Nissan Qashqai J11. Manual — part 175
CO-104
< REMOVAL AND INSTALLATION >
[R9M]
WATER OUTLET
WATER OUTLET
Exploded View
INFOID:0000000010416539
for symbols in the figure.
Removal and Installation
INFOID:0000000010416540
REMOVAL
1.
Drain engine coolant from radiator. Refer to
.
CAUTION:
Perform this step when engine is cold.
2.
Remove battery. Refer to
PG-155, "Removal and Installation"
.
3.
Remove intake manifold. Refer to
EM-387, "Removal and Installation"
4.
Disconnect radiator hose (lower). Refer to
5.
Disconnect water hoses from water outlet.
6.
Remove water outlet and thermostat assembly.
7.
CAUTION:
The thermostat cannot be separated from the water outlet.
INSTALLATION
Install in the reverse order of removal.
1.
Water hose
2.
Water pump
3.
Cylinder block
4.
O-ring
5.
Water pump inlet pipe
6.
Water pump inlet pipe intermediate
7.
Water outlet
8.
Water pipe between water inlet
housing and water chamber
9.
O-ring
10. intake manifold
11.
Water hose between intake manifold
and water chamber
12.
Water valve
A.
To Radiator
B.
To reservoir tank
E1BIA0656GB
WATER OUTLET
CO-105
< REMOVAL AND INSTALLATION >
[R9M]
C
D
E
F
G
H
I
J
K
L
M
A
CO
N
P
O
Inspection
INFOID:0000000010416541
INSPECTION AFTER REMOVAL
Water outlet and thermostat assembly
1.
Check valve seating condition at ordinary room temperatures. It should seat tightly.
INSPECTION AFTER INSTALLATION
• Check that the reservoir tank cap is tightened.
• Check for leaks of engine coolant using the adapter and the reservoir tank cap tester [SST: — (M.S. 554-07).
• Start and warm up the engine. Visually make sure that there is no leaks of engine coolant.
Standard:
CO-106
< SERVICE DATA AND SPECIFICATIONS (SDS)
[R9M]
SERVICE DATA AND SPECIFICATIONS (SDS)
SERVICE DATA AND SPECIFICATIONS (SDS)
SERVICE DATA AND SPECIFICATIONS (SDS)
Periodical Maintenance Specification
INFOID:0000000010416547
ENGINE COOLANT CAPACITY (APPROXIMATE)
Unit:
(Imp qt)
Radiator
INFOID:0000000010416548
Unit: kPa (bar, kg/cm
2
, psi)
Thermostat
INFOID:0000000010416549
Standard
Engine coolant capacity (With reservoir tank at “MAX” level)
M/T models
7.3 (6-3/8)
CVT models
7.9 (7)
Reservoir tank engine coolant capacity (At “MAX” level)
0.8 (3/4)
Reservoir tank cap relief pressure
140 (1.4, 1.4, 20)
Leakage testing pressure
140 (1.4, 1.4, 20)
Valve opening temperature
80 - 92
°
C (176 - 197
°
F)
ECH-1
ENGINE
C
D
E
F
G
H
I
J
K
L
M
SECTION
ECH
A
ECH
N
O
P
CONTENTS
ENGINE CONTROL SYSTEM (HR)
HRA2DDT
PRECAUTION . . . . . . . . . . . ...
PRECAUTIONS . . . . . . . . . . . . ...
Precaution for Procedure without Cowl Top Cover
. ..
Precautions for Removing Battery Terminal . . .....
Precaution for Stop/Start System Service . . . .....
On Board Diagnostic (OBD) System of Engine . .....
General Precautions . . . . . . . . . . . .....
PREPARATION . . . . . . . . . . ...
PREPARATION . . . . . . . . . . . . ..
Special Service Tools . . . . . . . . . . . ..
SYSTEM DESCRIPTION . . . . . . . .
COMPONENT PARTS . . . . . . . . . ...
Component Parts Location . . . . . . . . . ..
Accelerator Pedal Position Sensor . . . . . . ..
ASCD Steering Switch . . . . . . . . . . .
Camshaft Position Sensor . . . . . . . . . ...
Clutch Pedal Position Switch . . . . . . . . ..
Clutch Interlock Switch . . . . . . . . . . .
Cooling Fan . . . . . . . . . . . . . . . .
Cooling Fan Resistor . . . . . . . . . . . ...
Crankshaft Position Sensor . . . . . . . . . .
DC/DC Converter . . . . . . . . . . . . .
ECM . . . . . . . . . . . . . . . . . .
Electric Throttle Control Actuator . . . . . . .
Engine Coolant Bypass Valve . . . . . . . . .
Engine Coolant Bypass Valve Control Solenoid
Valve . . . . . . . . . . . . . . . . . ...
Engine Coolant Temperature Sensor . . . . . ..
Engine Oil Pressure Control Solenoid Valve . . ...
Engine Restart Relay . . . . . . . . . . . ..
Engine Restart Bypass Control Relay . . . . . .
Engine Restart Bypass Relay . . . . . . . . ..
EVAP Canister Purge Volume Control Solenoid
Valve . . . . . . . . . . . . . . . . . .
Exhaust Valve Timing Control Position Sensor . ...
Exhaust Valve Timing Control Solenoid Valve . .
Fuel Injector . . . . . . . . . . . . . . . .
Fuel Rail Pressure Sensor . . . . . . . . . ...
Heated Oxygen Sensor 1 . . . . . . . . . .
Heated Oxygen Sensor 2 . . . . . . . . . .
High Pressure Fuel Pump . . . . . . . . . ...
Hood Switch . . . . . . . . . . . . . . .
Ignition Coil . . . . . . . . . . . . . . . ..
Intake Air Temperature Sensor . . . . . . . ...
Intake Manifold Pressure Sensor . . . . . . .
Intake Valve Timing Control Solenoid Valve . . ...
Knock Sensor . . . . . . . . . . . . . . ..
Fuel Pump . . . . . . . . . . . . . . . ...
Malfunction Indicator Lamp . . . . . . . . . .
Reverse/Neutral Position Switch . . . . . . . .
Refrigerant Pressure Sensor . . . . . . . . ...
Stop Lamp Switch . . . . . . . . . . . . .
Stop/Start Indicator Lamp . . . . . . . . . .
Stop/Start OFF Switch . . . . . . . . . . . .
Thermostat Heater Control Solenoid Valve . . . .
Turbocharger wastegate control solenoid valve . ..
Turbocharger Boost Sensor . . . . . . . . .
Turbocharger bypass valve control solenoid valve
SYSTEM . . . . . . . . . . . . . . .
ENGINE CONTROL SYSTEM . . . . . . . . ...
ENGINE CONTROL SYSTEM : System Descrip-
tion . . . . . . . . . . . . . . . . . . ...
ENGINE SPEED CONTROL . . . . . . . . . ..
ENGINE SPEED CONTROL : System Description
.
POWERTRAIN COORDINATION CONTROL . . ...
POWERTRAIN COORDINATION CONTROL :
System Description . . . . . . . . . . . . ..
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст