Nissan Terrano r20e. Manual — part 204
General Specifications
Engine speed
Unit: rpm
Engine
TD27Ti
Idle speed
A/C: ON
725
845
Maximum engine speed
5,500
Pump numbers
Engine
Part number
Pump assembly num-
ber
TD27Ti
16700 7F410
104701-2032
RNP11
Pump data is not yet available.
Refer to CALIBRATION STANDARD published
by BOSCH.
Injection Nozzle
INSPECTION AND ADJUSTMENT
Injection nozzle assembly
Unit: kPa (bar, kg/cm
2
, psi)
Initial injection pressure
New
12,749 - 13,730 (127.5 - 137.3, 130 - 140,
1,849 - 1,991)
Used
12,259 - 12,749 (122.6 - 127.5, 120 - 135,
1,706 - 1,849)
Inspection and Adjustment
Plunger lift
mm (in)
at TDC
0.275 ± 0.02
(0.0108) ± (0.0008)
Idle speed
rpm
(“N” or “P” position)
725 ± 25
MASS AIR FLOW SENSOR
Supply voltage
V
Approximately 5
Output voltage
V
1.5 - 2.7*
*: Engine is warmed up sufficiently and idling under no-load.
ENGINE COOLANT TEMPERATURE
SENSOR
Temperature °C (°F)
Resistance k
Ω
20 (68)
2.1 - 2.9
50 (122)
0.68 - 1.00
90 (194)
0.236 - 0.260
CONTROL SLEEVE POSITION SENSOR
Resistance [at 25°C (77°F)]
Ω
Approximately 6.1
INJECTION TIMING CONTROL VALVE
Resistance [at 25°C (77°F)]
Ω
Approximately 15
NEEDLE LIFT SENSOR
Resistance [at 25°C (77°F)]
Ω
Approximately 105
CRANKSHAFT POSITION SENSOR (TDC)
Resistance [at 25°C (77°F)]
Ω
Approximately 900
GLOW PLUG
Resistance [at 25°C (77°F)]
Ω
0.5
ACCELERATOR POSITION SENSOR
Throttle valve conditions
Resistance k
Ω
[at 25°C (77°F)]
Completely closed
Approximately 1.2
Partially open
1.2 - 1.9
Completely open
Approximately 1.9
FUEL TEMPERATURE SENSOR
Temperature °C (°F)
Resistance k
Ω
25 (77)
Approximately 1.9
SERVICE DATA AND SPECIFICATIONS (SDS)
TD27Ti
EC-453
NOTES
ELECTRICAL SYSTEM
When you read wiring diagrams:
I
Read GI section, “HOW TO READ WIRING DIAGRAMS”.
CONTENTS
Description . . . . . . . . . . . . . . . . ...3
. . . . . . . . . . . ..4
Description . . . . . . . . . . . . . . . . ...4
. . . . . . . . . . ...6
Schematic . . . . . . . . . . . . . . . . . 6
Wiring Diagram - POWER - . . . . . . . . . . 8
Fuse . . . . . . . . . . . . . . . . . . ...17
Fusible Link. . . . . . . . . . . . . . . . 17
Circuit Breaker Inspection . . . . . . . . . . .17
. . . . . . . . . . . .18
. . . . . . . . . . . ...23
Check. . . . . . . . . . . . . . . . . . .23
Replacement. . . . . . . . . . . . . . . ..24
. . . . . . . . . . . . . ..25
Check. . . . . . . . . . . . . . . . . . .25
HEADLAMP - Without Daytime Light System -
. . .26
Wiring Diagram - H/LAMP -. . . . . . . . . ...26
HEADLAMP - Daytime Light System -
. . . . . ...29
Operation . . . . . . . . . . . . . . . . ...29
Schematic . . . . . . . . . . . . . . . . ..30
Wiring Diagram - DTRL -. . . . . . . . . . ...31
HEADLAMP - Headlamp Aiming Control -
. . . . .37
Description . . . . . . . . . . . . . . . . .37
Replacing Headlamp Aiming Actuator . . . . . ...38
Wiring Diagram - H/AIM - . . . . . . . . . . ..39
Trouble Diagnoses. . . . . . . . . . . . . .42
. . . . . . . . . . . . . . . . ...43
Bulb Replacement . . . . . . . . . . . . . .43
Aiming Adjustment . . . . . . . . . . . . . .43
. . . . . . . . . . . . . . ..45
Wiring Diagram - TAIL/L -. . . . . . . . . . ..45
Wiring Diagram - STOP/L - . . . . . . . . . ...48
Wiring Diagram - BACK/L - . . . . . . . . . ...49
Wiring Diagram - F/FOG - . . . . . . . . . . .51
Front Fog Lamp Aiming Adjustment . . . . . . ..53
Wiring Diagram - R/FOG -. . . . . . . . . . .54
Schematic . . . . . . . . . . . . . . . . ..55
Wiring Diagram - TURN - . . . . . . . . . . ..56
Bulb Specifications . . . . . . . . . . . . . 60
. . . . . . . . . . . . . . ...61
Schematic . . . . . . . . . . . . . . . . ..61
Wiring Diagram - ILL - . . . . . . . . . . . ...62
Wiring Diagram - INT/L - . . . . . . . . . . ...66
. . . . . . . . . . . . .70
Combination Meter . . . . . . . . . . . . . 70
Schematic . . . . . . . . . . . . . . . . ..71
Wiring Diagram - METER - . . . . . . . . . ...72
Combination Meter Self-Diagnosis . . . . . . . 76
Components Inspection . . . . . . . . . . . .78
Trouble Diagnoses. . . . . . . . . . . . . .79
Fuel Tank Gauge Unit Check . . . . . . . . . 80
Thermal Transmitter Check . . . . . . . . . ...80
Oil Pressure Switch Check. . . . . . . . . . 80
. . . . . . . . ...81
Schematic . . . . . . . . . . . . . . . . ..81
Wiring Diagram - WARN - . . . . . . . . . . .82
Diode Check . . . . . . . . . . . . . . . ..92
Wiring Diagram - CHIME - . . . . . . . . . . 93
. . . . . . . . . . . . ..94
Wiring Diagram - WIPER - . . . . . . . . . . 94
Wiring Diagram - WIP/R -. . . . . . . . . . ..96
Installation. . . . . . . . . . . . . . . . ..98
Washer Nozzle Adjustment . . . . . . . . . ...99
Check Valve. . . . . . . . . . . . . . . ...99
Wiring Diagram - HLC -. . . . . . . . . . ...100
HORN, CIGARETTE LIGHTER AND CLOCK
. . . 104
Wiring Diagram - HORN - . . . . . . . . . ...104
Wiring Diagram - CIGAR -. . . . . . . . . ...105
Wiring Diagram - CLOCK -. . . . . . . . . ..106
REAR WINDOW DEFOGGER AND DOOR
MIRROR DEFOGGER
. . . . . . . . . . . . .107
Wiring Diagram - DEF -. . . . . . . . . . ...107
Filament Check. . . . . . . . . . . . . . 109
Filament Repair . . . . . . . . . . . . . ... 110
. . . . . . . . . . . . . . . . . . .. 111
System Description. . . . . . . . . . . . .. 111
Schematic . . . . . . . . . . . . . . . . 113
Wiring Diagram - AUDIO -. . . . . . . . . ... 115
Wiring Diagram - REMOTE -. . . . . . . . ...122
Trouble Diagnoses. . . . . . . . . . . . ...124
Inspection. . . . . . . . . . . . . . . . .126
Location of Roof Mounted Antenna. . . . . . .127
. . . . . . . . . . . . . . . 128
Wiring Diagram - HSEAT - . . . . . . . . . ..128
. . . . . . . . . . . . . . . . . 130
Wiring Diagram - SROOF - . . . . . . . . . .130
. . . . . . . . . . . . . . ...131
Wiring Diagram - MIRROR - . . . . . . . . ...131
. . . . . . . . . . . . . ...133
Schematic . . . . . . . . . . . . . . . . 133
Wiring Diagram - WINDOW - . . . . . . . . ..134
Power Door Lock . . . . . . . . . . . . . .137
Schematic . . . . . . . . . . . . . . . . 138
Wiring Diagram - D/LOCK -. . . . . . . . . .140
POWER DOOR LOCK - SUPER LOCK -
. . . . ...145
Component Parts Location . . . . . . . . . ..145
System Description. . . . . . . . . . . . ..146
Schematic . . . . . . . . . . . . . . . . 148
Wiring Diagram - S/LOCK -. . . . . . . . . .150
Trouble Diagnoses. . . . . . . . . . . . ...158
. . . . . ...168
Schematic . . . . . . . . . . . . . . . . 168
Wiring Diagram - MULTI - . . . . . . . . . ...169
Trouble Diagnoses. . . . . . . . . . . . ...177
ID Code Entry Procedure . . . . . . . . . . 179
. . . . . . . . . .180
System Description. . . . . . . . . . . . ..180
Trouble Diagnosis . . . . . . . . . . . . . 182
Schematic . . . . . . . . . . . . . . . . 184
NATS (Nissan Anti-Theft System)
. . . . . . . .186
System Description. . . . . . . . . . . . ..186
System Composition. . . . . . . . . . . . 187
Component Parts Location . . . . . . . . . ..188
Wiring Diagram - NATS -. . . . . . . . . . .189
CONSULT-II . . . . . . . . . . . . . . . .193
Trouble Diagnoses. . . . . . . . . . . . ...195
How to Replace NATS IMMU. . . . . . . . ..208
. . . . . . . . . ...209
Components Parts and Harness Connector
Location . . . . . . . . . . . . . . . . ...209
System Description. . . . . . . . . . . . ..210
Theft Warning System/Schematic . . . . . . ...213
Wiring Diagram - THEFT -. . . . . . . . . ...214
Trouble Diagnoses. . . . . . . . . . . . ...230
. . . . . . .241
Engine Compartment. . . . . . . . . . . ...241
Passenger Compartment/LHD Models. . . . . 242
Passenger Compartment/RHD Models . . . . ...244
. . . . . . . . . . . . . 247
Outline. . . . . . . . . . . . . . . . . ..247
Main Harness. . . . . . . . . . . . . . ...248
EFC Harness . . . . . . . . . . . . . . ...264
Engine Harness . . . . . . . . . . . . . ...276
Body Harness . . . . . . . . . . . . . . ..278
Chassis Harness. . . . . . . . . . . . . ..286
Room Lamp Harness. . . . . . . . . . . ...287
Tailgate Harness . . . . . . . . . . . . . ..288
Door Harness (LH side). . . . . . . . . . ...289
Door Harness (RH side) . . . . . . . . . . ..290
WIRING DIAGRAM CODES (CELL CODES)
. . . .291
WIRING DIAGRAM REFERENCE CHART
ENGINE CONTROL SYSTEM, IGNITION SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . EC SECTION
RESTRAINT SYSTEM (AIR BAG) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ...RS SECTION
HEATER AND AIR CONDITIONER. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ..HA SECTION
CONTENTS
(Cont’d)
EL-2
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст