Nissan Frontier D22. Manual — part 755
GI-52
TERMINOLOGY
***: Not applicable
Transmission control module
TCM
A/T control unit
Turbocharger
TC
Turbocharger
Vehicle speed sensor
VSS
Vehicle speed sensor
Volume air flow sensor
VAFS
Air flow meter
Warm up oxidation catalyst
WU-OC
Catalyst
Warm up oxidation catalytic converter sys-
tem
WU-OC system
***
Warm up three way catalyst
WU-TWC
Catalyst
Warm up three way catalytic converter sys-
tem
WU-TWC system
***
Wide open throttle position switch
WOTP switch
Full switch
NEW TERM
NEW ACRONYM /
ABBREVIATION
OLD TERM
GW-1
GLASSES, WINDOW SYSTEM & MIRRORS
I BODY
CONTENTS
C
D
E
F
G
H
J
K
L
M
SECTION
A
B
GW
PRECAUTIONS . . . . . . . . . . . . . . .. 2
PREPARATION . . . . . . . . . . . . . . ... 3
Special service tool . . . . . . . . . . . . .. 3
Commercial Service Tool . . . . . . . . . . . 3
SQUEAK AND RATTLE TROUBLE DIAGNOSIS . .. 4
Squeak and Rattle Trouble Diagnoses . . . . . . 4
WORK FLOW . . . . . . . . . . . . . . 4
GENERIC SQUEAK AND RATTLE TROUBLE-
SHOOTING . . . . . . . . . . . . . . ... 6
DIAGNOSTIC WORKSHEET . . . . . . . . 8
WINDSHIELD AND WINDOWS . . . . . . . . 10
Removal and Installation . . . . . . . . . . 10
REMOVAL . . . . . . . . . . . . . . ... 10
INSTALLATION . . . . . . . . . . . . ... 10
WINDSHIELD . . . . . . . . . . . . . ...11
SIDE WINDOW . . . . . . . . . . . . ... 12
BACK WINDOW . . . . . . . . . . . . .. 13
POWER WINDOW . . . . . . . . . . . . . 14
System Description . . . . . . . . . . . . 14
MANUAL OPERATION . . . . . . . . . ... 14
AUTO OPERATION . . . . . . . . . . . 16
POWER WINDOW LOCK . . . . . . . . ... 16
RETAINED ACCESSORY POWER (RAP)
OPERATION (WITH POWER DOOR LOCKS) ... 16
Circuit Diagram . . . . . . . . . . . . . .. 17
Wiring Diagram — WINDOW — . . . . . . . . 18
Trouble Diagnoses . . . . . . . . . . . . . 22
FRONT DOOR . . . . . . . . . . . . . . .. 24
Overhaul . . . . . . . . . . . . . . . . . 24
REAR DOOR . . . . . . . . . . . . . . . . 25
Overhaul . . . . . . . . . . . . . . . . . 25
DOOR MIRROR . . . . . . . . . . . . . . 26
Wiring Diagram — MIRROR — . . . . . . . .. 26
REAR WINDOW DEFOGGER . . . . . . . . .. 27
Component Parts and Harness Connector Location
System Description . . . . . . . . . . . . . 28
MODELS WITHOUT POWER DOOR LOCKS . 28
MODELS WITH POWER DOOR LOCKS . . . 28
Wiring Diagram — DEF — . . . . . . . . . . 30
WITHOUT POWER DOOR LOCKS . . . . . 30
WITH POWER DOOR LOCKS . . . . . . . 31
Trouble Diagnoses . . . . . . . . . . . . . 32
Electrical Components Inspection . . . . . . .. 37
REAR WINDOW DEFOGGER RELAY . . . . 37
REAR WINDOW DEFOGGER SWITCH . . . . 37
Filament Check . . . . . . . . . . . . . ... 38
Filament Repair . . . . . . . . . . . . . .. 39
REPAIR EQUIPMENT . . . . . . . . . . . 39
REPAIRING PROCEDURE . . . . . . . . . 39
REAR VIEW MIRROR . . . . . . . . . . . ... 40
Removal . . . . . . . . . . . . . . . . . 40
Installation . . . . . . . . . . . . . . . .. 40
GW-2
PRECAUTIONS
PRECAUTIONS
PFP:00001
Service Notice
EIS002CN
●
When removing or installing various parts, place a cloth or padding on the vehicle body to prevent
scratches.
●
Handle trim, molding, instruments, grille, etc. carefully during removing and installing. Be careful not to soil
or damage them.
●
Apply sealing compound where necessary when installing parts.
●
When applying sealing compound, be careful that the sealing compound does not protrude from parts.
●
When replacing any metal parts (for example body outer panel, members, etc.), be sure to take rust pre-
vention measures.
Precautions for Supplemental Restraint System (SRS) “AIR BAG” and “SEAT
BELT PRE-TENSIONER”
EIS002CO
The Supplemental Restraint System such as “AIR BAG” and “SEAT BELT PRE-TENSIONER”, used along
with a front seat belt, helps to reduce the risk or severity of injury to the driver and front passenger for certain
types of collision. This system may include seat belt switch inputs and dual stage front air bag modules. If
equipped with dual stage front air bag modules, the SRS system uses the seat belt switches to determine the
front air bag deployment, and may only deploy one front air bag, depending on the severity of a collision and
whether the front occupants are belted or unbelted. Information necessary to service the system safely is
included in the SRS and SB section of this Service Manual.
The vehicle may be equipped with a passenger air bag deactivation switch. Because no rear seat exists where
a rear-facing child restraint can be placed, the switch is designed to turn off the passenger air bag so that a
rear-facing child restraint can be used in the front passenger seat. The switch is located in the center of the
instrument panel, near the ashtray. When the switch is turned to the ON position, the passenger air bag is
enabled and could inflate for certain types of collision. When the switch is turned to the OFF position, the pas-
senger air bag is disabled and will not inflate. A passenger air bag OFF indicator on the instrument panel lights
up when the passenger air bag is switched OFF. The driver air bag always remains enabled and is not affected
by the passenger air bag deactivation switch.
WARNING:
●
To avoid rendering the SRS inoperative, which could increase the risk of personal injury or death
in the event of a collision which would result in air bag inflation, all maintenance must be per-
formed by an authorized NISSAN/INFINITI dealer.
●
Improper maintenance, including incorrect removal and installation of the SRS, can lead to per-
sonal injury caused by unintentional activation of the system. For removal of Spiral Cable and Air
Bag Module, see the SRS section.
●
Do not use electrical test equipment on any circuit related to the SRS unless instructed to in this
Service Manual. SRS wiring harnesses can be identified by yellow and/or orange harnesses or
harness connectors.
●
The vehicle may be equipped with a passenger air bag deactivation switch which can be operated
by the customer. When the passenger air bag is switched OFF, the passenger air bag is disabled
and will not inflate. When the passenger air bag is switched ON, the passenger air bag is enabled
and could inflate for certain types of collision. After SRS maintenance or repair, make sure the
passenger air bag deactivation switch is in the same position (ON or OFF) as when the vehicle
arrived for service.
PREPARATION
GW-3
C
D
E
F
G
H
J
K
L
M
A
B
GW
PREPARATION
PFP:00002
Special service tool
EIS002CP
The actual shapes of Kent-Moore tools may differ from those of special service tools illustrated here.
Commercial Service Tool
EIS002CQ
Tool number
(Kent-Moore No.)
Tool name
Description
(J-39570)
Chassis ear
Locating the noise
(J-43980)
NISSAN Squeak and Rat-
tle Kit
Repairing the cause of noise
SIIA0993E
SIIA0994E
Tool name
Description
Engine ear
(J-39565)
Locating the noise
SIIA0995E
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст