Chrysler Town, Dodge Caravan. Manual — part 1076
MAINTENANCE SCHEDULES
TABLE OF CONTENTS
page
MAINTENANCE SCHEDULES FOR ALL
MARKETS EXCEPT U.S., CANADA and
MEXICO
DESCRIPTION — DIESEL ENGINES
MAINTENANCE SCHEDULES
FOR ALL MARKETS EXCEPT
U.S., CANADA and MEXICO
DESCRIPTION — DIESEL ENGINES
Maintenance Schedule Information not included in
this section, is located in the appropriate Owner’s
Manual.
There are two maintenance schedules that show
the required service for your vehicle.
First is Schedule “B”. It is for vehicles that are
operated under the conditions that are listed below
and at the beginning of the schedule.
• Extensive engine idling.
• Driving in dusty conditions.
• More than 50% of your driving is at sustained
high speeds during hot weather, above 32° C (90° F).
• Trailer towing.
• Taxi, police, or delivery service (commercial ser-
vice).
NOTE: Most vehicles are operated under the condi-
tions listed for Schedule
(
B
(
.
Second is Schedule “A”. It is for vehicles that are
not operated under any of the conditions listed under
Schedule
9B9.
Use the schedule that best describes your driving
conditions. Where time and mileage are listed, follow
the interval that occurs first.
CAUTION: Failure to perform the required mainte-
nance items may result in damage to the vehicle.
At Each Stop for Fuel
• Check the engine oil level about 5 minutes after
a fully warmed engine is shut off. Checking the oil
level while the vehicle is on level ground will
improve the accuracy of the oil level reading. Add oil
only when the level is at or below the ADD or MIN
mark.
• Check the windshield washer solvent and add if
required.
Once a Month
• Check the tire pressure and look for unusual
wear or damage.
• Inspect the battery and clean and tighten the
terminals as required.
• Check the fluid levels of coolant reservoir, brake
master cylinder, power steering and transmission
and add as needed.
• Check all lights and all other electrical items for
correct operation.
At Each Oil Change
• Change the engine oil filter.
• Inspect the exhaust system.
• Inspect the brake hoses.
• Inspect the CV joints and front suspension com-
ponents.
• Check the manual transmission fluid level.
• Check the coolant level, hoses, and clamps.
• Inspect engine accessory drive belts. Replace as
necessary.
• Inspect for the presence of water in the fuel fil-
ter/water separator unit.
• Rotate the tires at each oil change interval (20
000 km).
SCHEDULE “B”
Follow schedule “B” if you usually operate your
vehicle under one or more of the following conditions.
• Extensive engine idling.
• Driving in dusty conditions.
• More than 50% of your driving is at sustained
high speeds during hot weather, above 32° C (90° F).
• Trailer towing.
• Taxi, police, or delivery service (commercial ser-
vice).
RG
MAINTENANCE SCHEDULES
0 - 1
Kilometers
10 000 km
20 000 km
30 000 km
40 000 km
50 000 km
Change engine oil and engine oil filter.
X
X
X
X
X
Inspect engine air filter element. Replace as
necessary.
X
X
X
Replace engine air filter element
X
X
Replace fuel filter/water separator unit.
X
X
Check front end alignment.
X
X
Change the manual transaxle fluid.
X
Inspect the tie rod ends and boot seals.
X
Inspect the brake linings.
X
X
X
X
X
Kilometers
60 000 km
70 000 km
80 000 km
90 000 km
100 000 km
Change engine oil and engine oil filter.
X
X
X
X
X
Inspect engine air filter element. Replace
as necessary.
X
X
Replace engine air filter element
X
X
X
Replace fuel filter/water separator unit.
X
X
X
Replace engine timing belt.
X
Check front end alignment.
X
X
Change the manual transaxle fluid.
X
X
Inspect the tie rod ends and boot seals.
X
Inspect the brake linings.
X
X
X
X
X
Kilometers
110 000 km
120 000 km
130 000 km
140 000 km
150 000 km
160 000 km
Change engine oil and
engine oil filter.
X
X
X
X
X
X
Inspect engine air filter
element. Replace as
necessary.
X
X
X
Inspect accessory drive
belts and replace if
necessary.
X
Replace engine air filter
element
X
X
X
Replace fuel filter/water
separator unit.
X
X
X
Flush and replace engine
coolant.
X
Check front end alignment.
X
X
X
Inspect the tie rod ends and
boot seals.
X
X
Inspect the brake linings.
X
X
X
X
X
X
Inspection and service should also be performed
anytime a malfunction is observed or suspected.
Retain all receipts.
0 - 2
MAINTENANCE SCHEDULES
RG
MAINTENANCE SCHEDULES FOR ALL MARKETS EXCEPT U.S., CANADA and MEXICO (Continued)
SCHEDULE “A”
Kilometers
20 000 km
40 000 km
60 000 km
80 000 km
100 000 km
Change engine oil and engine oil filter.
X
X
X
X
X
Inspect engine air filter element. Replace
as necessary.
X
X
X
Replace engine air filter element
X
X
Replace fuel filter/water separator unit.
X
X
X
X
X
Replace engine timing belt.
X
Check front end alignment.
X
X
Inspect the tie rod ends and boot seals.
X
X
Inspect the brake linings.
X
X
X
X
X
Kilometers
120 000 km
140 000 km
160 000 km
180 000 km
Change engine oil and engine oil filter.
X
X
X
X
Inspect engine air filter element. Replace as
necessary.
X
X
Inspect accessory drive belts and replace if
necessary.
X
Replace engine air filter element
X
X
Replace fuel filter/water separator unit.
X
X
X
X
Flush and replace engine coolant.
X
Check front end alignment.
X
X
Inspect the tie rod ends and boot seals.
X
X
Inspect the brake linings.
X
X
X
X
Inspection and service should also be performed
anytime a malfunction is observed or suspected.
Retain all receipts.
WARNING: You can be badly injured working on or
around a motor vehicle. Do only that service work
for which you have the knowledge and the right
equipment. If you have any doubt about your ability
to perform a service job, take your vehicle to a
competent mechanic.
RG
MAINTENANCE SCHEDULES
0 - 3
MAINTENANCE SCHEDULES FOR ALL MARKETS EXCEPT U.S., CANADA and MEXICO (Continued)
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст