Isuzu N-Series. Manual — part 1039
CAB AND CHASSIS ELECTRICAL 8-261
Intermittent Relay
Circuit Diagram
Removal
Preparation:
Disconnect the battery ground cable.
1. Glove Box
Open the lid and remove the four screws.
2. Intermittent Relay
1) Press A position with your finger and pry up B
position with the tip of a screw-driver.
2) When the relay moves up by about 2/3 of its
size, tilt and take off the relay to avoid interfer-
ence with the instrument panel.
3) Disconnect the connector.
N8A0267E
8-262 CAB AND CHASSIS ELECTRICAL
Installation
To install, follow the removal steps in the reverse order.
Windshield Wiper Arm & Blade
Removal
1. Cover
2. Wiper Arm Nut
3. Wiper Arm & Blade
Installation
To install, follow the removal steps in the reverse order,
noting the following points.
1. Before installing the wiper arm & blade to the shaft,
confirm that the motor stops at the auto-stop posi-
tion.
2. Set the wiper arm & blade so that the tips of both
blades are positioned as shown in the illustration.
3. Tighten the wiper arm nut to the specified torque.
Tighten:
Wiper arm nut to 17 N
⋅m (170 kg⋅cm/147 lb⋅in)
Instrumental panel
Instrument
panel rein-
forcement
1
2
2
A
S
B
View S
N8A0268E
3
2
1
N8A0269E
Approx. 45mm(STD Cab)
Approx. 70mm(Wide Cab)
N8A0270E
CAB AND CHASSIS ELECTRICAL 8-263
Windshield Wiper Linkage
Location of Rod and Pivot
Removal
Preparation:
Disconnect the battery ground cable.
1. Wiper Arm & Blade
Remove the cover, nut and wiper arm & blade.
2. Pivot Nut
Remove the rubber seal, nut and retaining rubber.
Pivot (Wiper: LH)
Rod
Rod
Pivot (Wiper: RH)
Wiper motor
N8A0271E
1
Nut
Cover
N8A0272E
Rubber seal
2
Retaining rubber
N8A0273E
8-264 CAB AND CHASSIS ELECTRICAL
3. Instrument Panel Assembly
Refer to “INSTRUMENT PANEL” of section 2.
4. Wiper Motor
1) Remove the four screws.
2) Disconnect the ball joint between the crank arm
and the wiper link.
5. Instrument Panel Reinforcement
Refer to “INSTRUMENT PANEL” of section 2.
6. Wiper Link Assembly
Remove two retaining nuts from left hand side of
pivot.
3
N8A0274E
N8A0275E
N8A0276E
6
Pivot (Wiper: LH)
N8A0277E
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст