Nissan Xterra. Manual — part 166
CHG
GENERATOR
CHG-27
< REMOVAL AND INSTALLATION >
C
D
E
F
G
H
I
J
K
L
B
A
O
P
N
REMOVAL AND INSTALLATION
GENERATOR
Exploded View
INFOID:0000000009484997
Removal and Installation
INFOID:0000000009484998
NOTE:
When removing components such as hoses, tubes/lines, etc., cap or plug openings to prevent fluid from spill-
ing.
REMOVAL
1. Disconnect the negative battery terminal. Refer to
PG-72, "Removal and Installation"
2. Remove engine cooling fan (Motor Driven Type). Refer to
CO-19, "Removal and Installation (Motor driven
.
3. Remove the drive belt. Refer to
EM-13, "Removal and Installation"
.
4. Remove the generator stay, using power tools.
5. Remove the generator upper bolt, using power tools.
6. Disconnect the harness connectors from the generator.
7. Remove the generator.
INSTALLATION
Installation is in the reverse order of removal.
• Install the generator and check tension of drive belt. Refer to
.
CAUTION:
Tighten terminal nut carefully.
1.
Generator
2.
Engine block
3.
Generator stay
AWMIA1170GB
Terminal nut
: 10.8 N·m (1.1 kg-m, 8 ft-lb)
CHG-28
< REMOVAL AND INSTALLATION >
GENERATOR
• For this model, the power generation variable voltage control system that controls the power generation volt-
age of the generator has been adopted. Therefore, the power generation variable voltage control system
inspection should be performed after replacing the generator in order to ensure that the system operates
normally. Refer to
.
CHG
SERVICE DATA AND SPECIFICATIONS (SDS)
CHG-29
< SERVICE DATA AND SPECIFICATIONS (SDS)
C
D
E
F
G
H
I
J
K
L
B
A
O
P
N
SERVICE DATA AND SPECIFICATIONS (SDS)
SERVICE DATA AND SPECIFICATIONS (SDS)
Generator
INFOID:0000000009484999
*: Always check with the Parts Department for the latest parts information.
Type*
TG15S192
Valeo
Engine
VQ40DE
Nominal rating
14V-130A
Ground polarity
Negative
Minimum revolution under no-load
1,200 rpm
Hot output current (When 13.5 volts is applied)
More than 52A/1,500 rpm
More than 82A/1,800 rpm
More than 115A/2,500 rpm
More than 130A/5,000 rpm
Regulated output voltage
13.5V @ 5,000 rpm @ 20
°C (68°F)
Adjustment range of power generation variable
voltage control
11.7 - 15.3V
CL-1
TRANSMISSION & DRIVELINE
C
E
F
G
H
I
J
K
L
M
SECTION
CL
A
B
CL
N
O
P
CONTENTS
CLUTCH
SYMPTOM DIAGNOSIS . . . . . . . ...
NOISE, VIBRATION AND HARSHNESS
(NVH) TROUBLESHOOTING . . . . . . . .
NVH Troubleshooting Chart . . . . . . . . . ..
PRECAUTION . . . . . . . . . . . ...
PRECAUTIONS . . . . . . . . . . . . ...
Service Notice or Precautions . . . . . . . . ...
PREPARATION . . . . . . . . . . .
PREPARATION . . . . . . . . . . . . ...
Special Service Tool . . . . . . . . . . . .....
Commercial Service Tool . . . . . . . . . . ..
PERIODIC MAINTENANCE . . . . . . ..
CLUTCH PEDAL . . . . . . . . . . . . .
On-Vehicle Inspection and Adjustment . . . . .....
CLUTCH FLUID . . . . . . . . . . . . ...
Bleeding . . . . . . . . . . . . . . . . ....
REMOVAL AND INSTALLATION . . . .
CLUTCH PEDAL . . . . . . . . . . . . .
Exploded View . . . . . . . . . . . . . . ..
Removal and Installation . . . . . . . . . . ...
Inspection . . . . . . . . . . . . . . . . ..
CLUTCH MASTER CYLINDER . . . . . . .
Exploded View . . . . . . . . . . . . . . ..
Removal and Installation . . . . . . . . . . ..
OPERATING CYLINDER . . . . . . . . ..
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
CLUTCH PIPING . . . . . . . . . . . ...
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
UNIT REMOVAL AND INSTALLATION . ..
CLUTCH RELEASE MECHANISM . . . . ...
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
Inspection . . . . . . . . . . . . . . . .
CLUTCH DISC, CLUTCH COVER . . . . .
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
Inspection and Adjustment . . . . . . . . . ..
SERVICE DATA AND SPECIFICATIONS
(SDS) . . . . . . . . . . . . . . .
SERVICE DATA AND SPECIFICATIONS
(SDS) . . . . . . . . . . . . . . . . .
Clutch Control System . . . . . . . . . . . .
Clutch Master Cylinder . . . . . . . . . . .
Clutch Operating Cylinder . . . . . . . . . ...
Clutch Disc . . . . . . . . . . . . . . . ..
Clutch Cover . . . . . . . . . . . . . . .
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст