Chrysler 300/300 Touring/300C, Dodge Magnum. Manual — part 2325
SPECIFICATIONS
A/C SYSTEM
Item
Description
Notes
A/C Compressor
Denso 10S17
ND-8 PAG oil
Freeze–up Control
Evaporator Temperature Sensor
HVAC housing mounted
Low psi Control
A/C Pressure Transducer
Liquid line mounted - opens below
110 kPa (16 psi), closes above 220
kPa (32 psi)
High psi Control
A/C Pressure Transducer
Liquid line mounted - opens above
3219 kPa (476 psi), closed below
2937 kPa (426 psi)
Refrigerant Capacity
Refer to the A/C Underhood
Specification Label located in the
engine compartment
R-134a refrigerant
A/C Clutch Coil Draw
3.3 amps
@ 12V ± 0.5V @ 21° C (70° F)
A/C Clutch Coil Resistance
3.6 ± 0.2 ohms
When measured across coil lead
connector
A/C Clutch Air Gap
0.35 - 0.60 mm (0.014 - 0.024 in.)
TORQUE
Description
N·m
Ft. Lbs.
In. Lbs.
All Screws NOT Listed
Below
2
—
17
A/C Compressor to 2.7L
Engine Front Bolts
26
19
—
A/C Compressor to 2.7L
Engine Rear Bolt
50
37
—
A/C Compressor to 3.0L
Engine Bolts
26
19
—
A/C Compressor to 3.5L
Engine Bolts
26
19
—
A/C Compressor to
5.7L/6.1L Engine Bolts
50
37
—
A/C Condenser to
Radiator Bolts
5
—
44
A/C Expansion Valve to
Evaporator Tube Tapping
Block Bolts
11
—
97
Air Distribution Housing
Halves Screws
2.2
—
20
Air Distribution Housing to
HVAC Housing Screws
2.2
—
20
Air Inlet Housing to HVAC
Housing Screws
2.2
—
20
Blower Motor Screws
2.2
—
20
Compressor Shaft Bolt
19
—
168
Flange to HVAC Housing
Screws
2.2
—
20
24 - 334
HVAC - SERVICE INFORMATION
LX
Description
N·m
Ft. Lbs.
In. Lbs.
Floor Console Duct to
Floor Panel Screws
2.2
—
20
Fresh Air Inlet Housing/
Water Separator Filter
Housing to Dash Panel
Nuts
7
—
62
Heater Core Retaining
Bracket to Air Distribution
Housing Screw
2.2
—
20
HVAC Housing Halves
Screws
2.2
—
20
HVAC Housing to Engine
Side of Dash Panel Nuts
7
—
62
HVAC Housing to
Passenger Side of Dash
Panel Nuts
3
—
26
Instrument Panel/demister
Ducts to Instrument Panel
Screw
2.2
—
20
Liquid Line Front to Rear
Section Nut
22
16
—
PTC Heater Unit Screws
2.2
–
20
Refrigerant Lines to A/C
Expansion Valve Nut
23
17
—
Refrigerant Line to A/C
Compressor Nut
23
17
—
Refrigerant Line to A/C
Condenser Nut
22
16
—
Refrigerant Line Bracket to
Strut Tower Bolt
11
—
97
Receiver/drier to A/C
Condenser Bolt
22
16
—
Receiver/drier Bracket to
A/C Condenser Screw
5
—
44
Suction Line Front to Rear
Section Nut
22
16
—
Strut Support to Strut
Tower Bolts
38
28
—
LX
HVAC - SERVICE INFORMATION
24 - 335
SPECIAL TOOLS
HEATING-A/C SYSTEM
Trim Stick C-4755
24 - 336
HVAC - SERVICE INFORMATION
LX
CONTROLS
TABLE OF CONTENTS
page
page
ACTUATOR-BLEND DOOR
ACTUATOR-MODE DOOR
ACTUATOR-RECIRCULATION DOOR
CLUTCH-A/C COMPRESSOR
A/C COMPRESSOR CLUTCH COIL . . . . . . . . . . 348
CONTROL-A/C-HEATER
MODULE-POWER-BLOWER MOTOR
RELAY-A/C CLUTCH
DESCRIPTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 361
RESISTOR-BLOWER MOTOR
BLOWER MOTOR RESISTOR . . . . . . . . . . . . . . . 363
SENSOR-AMBIENT AIR TEMPERATURE
SENSOR-EVAPORATOR TEMPERATURE
SENSOR-INFRARED
SENSOR-SUN
SUN SENSOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 371
TRANSDUCER-A/C PRESSURE
LX
CONTROLS
24 - 337
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст