Nissan Versa Note. Manual — part 169
WATER OUTLET
CO-25
< REMOVAL AND INSTALLATION >
[HR16DE]
C
D
E
F
G
H
I
J
K
L
M
A
CO
N
P
O
Removal and Installation
INFOID:0000000009444807
WARNING:
Do not remove the radiator cap when the engine is hot. Serious burns could occur from high-pressure
engine coolant escaping from the radiator. Wrap a thick cloth around the radiator cap. Slowly turn it a
quarter of a turn to release built-up pressure. Carefully remove radiator cap by turning it all the way.
NOTE:
When removing components such as hoses, tubes/lines, etc., cap or plug openings to prevent fluid from spill-
ing.
REMOVAL
1. Drain engine coolant. Refer to
CO-8, "Draining Engine Coolant"
.
CAUTION:
• Perform this step when engine is cold.
• Do not spill engine coolant on drive belt.
2. Remove air ducts and air cleaner assembly. Refer to
EM-26, "Removal and Installation"
.
3. Disconnect radiator hose (upper). Refer to
.
4. Disconnect harness connector from engine coolant temperature sensor.
5. Disconnect harness connector from cylinder block heater (Canada only).
6. Disconnect water hoses and heater hoses from water outlet.
7. Remove water outlet.
8. Remove engine coolant temperature sensor from water outlet, if necessary.
9. Remove cylinder block heater from water outlet, if necessary (Canada only).
INSTALLATION
Installation is in the reverse order of removal.
INSPECTION AFTER INSTALLATION
• Before starting engine, check oil/fluid levels, including engine coolant and engine oil. If less than required
quantity, fill to the specified level. Refer to
MA-11, "Fluids and Lubricants"
• Use procedure below to check for fuel leaks.
• Turn ignition switch ON (with engine stopped). With fuel pressure applied to fuel piping, check for fuel leaks
at connection points.
• Start engine. With engine speed increased, check again for fuel leaks at connection points.
• Run engine to check for unusual noise and vibration.
NOTE:
If hydraulic pressure inside timing chain tensioner drops after removal and installation, slack in the guide
may generate a pounding noise during and just after engine start. However, this is normal. Noise will stop
after hydraulic pressure rises.
• Warm up engine thoroughly to make sure there is no leaks of fuel, exhaust gas, or any oils/fluids, including
engine oil and engine coolant.
• Bleed air from passages in lines and hoses, such as in cooling system.
• After cooling down engine, again check oil/fluid levels, including engine oil and engine coolant. Refill to spec-
ified level, if necessary.
• Summary of the inspection items:
*Power steering fluid, brake fluid, etc.
Item
Before starting engine
Engine running
After engine stopped
Engine coolant
Level
Leaks
Level
Engine oil
Level
Leaks
Level
Transmission/
transaxle fluid
CVT Models
Leaks
Level/Leaks
Leaks
M/T Models
Level/Leaks
Leaks
Level/Leaks
Other oils and fluids*
Level
Leaks
Level
Fuel
Leaks
Leaks
Leaks
Exhaust gas
—
Leaks
—
CO-26
< SERVICE DATA AND SPECIFICATIONS (SDS)
[HR16DE]
SERVICE DATA AND SPECIFICATIONS (SDS)
SERVICE DATA AND SPECIFICATIONS (SDS)
SERVICE DATA AND SPECIFICATIONS (SDS)
Standard and Limit
INFOID:0000000009444808
Engine coolant capacity (approximate)
Unit: (US qt, Imp qt)
*: Includes reservoir amount.
Radiator
Unit: kPa (kg/cm
2
, psi)
Thermostat
Standard
Engine coolant capacity (With reservoir tank at “MAX” level)*
CVT models
7.3 (7-3/4, 6-3/8)
M/T models
6.7 (7-1/8, 5-7/8)
Reservoir tank engine coolant capacity (At “MAX” level)
0.7 (3/4, 5/8)
Cap relief pressure
Standard
88 (0.90, 12.8)
Radiator leak test pressure
156 (1.59, 22.6)
Valve opening temperature
80.5 - 83.5
°C (177 - 182°F)
Maximum valve lift
8.0 mm/95
°C (0.315 in/203°F)
Valve closing temperature
77
°C (171°F)
DEF-1
DRIVER CONTROLS
C
D
E
F
G
H
I
J
K
M
SECTION
DEF
A
B
DEF
N
O
P
CONTENTS
DEFOGGER
PRECAUTION . . . . . . . . . . . ...
PRECAUTIONS . . . . . . . . . . . . ...
SYSTEM DESCRIPTION . . . . . . . ..
COMPONENT PARTS . . . . . . . . . .
Component Parts Location . . . . . . . . . ....
Rear window defogger . . . . . . . . . . . ..
Door mirror defogger . . . . . . . . . . . .....
SYSTEM . . . . . . . . . . . . . . . ..
System Description . . . . . . . . . . . . ...
DIAGNOSIS SYSTEM (BCM) (WITH INTELLI-
GENT KEY SYSTEM) . . . . . . . . . . ..
COMMON ITEM . . . . . . . . . . . . . . ...
COMMON ITEM : CONSULT Function (BCM -
COMMON ITEM) . . . . . . . . . . . . . ...
REAR DEFOGGER . . . . . . . . . . . . .....
REAR DEFOGGER : CONSULT Function (BCM -
REAR DEFOGGER) . . . . . . . . . . . .....
DIAGNOSIS SYSTEM (BCM) (WITHOUT IN-
TELLIGENT KEY SYSTEM) . . . . . . . .
COMMON ITEM . . . . . . . . . . . . . . ...
COMMON ITEM : CONSULT Function (BCM -
COMMON ITEM) . . . . . . . . . . . . . ...
REAR DEFOGGER . . . . . . . . . . . . ...
REAR DEFOGGER : CONSULT Function (BCM -
REAR DEFOGGER) . . . . . . . . . . . ...
ECU DIAGNOSIS INFORMATION . . . ..
BCM . . . . . . . . . . . . . . . . .
List of ECU Reference . . . . . . . . . . .
WIRING DIAGRAM . . . . . . . . . ..
REAR WINDOW DEFOGGER SYSTEM . . ..
Wiring Diagram . . . . . . . . . . . . . .
BASIC INSPECTION . . . . . . . . ...
DIAGNOSIS AND REPAIR WORK FLOW . ...
Work Flow . . . . . . . . . . . . . . . .
DTC/CIRCUIT DIAGNOSIS . . . . . . .
REAR WINDOW DEFOGGER SWITCH . . ...
Description . . . . . . . . . . . . . . . ...
Component Function Check . . . . . . . . .
Diagnosis Procedure . . . . . . . . . . . ...
Component Inspection . . . . . . . . . . . .
REAR WINDOW DEFOGGER RELAY . . . .
Description . . . . . . . . . . . . . . . ...
Component Function Check . . . . . . . . .
Diagnosis Procedure . . . . . . . . . . . ...
Component Inspection . . . . . . . . . . . .
REAR WINDOW DEFOGGER POWER SUP-
PLY AND GROUND CIRCUIT . . . . . . ..
Description . . . . . . . . . . . . . . . ...
Component Function Check . . . . . . . . .
Diagnosis Procedure . . . . . . . . . . . ...
Component Inspection . . . . . . . . . . . .
DRIVER SIDE DOOR MIRROR DEFOGGER ...
Description . . . . . . . . . . . . . . . ...
Component Function Check . . . . . . . . .
Diagnosis Procedure . . . . . . . . . . . ...
Component Inspection . . . . . . . . . . . .
PASSENGER SIDE DOOR MIRROR DEFOG-
GER . . . . . . . . . . . . . . . . ...
Description . . . . . . . . . . . . . . . ...
Component Function Check . . . . . . . . .
DEF-2
Component Inspection . . . . . . . . . . ....
SYMPTOM DIAGNOSIS . . . . . . . .
REAR WINDOW DEFOGGER AND DOOR
MIRROR DEFOGGER DO NOT OPERATE. . .
Diagnosis Procedure . . . . . . . . . . . ..
REAR WINDOW DEFOGGER DOES NOT
OPERATE BUT BOTH OF DOOR MIRROR
DEFOGGER OPERATE. . . . . . . . . ...
Diagnosis Procedure . . . . . . . . . . . ..
Diagnosis Procedure . . . . . . . . . . . ..
DRIVER SIDE DOOR MIRROR DEFOGGER
DOES NOT OPERATE. . . . . . . . . . .
Diagnosis Procedure . . . . . . . . . . . ...
PASSENGER SIDE DOOR MIRROR DEFOG-
GER DOES NOT OPERATE. . . . . . . .
Diagnosis Procedure . . . . . . . . . . . ...
Diagnosis Procedure . . . . . . . . . . . ...
REMOVAL AND INSTALLATION . . . ..
FILAMENT . . . . . . . . . . . . . . .
Inspection and Repair . . . . . . . . . . . .
CONDENSER . . . . . . . . . . . . .
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст