Hyundai Santa Fe (2006 year). Manual — part 2
GENERAL
ST -5
Tool (Number and Name)
Illustration
Use
09432-21600
Braring installer
APJF001K
Installing the pinion gear bearing
09434-14200
Counter shaft bearing installer
APJF001M
Installing the gear box oil seal
09565-11100
Preload socket
APJF001A
Measuring the pinion shaft preload
ST -6
STEERING SYSTEM
TROUBLESHOOTING
E4FE78AA
Symptom
Probable cause
Remedy
Loose yoke plug
Retighten
Loose steering gear mounting bolts
Retighten
Excessive play in steering
Loose or worn tie rod end
Retighten or replace as necessary
V-belt slippage
Readjust
Damaged V-belt
Replace
Low fluid level
Replenish
Air in the fluid
Bleed air
Twisted or damaged hoses
Correct the routing or replace
Insufficient oil pump pressure
Repair or replace the oil pump
Sticky flow control valve
Replace
Excessive internal oil pump leakage
Replace the damaged parts
Excessive oil leaks from rack and
pinion in gear box
Replace the damaged parts
Steering wheel operation is not
smooth (Insufficient power assist)
Distorted or damaged gear box
or valve body seals
Replace
Excessive turning resistance
of tierod end
Replace
Yoke plug excessively tight
Adjust
Tie rod and/or ball joint cannot
turn smoothly
Replace
Loose mounting of gear box
mounting bracket Worn steering
shaft joint and/or
Retighten
Worn steering shaft joint and/or
body grommet
Correct or replace
Distorted rack
Replace
Damaged pinion bearing
Replace
Twisted or damaged hoses
Reposition or replace
Damaged oil pressure control valve
Replace
Steering wheel does not return
properly
Damaged oil pump input shaft bearing
Replace
Noise
Hissing Noise in Steering Gear
There is some noise with all power steering systems. One of the most
common is a hissing sound when the steering wheel is turned and the car
is not moving. This noise will be most evident when turning the wheel
while the brakes are being applied. There is no relationship between
this noise and steering performance. Do not replace the valve unless
the "hissing" noise becomes extreme. A replaced valve will also make
a slight noise, and is not always a solution for the condition.
GENERAL
ST -7
Symptom
Probable cause
Remedy
Interference with hoses from
vehicle body
Reposition
Loose gear box bracket
Retighten
Loose tie rod end and/or ball joint
Retighten
Rattling or chucking noise in the
rack and pinion
Worn tie rod and/or ball joint
Replace
Low fluid level
Replenish
Air in the fluid
Bleed air
Loose pump mounting bolts
Retighten
Noise in the oil pump
Loose yoke plug
Retighten
ST -8
STEERING SYSTEM
SERVICE ADJUSTMENT
PROCEDURE
E2570252
CHECKING STEERING WHEEL FREE PLAY
1.
Start the engine and with the steering wheel in the
straight ahead position.
2.
Measure the play while turning the steering wheel to
the left and right.
Standard value :
Steering wheel free play : 30 mm (1.2 in)
SCMST6513L
3.
If the play exceeds the standard value, inspect the
connection between the steering shaft and tie rod
ends.
CHECKING STEERING ANGLE
1.
Place the front wheel on a turning radius gauge and
measure the steering angle.
STEERING ANGLE
Inner
39.2
Outer
31.6
2.
If the measured value is not within the standard value,
adjust the toe and inspect again.
EPRF010A
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст