Nissan Maxima. Manual — part 564
EX-4
< PERIODIC MAINTENANCE >
EXHAUST SYSTEM
PERIODIC MAINTENANCE
EXHAUST SYSTEM
Checking Exhaust System
INFOID:0000000009464994
Check the exhaust pipes, muffler, and mounting components for
incorrect attachment, leaks, cracks, damage, or deterioration.
SMA211A
EXHAUST SYSTEM
EX-5
< REMOVAL AND INSTALLATION >
C
D
E
F
G
H
I
J
K
L
M
A
EX
N
P
O
REMOVAL AND INSTALLATION
EXHAUST SYSTEM
Exploded View
INFOID:0000000009464995
Removal and Installation
INFOID:0000000009464996
WARNING:
• Perform the procedures with the exhaust system fully cooled down to avoid injury from the hot
exhaust system.
• Be careful not to cut your hand on the insulator edge.
CAUTION:
Use Genuine NISSAN exhaust system parts or equivalent, which are specifically designed for heat
resistance, corrosion resistance, and shape.
REMOVAL
• Remove exhaust system components using power tool.
• When removing center exhaust tube, remove tunnel stay bracket.
INSTALLATION
Installation is in the reverse order of removal.
CAUTION:
1.
Front exhaust tube
2.
Ring gasket
3.
Front exhaust tube stay
4.
Front exhaust tube bracket 5.
Gasket
6.
Center exhaust tube rubber hanger
7.
Center exhaust tube
8.
Center exhaust tube hanger
9.
Rear muffler bracket (RH)
10. Rear muffler (RH)
11. Rear muffler bracket (LH)
12. Rear muffler (LH)
Front
AWBIA1643ZZ
EX-6
< REMOVAL AND INSTALLATION >
EXHAUST SYSTEM
• Always replace exhaust gaskets with new ones when reassembling.
• If any insulator is badly deformed, repair or replace it. If deposits such as mud pile up on the insula-
tor, clean and inspect them.
• Temporarily tighten the nuts on the exhaust manifold side and the bolts on the vehicle side. Check
each part for interference with other components, and then tighten the nuts and bolts to specifica-
tion.
INSPECTION AFTER INSTALLATION
• With the engine running, check the exhaust tube joints for exhaust gas leaks and unusual noises.
• Check that the mounting brackets and mounting insulators are installed properly and free from excessive
stress. Improper installation could result in excessive noise, leaks, and vibration.
EXL-1
DRIVER CONTROLS
C
D
E
F
G
H
I
J
K
M
SECTION
EXL
A
B
EXL
N
O
P
CONTENTS
EXTERIOR LIGHTING SYSTEM
XENON TYPE
BASIC INSPECTION . . . . . . . . .
DIAGNOSIS AND REPAIR WORKFLOW . . ..
Work Flow . . . . . . . . . . . . . . . .....
SYSTEM DESCRIPTION . . . . . . . ..
HEADLAMP . . . . . . . . . . . . . . .
System Diagram . . . . . . . . . . . . . ....
System Description . . . . . . . . . . . . ...
Component Parts Location . . . . . . . . . ....
Component Description . . . . . . . . . . ...
DAYTIME RUNNING LIGHT SYSTEM . . . ..
System Diagram . . . . . . . . . . . . . ..
System Description . . . . . . . . . . . . .
Component Parts Location . . . . . . . . . ..
Component Description . . . . . . . . . . ...
AUTO LIGHT SYSTEM . . . . . . . . . ..
System Diagram . . . . . . . . . . . . . ..
System Description . . . . . . . . . . . . .
Component Parts Location . . . . . . . . . ..
Component Description . . . . . . . . . . ...
FRONT FOG LAMP . . . . . . . . . . .
System Diagram . . . . . . . . . . . . . ..
System Description . . . . . . . . . . . . .
Component Parts Location . . . . . . . . . ..
Component Description . . . . . . . . . . ...
TURN SIGNAL AND HAZARD WARNING
LAMPS . . . . . . . . . . . . . . . ...
System Diagram . . . . . . . . . . . . . ..
System Description . . . . . . . . . . . . .
Component Parts Location . . . . . . . . . ..
Component Description . . . . . . . . . . ...
PARKING, LICENSE PLATE AND TAIL
LAMPS . . . . . . . . . . . . . . . ...
System Diagram . . . . . . . . . . . . . ..
System Description . . . . . . . . . . . . ..
Component Parts Location . . . . . . . . . ..
Component Description . . . . . . . . . . ...
COMBINATION SWITCH READING SYSTEM
...
System Diagram . . . . . . . . . . . . . ..
System Description . . . . . . . . . . . . ..
DIAGNOSIS SYSTEM (BCM) . . . . . . ...
COMMON ITEM . . . . . . . . . . . . . . .
COMMON ITEM : CONSULT Function (BCM -
COMMON ITEM) . . . . . . . . . . . . . .
HEADLAMP . . . . . . . . . . . . . . . ...
HEADLAMP : CONSULT Function (BCM - HEAD
LAMP) . . . . . . . . . . . . . . . . . ..
FLASHER . . . . . . . . . . . . . . . . ...
FLASHER : CONSULT Function (BCM - FLASH-
ER) . . . . . . . . . . . . . . . . . . ..
COMB SW . . . . . . . . . . . . . . . . ..
COMB SW : CONSULT Function (BCM-COMB
SW) . . . . . . . . . . . . . . . . . . ..
BATTERY SAVER . . . . . . . . . . . . . .
BATTERY SAVER : CONSULT Function (BCM -
BATTERY SAVER) . . . . . . . . . . . . ..
DIAGNOSIS SYSTEM (IPDM E/R) . . . . ...
Diagnosis Description . . . . . . . . . . . ..
CONSULT Function (IPDM E/R) . . . . . . . .
DTC/CIRCUIT DIAGNOSIS . . . . . . .
POWER SUPPLY AND GROUND CIRCUIT .
BCM (BODY CONTROL MODULE) . . . . . . ..
BCM (BODY CONTROL MODULE) : Diagnosis
Procedure . . . . . . . . . . . . . . . .
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст