Isuzu Amigo / Axiom / Trooper / Rodeo / VehiCross. Manual — part 745
6E–4
TROOPER 6VE1 3.5L ENGINE DRIVEABILITY AND EMISSIONS
DTC P1133 HO2S Insufficient Switching
Bank 1 Sensor 1
6E–390
. . . . . . . . . . . . . . . . . . . . . . . .
DTC P1134 HO2S Transition Time Ratio
Bank 1 Sensor 1
6E–394
. . . . . . . . . . . . . . . . . . . . . . . .
DTC P1153 HO2S Insufficient Switching
Bank 2 Sensor 1
6E–398
. . . . . . . . . . . . . . . . . . . . . . . .
DTC P1154 HO2S Circuit Transition Time
Ratio Bank 2 Sensor 1
6E–402
. . . . . . . . . . . . . . . . . .
DTC P1167 Fuel System Rich During Decel
Fuel Cut Off (Bank 1)
6E–406
. . . . . . . . . . . . . . . . . . . .
DTC P1169 Fuel System Rich During Decel
Fuel Cut Off (Bank 2)
6E–408
. . . . . . . . . . . . . . . . . . . .
DTC P1171 Fuel System Lean During
Acceleration
6E–410
. . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1220 Throttle Position Senser2 (TPS2)
Circuit Fault
6E–413
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1221 TPS1 – TPS2 correlation
(Circuit Performance)
6E–416
. . . . . . . . . . . . . . . . . . .
DTC P1271 APS 1– 2 Correlation Error
6E–419
. . . .
DTC P1272 APS 2 – 3 Correlation Error
6E–422
. . . .
DTC P1273 APS 1 – 3 Correlation Error
6E–425
. . . .
DTC P1275 APS 1 Circuit Fault
6E–428
. . . . . . . . . . .
DTC P1280 APS 2 Circuit Fault
6E–430
. . . . . . . . . . .
DTC P1285 APS 3 Circuit Fault
6E–432
. . . . . . . . . . .
DTC P1290 ETC Forced Idle Mode
6E–434
. . . . . . . .
DTC P1295 Power Management Mode
6E–436
. . . .
DTC P1299 ETC Forced Engine Shutdown
Mode
6E–438
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1310 ION Sensing Module Diagnosis
6E–440
DTC P1311 ION Sensing Module SEC
Line 1 Circuit Fault
6E–443
. . . . . . . . . . . . . . . . . . . . . .
DTC P1312 ION Sensing Module SEC
Line 2 Circuit Fault
6E–446
. . . . . . . . . . . . . . . . . . . . . .
DTC P1326 ION Sensing Module Combustion
Quality Input Circuit Fault
6E–449
. . . . . . . . . . . . . . . .
DTC P1340 ION Sensing Module Cylinder ID
Fault (Cylinder Synchronization Fail)
6E–452
. . . . . .
DTC P1404 EGR Stuck Closed
6E–455
. . . . . . . . . . .
DTC P1441 EVAP System Flow During
Non-Purge
6E–458
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1514 TPS - MAF Correlation Error
6E–461
. . .
DTC P1515 Command - Actual TPS
Correlation Error
6E–465
. . . . . . . . . . . . . . . . . . . . . . . .
DTC P1516 Command - Actual TPS
Correlation Error
6E–468
. . . . . . . . . . . . . . . . . . . . . . . .
DTC P1523 Actuator Control Return
Performance
6E–471
. . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1574 Brake Switch No Operation
6E–474
. . . .
DTC P1635 Reference Voltage # 1 Circuit
Fault
6E–476
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1636 PCM RAM Stack
6E–478
. . . . . . . . . . . . .
DTC P1639 Reference Voltage # 2 Circuit
Fault
6E–479
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1640 Driver-1-Output Circuit Fault
(ODM)
6E–481
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1650 Quad Driver Module “A” Fault
6E–483
. .
Symptom Diagnosis
6E–486
. . . . . . . . . . . . . . . . . . . . .
Default Matrix Table
6E–515
. . . . . . . . . . . . . . . . . . . . .
On Vehicle Service Crankshaft Position
(CKP) Sensor
6E–518
. . . . . . . . . . . . . . . . . . . . . . . . . .
Engine Coolant Temperature (ECT) Sensor
6E–518
.
Heated Oxygen Sensor (HO2S)
6E–519
. . . . . . . . . . .
Intake Air Temperature (IAT) Sensor
6E–522
. . . . . . .
ION Sensing Module
6E–522
. . . . . . . . . . . . . . . . . . . . .
Mass Air Flow (MAF) Sensor
6E–523
. . . . . . . . . . . . .
Manifold Absolute Pressure (MAP) Sensor
6E–524
.
Malfunction Indicator Lamp (MIL)
6E–525
. . . . . . . . . .
Reduced Power Lamp
6E–525
. . . . . . . . . . . . . . . . . . .
Powertrain Control Module (PCM)
6E–525
. . . . . . . . .
Service Precaution
6E–525
. . . . . . . . . . . . . . . . . . . .
Removal Procedure
6E–525
. . . . . . . . . . . . . . . . . . . .
Installation Procedure
6E–526
. . . . . . . . . . . . . . . . . .
EEPROM
6E–527
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Throttle Position (TP) Sensor
6E–527
. . . . . . . . . . . . .
Vehicle Speed Sensor (VSS)
6E–528
. . . . . . . . . . . . .
Air Cleaner/Air Filter
6E–529
. . . . . . . . . . . . . . . . . . . . .
Common Chamber
6E–529
. . . . . . . . . . . . . . . . . . . . . .
Accelerator Pedal Replacement
6E–530
. . . . . . . . . . .
Accelerator Position Sensor Replacement
6E–531
. .
Accelerator Position Sensor Adjustment
6E–531
. . . .
Fuel Filler Cap
6E–532
. . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel Filter
6E–532
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel Gauge Unit
6E–534
. . . . . . . . . . . . . . . . . . . . . . . .
Fuel Injectors
6E–534
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel Metering System
6E–535
. . . . . . . . . . . . . . . . . . . .
Fuel Pump Assembly
6E–536
. . . . . . . . . . . . . . . . . . . .
Fuel Pump Relay
6E–536
. . . . . . . . . . . . . . . . . . . . . . . .
Fuel Rail Assembly
6E–537
. . . . . . . . . . . . . . . . . . . . . .
Fuel Tank
6E–538
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Throttle Body (TB)
6E–538
. . . . . . . . . . . . . . . . . . . . . . .
Electronic Ignition System
6E–540
. . . . . . . . . . . . . . . .
Catalytic Converter
6E–541
. . . . . . . . . . . . . . . . . . . . . .
Air Conditioning Thermo Relay
6E–541
. . . . . . . . . . .
EVAP Canister Hoses
6E–541
. . . . . . . . . . . . . . . . . . . .
EVAP Canister
6E–542
. . . . . . . . . . . . . . . . . . . . . . . . . .
EVAP Canister Vent Solenoid
6E–543
. . . . . . . . . . . . .
Fuel Tank Pressure (Vapor Pressure) Sensor
6E–544
EVAP Canister Purge Solenoid (Purge Duty
Solenoid Valve)
6E–545
. . . . . . . . . . . . . . . . . . . . . . . . .
Fuel Tank Vent Valve (Vent Solenoid Valve)
6E–545
.
Linear Exhaust Gas Recirculation (EGR)
Valve
6E–545
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Positive Crankcase Ventilation (PCV) Valve
6E–546
.
PCV Valve
6E–547
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Wiring and Connectors
6E–547
. . . . . . . . . . . . . . . . . . .
PCM Connectors and Terminals
6E–548
. . . . . . . . . . .
Wire Harness Repair: Twisted Shielded
Cable
6E–548
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Twisted Leads
6E–549
. . . . . . . . . . . . . . . . . . . . . . . . . .
Weather-Pack Connector
6E–550
. . . . . . . . . . . . . . . . .
6E–5
TROOPER 6VE1 3.5L ENGINE DRIVEABILITY AND EMISSIONS
Com-Pack III
6E–551
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Metri-Pack
6E–552
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
General Description (PCM and Sensors)
6E–553
. . .
58X Reference PCM Input
6E–553
. . . . . . . . . . . . . .
A/C Request Signal
6E–553
. . . . . . . . . . . . . . . . . . . .
Crankshaft Position (CKP) Sensor
6E–553
. . . . . . .
Engine Coolant Temperature (ECT) Sensor
6E–553
Electrically Erasable Programmable Read
Only Memory (EEPROM)
6E–553
. . . . . . . . . . . . . .
Fuel Control Heated Oxygen Sensors
6E–553
. . . .
Catalyst Monitor Heated Oxygen Sensors
6E–554
Intake Air Temperature (IAT) Sensor
6E–554
. . . . .
Linear Exhaust Gas Recirculation (EGR)
Control
6E–555
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Mass Air Flow (MAF) Sensor
6E–555
. . . . . . . . . . . .
Manifold Absolute Pressure (MAP) Sensor
6E–555
Powertrain Control Module (PCM)
6E–556
. . . . . . .
PCM Function
6E–556
. . . . . . . . . . . . . . . . . . . . . . . . .
PCM Components
6E–556
. . . . . . . . . . . . . . . . . . . . .
PCM Voltage Description
6E–556
. . . . . . . . . . . . . . .
PCM Input/Outputs
6E–556
. . . . . . . . . . . . . . . . . . . .
PCM Service Precautions
6E–557
. . . . . . . . . . . . . .
Reprogramming The PCM
6E–557
. . . . . . . . . . . . . .
Throttle Position (TP) Sensor
6E–557
. . . . . . . . . . .
Transmission Fluid Temperature (TFT)
Sensor
6E–557
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Transmission Range Switch (Mode Switch)
6E–557
Vehicle Speed Sensor (VSS)
6E–557
. . . . . . . . . . . .
Use of Circuit Testing Tools
6E–557
. . . . . . . . . . . . .
Aftermarket Electrical and Vacuum
Equipment
6E–558
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Electrostatic Discharge Damage
6E–558
. . . . . . . . .
General Description (Air Induction)
6E–558
. . . . . . . .
Air Induction System
6E–558
. . . . . . . . . . . . . . . . . . .
General Description (Fuel Metering)
6E–559
. . . . . . .
Acceleration Mode
6E–559
. . . . . . . . . . . . . . . . . . . . .
Battery Voltage Correction Mode
6E–559
. . . . . . . .
Clear Flood Mode
6E–559
. . . . . . . . . . . . . . . . . . . . .
Deceleration Mode
6E–559
. . . . . . . . . . . . . . . . . . . .
Engine Speed/Vehicle Speed/Fuel Disable
Mode
6E–559
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel Cutoff Mode
6E–559
. . . . . . . . . . . . . . . . . . . . . .
Fuel Injector
6E–559
. . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel Metering System Components
6E–559
. . . . . .
Fuel Metering System Purpose
6E–559
. . . . . . . . . .
Fuel Pressure Regulator
6E–560
. . . . . . . . . . . . . . . .
Fuel Pump Electrical Circuit
6E–560
. . . . . . . . . . . . .
Fuel Rail
6E–560
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Run Mode
6E–560
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Starting Mode
6E–560
. . . . . . . . . . . . . . . . . . . . . . . . .
Throttle Body Unit
6E–561
. . . . . . . . . . . . . . . . . . . . .
General Description (Electronic Ignition
System)
6E–561
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Crankshaft Position (CKP) Sensor
6E–561
. . . . . . .
Electronic Ignition
6E–561
. . . . . . . . . . . . . . . . . . . . .
Ignition Coils
6E–561
. . . . . . . . . . . . . . . . . . . . . . . . . .
Ignition Control
6E–561
. . . . . . . . . . . . . . . . . . . . . . . .
Ignition Control PCM Output
6E–562
. . . . . . . . . . . .
Powertrain Control Module (PCM)
6E–562
. . . . . . .
Spark Plug
6E–563
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
A/C Clutch Diagnosis
6E–564
. . . . . . . . . . . . . . . . . . . .
A/C Clutch Circuit Operation
6E–564
. . . . . . . . . . . .
A/C Clutch Circuit Purpose
6E–564
. . . . . . . . . . . . .
A/C Request Signal
6E–564
. . . . . . . . . . . . . . . . . . . .
General Description (Evaporative (EVAP)
Emission System)
6E–565
. . . . . . . . . . . . . . . . . . . . . .
EVAP Emission Control System Purpose
6E–565
.
EVAP Emission Control System Operation
6E–565
Enhanced Evaporative Emission Control
System
6E–565
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
General Description (Exhaust Gas
Recirculation (EGR) System)
6E–568
. . . . . . . . . . . . .
EGR Purpose
6E–568
. . . . . . . . . . . . . . . . . . . . . . . . .
Linear EGR Valve
6E–569
. . . . . . . . . . . . . . . . . . . . .
Linear EGR Control
6E–569
. . . . . . . . . . . . . . . . . . . .
Linear EGR Valve Operation and Results of
Incorrect Operation
6E–569
. . . . . . . . . . . . . . . . . . . .
EGR Pintle Position Sensor
6E–569
. . . . . . . . . . . . .
General Description (Positive Crankcase
Ventilation (PCV) System)
6E–569
. . . . . . . . . . . . . . .
Crankcase Ventilation System Purpose
6E–569
. . .
Crankcase Ventilation System Operation
6E–569
.
Special Tools
6E–571
. . . . . . . . . . . . . . . . . . . . . . . . . . .
6E–6
TROOPER 6VE1 3.5L ENGINE DRIVEABILITY AND EMISSIONS
Specifications
Tightening Specifications
Application
N·m
Lb Ft.
Lb In.
EGR Bolt
25
18
—
Engine Coolant Temperature Sensor
30
22
—
Fuel Drain Plug
20
14
—
Fuel Pressure Regulator Attaching Screw
3
—
26
Fuel Rail Bolts
25
18
—
Fuel Tank Undercover Retaining Bolts
36
27
—
Heated Oxygen Sensor
55
40
—
Lower Intake Manifold to Engine Block Bolts
25
18
—
Lower Intake Manifold to Engine Block Nuts
25
18
—
Spark Plugs
18
13
—
Throttle Body Mounting Bolts
10
—
87
Common Chamber to Lower Intake Manifold Bolts
25
18
—
VSS Retaining Bolt
16
12
—
6E–7
TROOPER 6VE1 3.5L ENGINE DRIVEABILITY AND EMISSIONS
Diagrams and Schematics
PCM Wiring Diagram (1 of 8)
D06R200030
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст