SsangYong Musso. Manual — part 122
1F-72 ENGINE CONTROLS
SSANGYONG Y158
1. The scan tool is malfunctioning.
2. Refer to the scan tool’s manual for repair.
Is the repair complete?
1. Using the scan tool, clear the Diagnostic Trouble
Codes (DTCs).
2. Attempt to start the engine.
Does the engine start and continue to run?
1. Allow the engine to idle until normal operation
temperature is reached.
2. Check if any DTCs are set.
Are any DTCs displayed that have not been diagnosed?
Step
Action
Value(s)
Yes
No
Data Link Connector Diagnosis (Cont'd)
-
Go to Step 18
Go to Step 2
-
Go to
applicable
DTC table
System OK
16
17
18
-
Go to Step 17
-
ENGINE CONTROLS 1F-73
SSANGYONG Y158
BLANK
1F-74 ENGINE CONTROLS
SSANGYONG Y158
TROUBLE CODE DIAGNOSIS
CLEARING TROUBLE CODES
Notice: To prevent Engine Control Module (ECM) dam-
age, the key must be OFF when disconnecting or recon-
necting the power to the ECM (for example battery cable,
ECM pigtail connector, ECM fuse, jumper cables, etc.)
When the ECM sets a diagnostic trouble code (DTC),
the Malfunction Indicator Lamp (MIL) will be turned ON
and a DTC will be stored in the ECM’s memory. If the
problem is intermittent, the light will go out after 10 sec-
onds if the fault is no longer present. The DTC will stay
in the ECM’s memory until the battery voltage for 10
seconds will clear all stored DTCs.
DTCs should be cleared after repairs have been com-
pleted. Some diagnostic tables will tell you to clear the
codes before using the chart. This allows the ECM to
set the DTC while going through the chart, which will
help to find the cause of the problem more quickly.
DIAGNOSTIC TROUBLE CODES
DTC
P0010
P0101
P0102
P0103
P0105
P0107
P0108
P0111
P0112
P0113
P0116
P0117
P0118
P0120
P0121
P0125
P0131
P0132
P0133
P0134-82
P0134-83
P0135-86
P0135-87
P0137
P0138
P0140
P0141-94
P0141-95
P0151
P0152
2.3L
DOHC
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
3.2L
DOHC
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
Type
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
Illuminate
MIL
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Description
Camshaft actuator short circuit to ground/battery/open
Mass air flow plausibility
Mass air flow low voltage
Mass air flow high voltage
Manifold absolute pressure plausibility
Manifold absolute pressure low voltage
Manifold absolute pressure high voltage
Intake air temperature plausibility
Intake air temperature low voltage
Intake air temperature high voltage
Engine coolant temperature plausibility
Engine coolant temperature low voltage
Engine coolant temperature high voltage
Throttle position sensor error
Throttle adaptation or throttle spring check
Engine coolant temperature warm-up
O2 bank 1 sensor 1 low voltage
O2 bank 1 sensor 1 high voltage
O2 bank 1 sensor 1 slow response
O2 bank 1 sensor 1 no activity detected
O2 bank 1 sensor 1 not lean after coasting shut down
O2 bank 1 sensor 1 heater short circuit to battery
O2 bank 1 sensor 1 heater short circuit to ground or open
O2 bank 1 sensor 2 low voltage
O2 bank 1 sensor 2 high voltage
O2 bank 1 sensor 2 not lean after coasting shut down
O2 bank 1 sensor 2 heater short circuit to battery
O2 bank 1 sensor 2 heater short circuit to ground or open
O2 bank 2 sensor 3 low voltage
O2 bank 2 sensor 3 high voltage
ENGINE CONTROLS 1F-75
SSANGYONG Y158
Diagnostic Trouble Codes (Cont'd)
DTC
P0153
P0154-202
P0154-203
P0155-206
P0155-207
P0157
P0158
P0160
P0161-214
P0161-215
P0171
P0172
P0174
P0175
P0220
P0231
P0232
P0261
P0262
P0264
P0265
P0267
P0268
P0270
P0271
P0273
P0274
P0276
P0277
P0300
P0301
P0302
P0303
P0304
P0305
P0306
P0325
P0330
P0335
P0336
P0341
2.3L
DOHC
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
3.2L
DOHC
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
Type
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
Illuminate
MIL
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Description
O2 bank 2 sensor 3 slow response
O2 bank 2 sensor 3 no activity detected
O2 bank 2 sensor 3 not lean after coasting shut down
O2 bank 2 sensor 3 heater short circuit to battery
O2 bank 2 sensor 3 heater short circuit to ground or open
O2 bank 2 sensor 4 low voltage
O2 bank 2 sensor 4 high voltage
O2 bank 2 sensor 4 not lean after coasting shut down
O2 bank 2 sensor 4 heater short circuit to battery
O2 bank 2 sensor 4 heater short circuit to ground or open
Bank 1 system too lean
Bank 1 system too rich
Bank 2 system too lean
Bank 2 system too rich
Accelerator pedal position sensor malfunction
Fuel pump short circuit to ground or open
Fuel pump short circuit to battery
Injector 1: short circuit to ground or open
Injector 1: short circuit to battery
Injector 2: short circuit to ground or open
Injector 2: short circuit to battery
Injector 3: short circuit to ground or open
Injector 3: short circuit to battery
Injector 4: short circuit to ground or open
Injector 4: short circuit to battery
Injector 5: short circuit to ground or open
Injector 5: short circuit to battery
Injector 6: short circuit to ground or open
Injector 6: short circuit to battery
Multiple cylinder misfire
Cylinder 1 misfire
Cylinder 2 misfire
Cylinder 3 misfire
Cylinder 4 misfire
Cylinder 5 misfire
Cylinder 6 misfire
Knock sensor 1: noise level check
Knock sensor 2: noise level check
Crankshaft position sensor malfunction
Crankshaft position sensor signal range
Camshaft position sensor signal: cylinder 1 missing
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст