RAM 3500 Chassis Cab (2019 year). Manual — part 24
380 IN CASE OF EMERGENCY
3. Pull the bulb straight from it's socket and replace.
Removing The Bulb From The Bulb Socket
FUSES
WARNING!
• When replacing a blown fuse, always use an appro-
priate replacement fuse with the same amp rating as the
original fuse. Never replace a fuse with another fuse of
higher amp rating. Never replace a blown fuse with
metal wires or any other material. Do not place a fuse
inside a circuit breaker cavity or vice versa. Failure to
use proper fuses may result in serious personal injury,
fire and/or property damage.
• Before replacing a fuse, make sure that the ignition is
off and that all the other services are switched off and/
or disengaged.
• If the replaced fuse blows again, contact an authorized
dealer.
• If a general protection fuse for safety systems (air bag
system, braking system), power unit systems (engine
system, transmission system) or steering system blows,
contact an authorized dealer.
-------------------------------------------------------------------------------------------------------------------------------------------------------------
IN CASE OF EMERGENCY
381
Power Distribution Center
The Power Distribution Center is located in the engine
compartment near the battery. This center contains cartridge
fuses, micro fuses, relays, and circuit breakers. A description
of each fuse and component may be stamped on the inside
cover, otherwise the cavity number of each fuse is stamped
on the inside cover that corresponds to the following chart.
Power Distribution Center Location
Cavity
Cartridge Fuse
Micro Fuse
Description
F01
80 Amp Black
–
Rad Fan Control Module – If Equipped (DS 1500 Only)
F02
60 Amp Yellow
–
ABS Pump Motor (HD Only)
F03
60 Amp Yellow
–
Rad Fan – If Equipped
F04
50 Amp Red
400W Inverter – If Equipped (HD Only)
F05
40 Amp Green
50 Amp Red (Special
Services Vehicle (SSV))
–
Compressor For Air Suspension – If Equipped
F06
40 Amp Green
–
ABS Pump Motor (DS 1500 Only)
F07
40 Amp Green
–
Starter Solenoid
6
-------------------------------------------------------------------------------------------------------------------------------------------------------------
382 IN CASE OF EMERGENCY
F08
20 Amp Blue (DS 1500
LD/Cummins Diesel)
40 Amp Green
–
–
NOX Sensor – If Equipped
Aux Relay Output- SSV Only
F09
40 Amp Green (SSV &
Cummins Diesel)
–
Aux Relay Output / Diesel Fuel Heater – If Equipped
F09
30 Amp Pink
–
Brake Vacuum Pump – If Equipped (HD Only)
F10
40 Amp Green
–
Body Controller / Exterior Lighting #2
F11
30 Amp Pink
–
PWR - Trailer Tow Electric Brake Batt Feed – If
Equipped (DS 1500 Only)
F11
40 Amp Green
–
Brake System Module (ECU and Valves) (HD Only)
F12
40 Amp Green
–
Body Controller #3
F13
40 Amp Green
–
Blower Motor
F14
40 Amp Green
–
Body Controller #4 / Exterior Lighting
F15
30 Amp Pink
40 Amp Green
–
–
Power Side Steps – If Equipped (HD Only)
Extra Fuse - SSV Only
F16
30 Amp Pink
–
Smart-Bar Module – If Equipped (HD Only)
F17
30 Amp Pink
–
Winch Control Module – If Equipped (HD Only)
F19
20 Amp Blue (DS 1500
LD Diesel)
30 Amp Pink
(Cummins Diesel)
–
SCR – If Equipped
Cavity
Cartridge Fuse
Micro Fuse
Description
-------------------------------------------------------------------------------------------------------------------------------------------------------------
IN CASE OF EMERGENCY
383
F20
30 Amp Pink
–
Passenger Door Module
F21
30 Amp Pink
–
Drive Train Control Module
F22
20 Amp Blue
–
Engine Control Module GPEC / Heavy Duty / Other –
If Equipped
F22
25 Amp White
(Cummins Diesel)
–
PCM – If Equipped
F23
30 Amp Pink
–
CBC Feed # 1
F24
30 Amp Pink
–
Driver Door Module
F25
30 Amp Pink
–
Front Wiper
F26
30 Amp Pink
–
Antilock Brakes / Stability Control Module / Valves – If
Equipped (DS 1500 Only)
F28
20 Amp Blue
–
Trailer Tow Backup Lights – If Equipped
F29
20 Amp Blue
–
Trailer Tow Parking Lights – If Equipped
F30
30 Amp Pink
–
Trailer Tow Receptacle / Trailer Tow (Separate
E-Brake)/Trailer Tow (BUX)
F31
30 Amp Pink
–
Diesel Heater Control – If Equipped (DS 1500 LD Diesel)
F31
20 Amp Blue
–
Aux App SSV Only - If Equipped
F32
–
–
Aux Feed, Special Services Vehicle-If Equipped (DS 1500
Only)
F33
20 Amp Blue
–
Trans Control Module – If Equipped (HD Only)
Aux Feed, SSV Only (DS 1500 Only)
Cavity
Cartridge Fuse
Micro Fuse
Description
6
-------------------------------------------------------------------------------------------------------------------------------------------------------------
384 IN CASE OF EMERGENCY
F34
30 Amp Pink
–
Vehicle System Interface Module #2 – If Equipped
(HD Only)
SSV (DS 1500 Only)
F35
30 Amp Pink
–
Sunroof – If Equipped
F36
30 Amp Pink
–
Electric Back Light – If Equipped
F37
30 Amp Pink
–
Fuel Heater #2, Aux Relay 2 – If Equipped (HD Only)
SSV (DS 1500 Only)
F38
30 Amp Pink
–
Integrated Trailer Brake Module – If Equipped
(HD Only)
Power Inverter 115V AC – If Equipped (DS 1500 Only)
F39
20 Amp Blue
–
Power Outlet – SSV Only
F40
–
10 Amp Red
Ventilated Seats – If Equipped (HD Only)
F41
–
10 Amp Red
Active Grille Shutter / Active Air Dam – If Equipped
F42
–
20 Amp Yellow
Horn
F43
–
15 Amp Blue
Heated Steering Wheel – If Equipped (HD Only)
F44
–
10 Amp Red
Diagnostic Port
F46
–
10 Amp Red
Upfitters Relay Coil – If Equipped (HD Only)
Spare (DS 1500 Only)
F49
–
10 Amp Red
Instrument Panel Cluster / HVAC (DS 1500 Only)
Instrument Cluster / MOD CSG (HD Only)
Cavity
Cartridge Fuse
Micro Fuse
Description
-------------------------------------------------------------------------------------------------------------------------------------------------------------
IN CASE OF EMERGENCY
385
F50
–
20 Amp Yellow
Air Suspension Control Module – If Equipped
F51
–
10 Amp Red
Ignition Node Module / Keyless Ignition Node Module,
Radio Frequency Hub Module / Electric Steering
Column Lock - If Equipped
F52
–
5 Amp Tan
Battery Sensor
F53
–
20 Amp Yellow
Trailer Tow – Left Turn/Stop Lights - If Equipped
F54
–
20 Amp Yellow
Non Memory Adjustable Pedals - If Equipped
F56
–
15 Amp Blue
Additional Diesel Content - If Equipped (DS 1500 Only)
F57
–
20 Amp Yellow
TCM/PCM / Solenoid Trans Pressure SW (RFE Trans
Only) – If Equipped (HD Only)
Transmission (DS 1500 Only)
F58
–
10 Amp Red
Bed Lighting (LED) – If Equipped (HD Only)
F60
–
15 Amp Blue
Underhood Lamp / TCM – If Equipped (DS 1500 Only)
F61
–
10 Amp Red
UREA Sensor / PM Sensor – If Equipped (DS 1500 LD
Diesel & Cummins Diesel)
F62
–
10 Amp Red
Air Conditioning Clutch
F63
–
20 Amp Yellow
Ignition Coils (Gas), Ignition Coils Capacitors (Gas) /
Short Runner Valve Actuator / Urea Heater Control
Unit (DS 1500 LD Diesel) / RLY Coil Feed-SCR (DS 1500
LD Diesel)
Cavity
Cartridge Fuse
Micro Fuse
Description
6
-------------------------------------------------------------------------------------------------------------------------------------------------------------
386 IN CASE OF EMERGENCY
F64
–
25 Amp Clear
Fuel Injectors / Powertrain Control Module / SRV – If
Equipped
F65
–
10 Amp Red
MOD Inverter (Wake Up) / Power Port / USB IP /
WCPM – If Equipped (HD Only)
Spare (DS 1500 Only)
F66
–
10 Amp Red
Sunroof / Light and Rain Sensor Module / Inside
Rearview Mirror / Passenger Window SW / USB Port
Rear / Feed for R/A RLY #2 Coil – If Equipped
F67
–
10 Amp Red
CD / DVD / UCI Port – If Equipped (HD Only)
Bluetooth Hands-Free Module / CD – If Equipped
(DS 1500 Only)
F68
–
10 Amp Red
AEB RACAM HTR – If Equipped (HD Only)
F69
–
15 Amp Blue
SCR Module – If Equipped (HD Only)
F70
–
30 Amp Green
Fuel Pump Motor / K09 RLY Coil Feed (Cummins
Diesel) – If Equipped
F71
–
25 Amp Clear
Amplifier / Active Noise Cancelation – If Equipped
(HD Only)
F72
–
10 Amp Red
PCM / DC/DC Converter Voltage– If Equipped
(DS 1500 Only)
F73
–
20 Amp Yellow
Fuel Transfer Pump (Rear Tank) – If Equipped
(HD Only)
Cavity
Cartridge Fuse
Micro Fuse
Description
-------------------------------------------------------------------------------------------------------------------------------------------------------------
IN CASE OF EMERGENCY
387
F74
–
20 Amp Yellow
Brake Vacuum Pump Gas/Diesel – If Equipped (DS 1500
Only)
F74
–
10 Amp Red
Backup Alarm – If Equipped (HD Only)
F75
–
10 Amp Red
ATMM / Coil-SCR Module RLY– If Equipped
(HD Only)
Coolant Temperature Valve – If Equipped
(DS 1500 Only)
F76
–
10 Amp Red
Electronic Stability Control (HD Only)
Brake System Module / Stop Lamp Switch / Electric
Park Brake / Clutch Pedal Switch (DS 1500 Only)
F77
–
10 Amp Red
Drivetrain Control Module / Front Axle Disconnect
Module / TCM (HD Only)
Drivetrain Control Module / ELSD / Front Axle
Disconnect Module / Transmission Control Relay /
RDM / Power Take Off Unit – If Equipped (DS 1500
Only)
F78
–
10 Amp Red
Engine Control Module / Powertrain Control Module /
Electric Power Steering (DS 1500 Only)
F78
–
15 Amp Blue
Engine Control Module / Powertrain Control Module /
AEB RACM MOD / Feed To AUX PDC Relay Coils (HD
Only)
F79
–
15 Amp Blue
ID / Clearance Lights
Cavity
Cartridge Fuse
Micro Fuse
Description
6
-------------------------------------------------------------------------------------------------------------------------------------------------------------
388 IN CASE OF EMERGENCY
F80
–
10 Amp Red
Universal Garage Door Opener / Compass /
Anti-Intrusion Module (DS 1500 Only)
ASSY Overhead Console / SW Assist / SW 911 – If
Equipped (HD Only)
F81
–
20 Amp Yellow
Trailer Tow Right Turn / Stop Lights - If Equipped
F82
–
10 Amp Red
Steering Column Control Module / Cruise Control
F83
–
–
No Connection
F84
–
15 Amp Blue
ASBM / HVAC / ICS / Rear Heated Seat Switches
F85
–
10 Amp Red
Airbag Module
F86
–
10 Amp Red
Airbag Module
F87
–
10 Amp Red
Air Suspension / ITBM / Steering Column Control
Module / MOD Gateway CAN-C Trailer TPM (HD
Only)
Air Suspension / Trailer Tow / DC/DC Converter
(Voltage Stabilizer) / Steering Column Control Module
/ Occupant Classification Sensor (DS 1500 Only)
F88
–
15 Amp Blue
Instrument Panel Cluster
F90/F91
–
20 Amp Yellow
IGN or BATT Customer Selectable – If Equipped
(HD Only)
Power Outlet (Rear Seats) Customer Selectable (DS 1500
Only)
F93
–
20 Amp Yellow
Cigar Lighter - If Equipped
Cavity
Cartridge Fuse
Micro Fuse
Description
-------------------------------------------------------------------------------------------------------------------------------------------------------------
IN CASE OF EMERGENCY
389
F94
–
10 Amp Red
Shift-By-Wire / Transfer Case Switch (DS 1500 Only)
Shift-By-Wire / Transfer Case Switch / Module TPM
Trailer (HD Only) / Module Gateway Can-C Trailer
TPM (HD Only)
F95
–
10 Amp Red
Rearview Camera / Park Assist / CHMSL Camera /
Blind Spot Sensor / Surround View Camera (HD Only)
Rear Camera / Park Assist / Blind Spot Sensor /
Compass (DS 1500 Only)
F96
–
10 Amp Red
Rear Seat Heater Switch / Trunk Lamp With Flashlamp
Charger / Truck Lamp - If Equipped (DS 1500 Only)
Trailer Camera – If Equipped (HD Only)
F97
–
25 Amp Clear
Rear Heated Seats And Heated Steering Wheel – If
Equipped (DS 1500 Only)
F97
–
20 Amp Yellow
Front Heated Seat Passenger – If Equipped (HD Only)
F98
–
25 Amp Clear
Front Heated Seats – If Equipped (DS 1500 Only)
F98
–
20 Amp Yellow
Front Heated Seat Driver – If Equipped (HD Only)
F99
–
10 Amp Red
HVAC / DASM (DS 1500 Only)
HVAC / In-Car Temperature Sensor / CSG MOD /
Humidity Sensor (HD Only)
F100
–
10 Amp Red
Upfitters – If Equipped (HD Only)
F101
–
15 Amp Blue
SSV Only
F101
–
20 Amp Yellow
Rear Heated Seat Right (HD Only)
Cavity
Cartridge Fuse
Micro Fuse
Description
6
-------------------------------------------------------------------------------------------------------------------------------------------------------------
390 IN CASE OF EMERGENCY
(Continued)
JACKING AND TIRE CHANGING
F102
–
20 Amp Yellow
Rear Heated Seat Left / Run RLY #3 Coil (HD Only)
F103
–
10 Amp Red
HeadLamp AFLS (HD Only)
F104
–
20 Amp Yellow
Power Outlets (Instrument Panel / Center Console) /
Trunk – If Equipped (DS 1500 Only)
UCI Port / USB Rear (HD Only)
Cavity
Cartridge Fuse
Micro Fuse
Description
CAUTION!
• When installing the power distribution center cover, it
is important to ensure the cover is properly positioned
and fully latched. Failure to do so may allow water to
get into the power distribution center and possibly
result in an electrical system failure.
• When replacing a blown fuse, it is important to use
only a fuse having the correct amperage rating. The use
of a fuse with a rating other than indicated may result
in a dangerous electrical system overload. If a properly
rated fuse continues to blow, it indicates a problem in
the circuit that must be corrected.
WARNING!
• Do not attempt to change a tire on the side of the vehicle
close to moving traffic. Pull far enough off the road to
avoid the danger of being hit when operating the jack
or changing the wheel.
• Being under a jacked-up vehicle is dangerous. The
vehicle could slip off the jack and fall on you. You
could be crushed. Never put any part of your body
under a vehicle that is on a jack. If you need to get
under a raised vehicle, take it to a service center where
it can be raised on a lift.
• Never start or run the engine while the vehicle is on a
jack.
-------------------------------------------------------------------------------------------------------------------------------------------------------------
IN CASE OF EMERGENCY
391
4500/5500 Models
These vehicles do not come equipped with a jack.
NOTE:
Jacking and tire changing on 4500/5500 models should be
performed by an authorized dealer, or knowledgeable
service personnel with the appropriate heavy duty equip-
ment, like a tire service company.
Preparations For Jacking
1. Park the vehicle on a firm, level surface. Avoid ice or slip-
pery areas.
2. Place the gear selector into PARK. On four-wheel drive
vehicles, shift the transfer case to the 4L position.
3. Turn on the Hazard Warning flasher.
4. Apply the parking brake.
5. Turn the ignition OFF.
• The jack is designed to be used as a tool for changing
tires only. The jack should not be used to lift the
vehicle for service purposes. The vehicle should be
jacked on a firm level surface only. Avoid ice or slip-
pery areas.
WARNING! (Continued)
WARNING!
Do not attempt to change a tire on the side of the vehicle
close to moving traffic. Pull far enough off the road to
avoid being hit when operating the jack or changing the
wheel.
6
-------------------------------------------------------------------------------------------------------------------------------------------------------------
392 IN CASE OF EMERGENCY
(Continued)
6. Block both the front and rear of the wheel diagonally
opposite the jacking position. For example, if the right
front wheel is being changed, block the left rear wheel.
Wheel Blocked
NOTE:
Passengers should not remain in the vehicle when the
vehicle is being jacked.
Jacking Instructions 4500 And 5500 Series
WARNING!
Carefully follow these tire changing warnings to help
prevent personal injury or damage to your vehicle:
• Always park on a firm, level surface as far from the
edge of the roadway as possible before raising the
vehicle.
• Turn on the Hazard Warning flasher.
• Block the wheel diagonally opposite the wheel to be
raised.
• Apply the parking brake firmly and set the transmis-
sion in PARK.
• Never start or run the engine with the vehicle on a jack.
• Do not let anyone sit in the vehicle when it is on a jack.
• Do not get under the vehicle when it is on a jack. If you
need to get under a raised vehicle, take it to a service
center where it can be raised on a lift.
• Only use the jack in the positions indicated and for
lifting this vehicle during a tire change.
• If working on or near a roadway, be extremely careful
of motor traffic.
-------------------------------------------------------------------------------------------------------------------------------------------------------------
IN CASE OF EMERGENCY
393
Jack Warning Label
1. If equipped, remove the spare wheel, jack, and tools from
storage.
2. Using the lug wrench, loosen, but do not remove, the lug
nuts by turning them counterclockwise one turn while
the wheel is still on the ground.
• To assure that spare tires, flat or inflated, are securely
stowed, spares must be stowed with the valve stem
facing the ground.
WARNING! (Continued)
CAUTION!
Do not attempt to raise the vehicle by jacking on
locations other than those indicated in the Jacking
Instructions for this vehicle.
6
-------------------------------------------------------------------------------------------------------------------------------------------------------------
394 IN CASE OF EMERGENCY
3. When changing the front wheel, assemble the jack driver
to the jack and connect the jack driver to the extension
tube. Place the jack under the axle as close to the tire as
possible with the jack driver extending to the front.
Connect the extension tubes and lug wrench.
Front Jacking Locations
When changing a rear wheel, assemble the jack driver to
the jack and connect the jack driver to the extension tubes.
Securely place the jack under the sway bar bracket (unless
both tires are flat on one side, then place jack under shock
bracket) facing forward in vehicle. Connect the extension
tubes and lug wrench.
Rear Jacking Location
Before raising the wheel off the ground, make sure that
the jack will not damage surrounding truck parts and
adjust the jack position as required.
NOTE:
If the jack will not lower by turning the dial (thumbwheel) by
hand, it may be necessary to use the jack driver in order to
lower the jack.
4. By rotating the lug wrench clockwise, raise the vehicle
until the wheel just clears the surface.
-------------------------------------------------------------------------------------------------------------------------------------------------------------
IN CASE OF EMERGENCY
395
5. Remove the lug nuts and pull the wheel off. Install the
spare wheel and lug nuts with the cone shaped end of the
nuts toward the wheel on single rear wheel (SRW)
models. On dual rear wheel models (DRW) the lug nuts
are a two-piece assembly with a flat face. Lightly tighten
the nuts. To avoid risk of forcing the vehicle off the jack,
do not fully tighten the nuts until the vehicle has been
lowered.
6. Using the lug wrench, finish tightening the nuts using a
crisscross pattern. For the proper lug nut torque specifica-
tions refer to “Wheel And Tire Torque Specifications” in
“Technical Specifications.” If in doubt about the correct
tightness, have them checked with a torque wrench by an
authorized dealer or at a service station.
7. Install wheel center cap (if equipped) and remove wheel
blocks. Do not install chrome or aluminum wheel center
caps on the spare wheel. This may result in cap damage.
8. Lower the jack to its fully closed position. If the jack will
not lower by turning the dial (thumbwheel) by hand, it
may be necessary to use the jack driver in order to lower
the jack. Stow the replaced tire, jack, and tools as previ-
ously described.
9. Adjust the tire pressure when possible.
WARNING!
Raising the vehicle higher than necessary can make the
vehicle less stable. It could slip off the jack and hurt
someone near it. Raise the vehicle only enough to
remove the tire.
WARNING!
A loose tire or jack thrown forward in a collision or hard
stop, could endanger the occupants of the vehicle.
Always stow the jack parts and the spare tire in the
places provided.
6
-------------------------------------------------------------------------------------------------------------------------------------------------------------
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст