
Technician(s)
Service Advisor
Body Shop Manager
Parts Manager
Circulate To:
√
√
√
√
√
√
For some Nubira 5-Door models, it is possible that
the alarm may be triggered when opening the rear
hatch with the key. If the key is rotated slowly, it is
possible that the rear latch could be released before
the lock switch disables the alarm system. To correct
this condition, Daewoo has developed an updated
rear hatch lock rod which is 5 mm shorter than the
original rod.
A supply of updated lock rods has been shipped to
your location and are available for customer
complaints/concerns.
All applicable Store stock units should be immediately updated with the new lock rod.
Affected customer vehicles, demonstrators, DCA vehicles, etc. should be updated as they
come in for periodic service and/or repairs regardless if a complaint has been made.
A list of applicable Nubira 5-Door Vehicle Identification Numbers (VIN’s) has been attached
for your reference.
REAR HATCH LOCK ROD REMOVAL / INSTALLATION INSTRUCTIONS
Lock Rod Removal:
1.
Raise the rear hatch to its fully opened position.
2.
Remove the rear hatch inner trim panel by
removing and retaining the four (4) screws and
three (3) trim panel clips.
Rear Hatch
Inner Trim Panel
“New”
Lock Rod
“Old”
Lock Rod
Description
Page
Rear Hatch Lock Rod
2 of 2
November, 1998
3.
Release the two (2) lock rod plastic lock tabs
and remove the lock rod.
Lock Rod Installation:
1.
Install the new lock rod and reattach the two (2)
plastic lock tabs.
2.
Reinstall the rear hatch inner trim panel, the
four (4) retaining screws and the three (3) trim
panel clips.
3.
Verify the operation of the latch rod by first
setting the alarm system, then opening the rear
hatch by slowly rotating the key in the cylinder.
Parts Information:
Part Name
Part Number
Qty. Req’d
Rod-Key Cyl, T/Gate
96237711
1
Warranty Information:
Operation Code
Operation Description
Labor Time
F896112
Rod, T/Gate Lock, Replace
0.2 hr
Causal Part Number: 96301830
Nature Code: N65
Cause Code: R31
“Old”
Lock Rod
“New”
Lock Rod
SECTION : 9O
BUMPERS AND FASCIAS
CAUTION : Disconnect the negative battery cable before removing or installing any electrical unit or when a tool
or equipment could easily come in contact with exposed electrical terminals. Disconnecting this cable will help
prevent personal injury and damage to the vehicle. The ignition must also be in LOCK unless otherwise noted.
TABLE OF CONTENTS
SPECIFICATIONS
9O–1
. . . . . . . . . . . . . . . . . . . . . . . . . .
FASTENER TIGHTENING SPECIFICATIONS
9O–1
.
MAINTENANCE AND REPAIR
9O–2
. . . . . . . . . . . . . . .
ON–VEHICLE SERVICE
9O–2
. . . . . . . . . . . . . . . . . . . . .
FRONT BUMPER FASCIA
9O–2
. . . . . . . . . . . . . . . . . .
FRONT BUMPER ENERGY ABSORBER
9O–6
. . . . .
FRONT BUMPER IMPACT BAR
9O–6
. . . . . . . . . . . . .
REAR BUMPER FASCIA
9O–8
. . . . . . . . . . . . . . . . . . .
REAR BUMPER ENERGY ABSORBER
9O–11
. . . . .
REAR BUMPER IMPACT BAR
9O–12
. . . . . . . . . . . . .
GENERAL DESCRIPTION AND SYSTEM
OPERATION
9O–14
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
BUMPERS
9O–14
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
SPECIFICATIONS
FASTENER TIGHTENING SPECIFICATIONS
Application
N
S
m
Lb–Ft
Lb–In
Fender–to–Fascia Bolts
1.5
–
13
Front Impact Bar Bolts
35
26
–
Front Impact Bar Nuts
22
16
–
Front Wheel Well Fascia
Bolts
1.5
–
13
Front Wheel Well Splash
Shield Bolts
1.5
–
13
Luggage Compartment
Fascia Bolts
8
–
71
Rear Impact Bar Bolts
35
26
–
Rear Impact Bar Bracket
Nuts
30
22
–
Rear Wheel Mud Guard
Bolts
1.5
–
13
Rear Wheel Well Fascia
Bolts
1.5
–
13
Rear Wheel Well Splash
Shield Bolts
1.5
–
13
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст