Isuzu engine C22NE / 22LE / 20LE. Manual — part 44
DRIVEABILITY AND EMISSIONS 6E1-5
PAGE
Legend . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6E1- 76
Results of Incorrect Operation . . . . . . . . . . . . . . . . . . . .. 6E1- 76
Diagnosis. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6E1- 77
Legend . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6E1- 77
Visual Check of Canister. . . . . . . . . . . . . . . . . . . . . . 6E1- 77
Evaporative Emission Canister Purge Control Solenoid Valve Check
(If applicable) . . . . . . . . . . . . . . . . . . . . . . . . . . . ... 6E1- 78
Circuit Description. . . . . . . . . . . . . . . . . . . . . . . . .. 6E1- 78
Test Description. . . . . . . . . . . . . . . . . . . . . . . . . .. 6E1- 78
Diagnostic Aids. . . . . . . . . . . . . . . . . . . . . . . . . ... 6E1- 78
General Description . . . . . . . . . . . . . . . . . . . . . . . . . 6E1- 79
Legend . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6E1- 79
ECM Diagnostic Trouble Codes . . . . . . . . . . . . . . . . . . . . . 6E1- 80
SYMPTOM DIAGNOSIS . . . . . . . . . . . . . . . . . . . . . . . ... 6E1- 81
PRELIMINARY CHECKS. . . . . . . . . . . . . . . . . . . . . . . .. 6E1- 81
VISUAL/PHYSICAL CHECK. . . . . . . . . . . . . . . . . . . . . . . 6E1- 81
INTERMITTENT . . . . . . . . . . . . . . . . . . . . . . . . . . . 6E1- 81
Hard Start Symptom . . . . . . . . . . . . . . . . . . . . . . . ... 6E1- 82
Surges and/or Chuggles symptom. . . . . . . . . . . . . . . . . . 6E1- 84
Lack of Power, Sluggish or Spongy Symptom . . . . . . . . . . . . . 6E1- 86
Detonation/Spark Knock Symptom . . . . . . . . . . . . . . . . . ... 6E1- 88
Rough, Unstable, or Incorrect Idle, Stalling Symptom
(For Open Loop System) . . . . . . . . . . . . . . . . . . . . . . 6E1- 90
Rough, Unstable, or incorrect Idle, Stalling Sympton
(For Closed Loop System) . . . . . . . . . . . . . . . . . . . . . . 6E1- 92
Idle CO Concentration Check and adjustment. . . . . . . . . . . . . . 6E1- 94
Poor Fuel Economy Symptom . . . . . . . . . . . . . . . . . . . ... 6E1- 95
Dieseling, Run-On Symptom. . . . . . . . . . . . . . . . . . . . .. 6E1- 97
Backfire Symptom . . . . . . . . . . . . . . . . . . . . . . . . .. 6E1- 98
Cuts, Out, Misses Symptom . . . . . . . . . . . . . . . . . . . . .. 6E1-100
Hesitation, Sag, Stumble Symptom. . . . . . . . . . . . . . . . . ... 6E1-103
DEFAULT MATRIX TABLE . . . . . . . . . . . . . . . . . . . . . . .. 6E1-105
SERVICE PROCEDURE DEFAULT STRATEGY . . . . . . . . . . . . . . . 6E1-105
Default Matrix Table. . . . . . . . . . . . . . . . . . . . . . . . 6E1-105
6E1-6 DRIVEABILITY AND EMISSIONS
PAGE
ENGINE CRANKS BUT WILL NOT RUN . . . . . . . . . . . . . . . . . . 6E1-108
Circuit Description. . . . . . . . . . . . . . . . . . . . . . . . .. 6E1-108
Diagnostic Aids. . . . . . . . . . . . . . . . . . . . . . . . . ... 6E1-108
Engine Cranks But Will Not Run . . . . . . . . . . . . . . . . . . ... 6E1-108
FUEL SYSTEM ELECTRICAL TEST. . . . . . . . . . . . . . . . . . . 6E1-113
Circuit Description. . . . . . . . . . . . . . . . . . . . . . . . .. 6E1-113
Diagnostic Aids. . . . . . . . . . . . . . . . . . . . . . . . . ... 6E1-113
Test Description. . . . . . . . . . . . . . . . . . . . . . . . . .. 6E1-114
Fuel Pressure Relief Procedure. . . . . . . . . . . . . . . . . . . . 6E1-114
Fuel Pressure Gauge Installation . . . . . . . . . . . . . . . . . . .. 6E1-114
Fuel System Electrical Test . . . . . . . . . . . . . . . . . . . . ... 6E1-114
FUEL SYSTEM DIAGNOSIS . . . . . . . . . . . . . . . . . . . . . . 6E1-117
Circuit Description. . . . . . . . . . . . . . . . . . . . . . . . .. 6E1-117
Test Description. . . . . . . . . . . . . . . . . . . . . . . . . .. 6E1-117
Fuel Pressure Relief Procedure. . . . . . . . . . . . . . . . . . . . 6E1-119
Fuel Pressure Gauge Installation . . . . . . . . . . . . . . . . . . .. 6E1-119
Fuel System Diagnosis. . . . . . . . . . . . . . . . . . . . . . ... 6E1-119
MANIFOLD ABSOLUTE PRESSURE (MAP) OUTPUT CHECK . . . . . . . . .. 6E1-123
Circuit Description. . . . . . . . . . . . . . . . . . . . . . . . .. 6E1-123
Test Description. . . . . . . . . . . . . . . . . . . . . . . . . .. 6E1-123
Manifold Absolute Pressure (MAP) Output Check . . . . . . . . . . . ... 6E1-124
EVAPORATIVE EMISSIONS (EVAP)
CANISTER PURGE CONTROL SOLENOID VALVE CHECK. . . . . . . . . .. 6E1-125
Circuit Description. . . . . . . . . . . . . . . . . . . . . . . . .. 6E1-125
Diagnostic Aids. . . . . . . . . . . . . . . . . . . . . . . . . ... 6E1-125
Test Description. . . . . . . . . . . . . . . . . . . . . . . . . .. 6E1-125
Evaporative Emissions (EVAP)
Canister Purge Valve Solenoid Check . . . . . . . . . . . . . . . . .. 6E1-126
THROTTLE POSITION (TP) SENSOR CIRCUIT RANGE/PERFORMANCE
PROBLEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6E1-129
Circuit Description. . . . . . . . . . . . . . . . . . . . . . . . .. 6E1-129
Diagnostic Aids. . . . . . . . . . . . . . . . . . . . . . . . . ... 6E1-129
TP Sensor Circuit Range/Performance Problem. . . . . . . . . . . . .. 6E1-130
DRIVEABILITY AND EMISSIONS 6E1-7
PAGE
DIAGNOSTIC TROUBLE CODE (DTC) (Flash DTC=22)
THROTTLE POSITION (TP) SENSOR CIRCUIT LOW INPUT. . . . . . . . . . 6E1-133
Circuit Description. . . . . . . . . . . . . . . . . . . . . . . . .. 6E1-133
Conditions for setting the DTC . . . . . . . . . . . . . . . . . . . .. 6E1-133
Action Taken when the DTC Sets . . . . . . . . . . . . . . . . . . .. 6E1-133
Conditions for Clearing the MIL/DTC . . . . . . . . . . . . . . . . . 6E1-133
Diagnostic Aids. . . . . . . . . . . . . . . . . . . . . . . . . ... 6E1-134
DTC (Flash DTC=22) Throttle Position (TP) Sensor Circuit Low Input . . . . ... 6E1-134
DIAGNOSTIC TROUBLE CODE (DTC) (Flash DTC=21)
THROTTLE POSITION (TP) SENSOR CIRCUIT HIGH INPUT . . . . . . . . . 6E1-137
Circuit Description. . . . . . . . . . . . . . . . . . . . . . . . .. 6E1-137
Conditions for Setting the DTC. . . . . . . . . . . . . . . . . . . .. 6E1-137
Action Taken When the DTC sets. . . . . . . . . . . . . . . . . . .. 6E1-137
Diagnostic Aids. . . . . . . . . . . . . . . . . . . . . . . . . ... 6E1-137
Test Description. . . . . . . . . . . . . . . . . . . . . . . . . .. 6E1-138
DTC (Flash DTC=21) Throttle Position (TP) Sensor Circuit High Input . . . . .. 6E1-138
DIAGNOSTIC TROUBLE CODE (DTC) (Flash DTC=13)
02 SENSOR CIRCUIT NOT READY DETECTED (IF APPLICABLE) . . . . . . .. 6E1-141
Circuit Description. . . . . . . . . . . . . . . . . . . . . . . . .. 6E1-141
Conditions for Setting the DTC. . . . . . . . . . . . . . . . . . . .. 6E1-141
Action Taken When the DTC Sets . . . . . . . . . . . . . . . . . . . 6E1-141
Conditions for Clearing the MIL/DTC . . . . . . . . . . . . . . . . . 6E1-141
Diagnostic Aids. . . . . . . . . . . . . . . . . . . . . . . . . ... 6E1-142
DTC (Flash DTC=13) 02 Sensor Circuit Not Ready . . . . . . . . . . . . ... 6E1-142
DIAGNOSTIC TROUBLE CODE (DTC) (Flash DTC=44)
02 SENSOR TOO LEAN (IF APPLICABLE). . . . . . . . . . . . . . . . . 6E1-145
Circuit Description. . . . . . . . . . . . . . . . . . . . . . . . .. 6E1-145
Conditions for Setting the DTC. . . . . . . . . . . . . . . . . . . .. 6E1-145
Action Taken When the DTC Sets . . . . . . . . . . . . . . . . . . . 6E1-145
Conditions for Clearing the MIL/DTC . . . . . . . . . . . . . . . . . 6E1-145
Diagnostic Aids. . . . . . . . . . . . . . . . . . . . . . . . . ... 6E1-146
DTC (Flash DTC=44) 02 Sensor Too Lean . . . . . . . . . . . . . . . . . 6E1-146
DIAGNOSTIC TROUBLE CODE (DTC) (Flash DTC=45)
02 SENSOR TOO RICH (IF APPLICABLE). . . . . . . . . . . . . . . . .. 6E1-149
6E1-8 DRIVEABILITY AND EMISSIONS
PAGE
Circuit Description. . . . . . . . . . . . . . . . . . . . . . . . .. 6E1-149
Conditions for setting the DTC . . . . . . . . . . . . . . . . . . . .. 6E1-149
Action Taken When the DTC Sets . . . . . . . . . . . . . . . . . . . 6E1-149
Conditions for Clearing the MIL/DTC . . . . . . . . . . . . . . . . . 6E1-149
Diagnostic Aids. . . . . . . . . . . . . . . . . . . . . . . . . ... 6E1-150
DTC (Flash DTC=45) 02 Sensor Too Rich . . . . . . . . . . . . . . . . . 6E1-150
DIAGNOSTIC TROUBLE CODE (DTC) (Flash DTC=14)
EINGINE COOLANT TEMPERATURE(ECT) SENSOR CIRCUIT HIGH INPUT . . .. 6E1-153
Circuit Description. . . . . . . . . . . . . . . . . . . . . . . . .. 6E1-153
Conditions for Setting the DTC. . . . . . . . . . . . . . . . . . . .. 6E1-153
Action Taken When the DTC Sets . . . . . . . . . . . . . . . . . . . 6E1-153
Conditions for Clearing the MIL/DTC . . . . . . . . . . . . . . . . . 6E1-153
Diagnostic Aids. . . . . . . . . . . . . . . . . . . . . . . . . ... 6E1-154
Test Description. . . . . . . . . . . . . . . . . . . . . . . . . .. 6E1-154
Engine Coolant Temperature Sensor. . . . . . . . . . . . . . . . . 6E1-154
DTC (Flash DTC=14) ECT Sensor Circuit High Input. . . . . . . . . . . . 6E1-154
DIAGNOSTIC TROUBLE CODE (DTC) (Flash DTC=15)
ENGINE COOLANT TEMPERATURE (ECT) SENSOR CIRCUIT LOW INPUT . . ... 6E1-157
Circuit Description. . . . . . . . . . . . . . . . . . . . . . . . .. 6E1-157
Conditions for Setting the DTC. . . . . . . . . . . . . . . . . . . .. 6E1-157
Action Taken When the DTC Sets . . . . . . . . . . . . . . . . . . . 6E1-157
Conditions for Clearing the MIL/DTC . . . . . . . . . . . . . . . . . 6E1-157
Diagnostic Aids. . . . . . . . . . . . . . . . . . . . . . . . . ... 6E1-158
Test Description. . . . . . . . . . . . . . . . . . . . . . . . . .. 6E1-158
Engine Coolant Temperature Sensor. . . . . . . . . . . . . . . . . 6E1-158
DTC (Flash DTC=15) Engine Coolant Temperature (ECT)
Sensor Circuit Low Input . . . . . . . . . . . . . . . . . . . . . . . 6E1-158
DIAGNOSITC TROUBLE CODE (DTC) (Flash DTC=16)
KNOCK SENSOR (KS) DISCONNECTED MALFUNCTION . . . . . . . . . . 6E1-161
Circuit Description. . . . . . . . . . . . . . . . . . . . . . . . .. 6E1-161
Conditions for Setting the DTC. . . . . . . . . . . . . . . . . . . .. 6E1-161
Action Taken When the DTC Sets . . . . . . . . . . . . . . . . . . . 6E1-161
Conditions for Clearing the MIL/DTC . . . . . . . . . . . . . . . . . 6E1-161
Diagnostic Aids. . . . . . . . . . . . . . . . . . . . . . . . . ... 6E1-161
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст