Nissan X-Trail 32. Manual — part 1286
FAX-136
< REMOVAL AND INSTALLATION >
[4WD]
FRONT DRIVE SHAFT
• Check boot for cracks, damage, and leakage of grease.
• Disassemble drive shaft and exchange malfunctioning part if there
is a non-standard condition.
INSPECTION AFTER DISASSEMBLY
Shaft
Check shaft for runout, cracks, or other damage. Replace if there are.
Dynamic Damper (If equipped)
Check damper for cracks or wear. Replace if necessary.
Joint Sub-Assembly (Wheel Side)
Check the following:
• Joint sub-assembly for rough rotation and excessive axial looseness
• The inside of the joint sub-assembly for entry of foreign material
• Joint sub-assembly for compression scars, cracks, and fractures inside of joint sub-assembly
Replace joint sub-assembly if there are any non-standard conditions of components.
Housing and Spider assembly (Transaxle Side)
Replace housing and spider assembly if there is scratching or wear of housing roller contact surface or spider
roller contact surface.
NOTE:
Housing and spider assembly are used in a set.
Support Bearing (Right Side)
Make sure wheel bearing rolls freely and is free from noise, cracks, pitting or wear. Replace support bearing if
there are any non-standard conditions.
Support Bearing Bracket (Right Side)
Check for bending, cracks, or damage. Replace support bearing bracket if there are any non-standard condi-
tions.
INSPECTION AFTER INSTALLATION
1.
Check wheel sensor harness for proper connection. Refer to
BRC-212, "FRONT WHEEL SENSOR :
.
2.
Check the wheel alignment. Refer to
.
3.
Adjust neutral position of steering angle sensor. Refer to
.
SDIA1190J
SERVICE DATA AND SPECIFICATIONS (SDS)
FAX-137
< SERVICE DATA AND SPECIFICATIONS (SDS)
[4WD]
C
E
F
G
H
I
J
K
L
M
A
B
FAX
N
O
P
SERVICE DATA AND SPECIFICATIONS (SDS)
SERVICE DATA AND SPECIFICATIONS (SDS)
Wheel Bearing
INFOID:0000000010824424
Drive Shaft
INFOID:0000000010824425
MR20DD
*: For measuring position. Refer to
FAX-107, "MR20DD : Disassembly and Assembly"
.
QR25DE
*: For measuring position. Refer to
FAX-119, "QR25DE : Disassembly and Assembly"
.
R9M
*: For measuring position. Refer to
FAX-131, "R9M : Disassembly and Assembly"
Axial end play
0.05 mm (0.002 in) or less
Item
Standard
Left side
Right side
Grease quantity
Wheel side
115 – 135 g (4.06 – 4.76 oz)
Transaxle side
175 – 195 g (6.18 – 6.87 oz)
Boots installed length
*
Wheel side
141.5 mm (5.57 in)
Transaxle side
196.9 mm (7.75 in)
188.9 mm (7.44 in)
Dimension of dynamic damper
*
A
273 – 279 mm (10.75 – 10.98 in)
243 – 249 mm (9.57 – 9.80 in)
B
70 mm (2.76 in)
Item
Standard
Left side
Right side
Grease quantity
Wheel side
115 – 135 g (4.06 – 4.76 oz)
Transaxle side
175 – 195 g (6.18 – 6.87 oz)
Boots installed length
*
Wheel side
141.5 mm (5.57 in)
Transaxle side
196.9 mm (7.75 in)
188.9 mm (7.44 in)
Dimension of dynamic damper
*
A
240 – 246 mm (9.45 – 9.68 in)
B
70 mm (2.76 in)
50 mm (1.97 in)
Item
Standard
Left side
Right side
Grease quantity
Wheel side
145 – 165 g (5.11 – 5.82 oz)
Transaxle side
265 – 285 g (9.35 – 10.05 oz)
Boots installed length
*
Wheel side
145 mm (5.71 in)
Transaxle side
196.1 mm (7.72 in)
184.1 mm (7.25 in)
Dimension of dynamic damper
*
A
207 – 213 mm (8.15 – 8.39 in)
—
B
70 mm (2.76 in)
—
FL-1
ENGINE
C
D
E
F
G
H
I
J
K
L
M
SECTION
FL
A
FL
N
O
P
CONTENTS
FUEL SYSTEM
GASOLINE ENGINE MODEL
PRECAUTION . . . . . . . . . . . ...
PRECAUTIONS . . . . . . . . . . . . ...
Precautions for Removing Battery Terminal . . .....
General Precautions . . . . . . . . . . . .....
PREPARATION . . . . . . . . . . .
PREPARATION . . . . . . . . . . . . ...
Special Service Tools . . . . . . . . . . . ....
SYSTEM DESCRIPTION . . . . . . . ..
SYSTEM . . . . . . . . . . . . . . . ..
WARNING/INDICATOR (ON INFORMATION DIS-
PLAY) . . . . . . . . . . . . . . . . . . ..
WARNING/INDICATOR (ON INFORMATION
DISPLAY) : Low fuel warning . . . . . . . . ....
WARNING/INDICATOR/CHIME LIST . . . . . .....
WARNING/INDICATOR/CHIME LIST : Warning/
Indicator (On Information Display) . . . . . . ....
PERIODIC MAINTENANCE . . . . . . ..
FUEL SYSTEM . . . . . . . . . . . . .
Hydraulic Layout . . . . . . . . . . . . . ...
Inspection . . . . . . . . . . . . . . . . ..
Quick Connector . . . . . . . . . . . . . ...
REMOVAL AND INSTALLATION . . . ...
FUEL LEVEL SENSOR UNIT, FUEL FILTER
AND FUEL PUMP ASSEMBLY . . . . . . .
Exploded View . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
Disassembly and Assembly . . . . . . . . .
Inspection . . . . . . . . . . . . . . . .
FUEL TANK . . . . . . . . . . . . . .
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
Inspection . . . . . . . . . . . . . . . .
EVAP CANISTER . . . . . . . . . . . ..
Hydraulic Layout . . . . . . . . . . . . . ..
Removal and Installation . . . . . . . . . . .
Inspection . . . . . . . . . . . . . . . .
SERVICE DATA AND SPECIFICATIONS
(SDS) . . . . . . . . . . . . . . .
SERVICE DATA AND SPECIFICATIONS
(SDS) . . . . . . . . . . . . . . . . .
Fuel Tank . . . . . . . . . . . . . . . . .
DIESEL ENGINE MODEL
PRECAUTION . . . . . . . . . . . ..
PRECAUTIONS . . . . . . . . . . . . .
Precautions for Removing Battery Terminal . . .
General Precautions . . . . . . . . . . . .
PREPARATION . . . . . . . . . . ...
PREPARATION . . . . . . . . . . . . .
Special Service Tools . . . . . . . . . . . ..
SYSTEM DESCRIPTION . . . . . . . .
COMPONENT PARTS . . . . . . . . . ..
Fuel Filter Sensor . . . . . . . . . . . . .
STRUCTURE AND OPERATION . . . . . .
FUEL TRANSPORTATION IN FUEL TANK . . . ..
FUEL TRANSPORTATION IN FUEL TANK : Sys-
tem Description . . . . . . . . . . . . . .
SYSTEM . . . . . . . . . . . . . . .
WARNING/INDICATOR (ON INFORMATION DIS-
PLAY) . . . . . . . . . . . . . . . . . . .
FL-2
WARNING/INDICATOR (ON INFORMATION
DISPLAY) : Low fuel warning . . . . . . . . .
WARNING/INDICATOR/CHIME LIST . . . . . ...
WARNING/INDICATOR/CHIME LIST : Warning
lamps/Indicator lamps . . . . . . . . . . . .
WARNING/INDICATOR/CHIME LIST : Warning/
Indicator (On Information Display) . . . . . . ..
PERIODIC MAINTENANCE . . . . . .
FUEL SYSTEM . . . . . . . . . . . . ..
Hydraulic Layout . . . . . . . . . . . . . .
Inspection . . . . . . . . . . . . . . . ...
Air Bleeding . . . . . . . . . . . . . . ....
Quick Connector . . . . . . . . . . . . . .
FUEL FILTER . . . . . . . . . . . . .
Exploded View . . . . . . . . . . . . . ....
Removal and Installation . . . . . . . . . ....
Draining Water from Fuel Filter . . . . . . . ..
Inspection . . . . . . . . . . . . . . . ...
REMOVAL AND INSTALLATION . . . ..
FUEL LEVEL SENSOR UNIT, FUEL FILTER
AND FUEL PUMP ASSEMBLY . . . . . . .
Exploded View . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
Disassembly and Assembly . . . . . . . . .
Inspection . . . . . . . . . . . . . . . .
FUEL TANK . . . . . . . . . . . . . ...
Exploded View . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
Inspection . . . . . . . . . . . . . . . .
SERVICE DATA AND SPECIFICATIONS
(SDS) . . . . . . . . . . . . . . ..
SERVICE DATA AND SPECIFICATIONS
(SDS) . . . . . . . . . . . . . . . . .
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст