Nissan Frontier D40. Manual — part 833
PERIODIC MAINTENANCE
MA-13
< ON-VEHICLE MAINTENANCE >
C
D
E
F
G
H
I
J
K
L
M
B
MA
N
O
A
(1) Refer to “Tire rotation” under the “General maintenance” heading earlier in this section.
For Mexico
INFOID:0000000005550700
For Mexico: Periodic Maintenance
The following tables show the normal maintenance schedule. Depending upon weather and atmospheric con-
ditions, varying road surfaces, individual driving habits and vehicle usage, additional or more frequent mainte-
nance may be required.
Periodic maintenance beyond the last period shown on the tables requires similar maintenance.
ENGINE AND EMISSION CONTROL MAINTENANCE
Abbreviations: I = Inspect and correct or replace as necessary,
R = Replace, E = Check and correct the engine coolant mixture ratio
NOTE:
Maintenance items with “
” should be performed more frequently according to “Maintenance Under Severe Driving Condi-
tions”.
(1) Periodic maintenance is not required. However, if valve noise increases, check valve clearance.
(2) Replace the drive belts if found damaged or if the auto belt tensioner reading reaches the maximum limit.
(3) Use Genuine NISSAN Engine Coolant, or equivalent in its quality in order to avoid possible aluminum corrosion within the engine
cooling system caused by the use of non-genuine engine coolant. After first replacement, replace every 40,000 km (24,000 mi8les) or 24
months.
(4) Fuel filter is maintenance-free. For service procedures, refer to FL section.
CHASSIS AND BODY MAINTENANCE
Drive shaft boots and propeller shaft
(4WD)
I
I
I
I
Exhaust system
I
I
In-cabin microfilter
R
R
R
R
MAINTENANCE OPERATION
MAINTENANCE INTERVAL
Reference
Section
- Page
or
- Content
Title
Perform at number of miles, kilometers
or months, whichever comes first.
Miles x 1,000
(km x 1,000)
Months
7.5
(12)
6
15
(24)
12
22.5
(36)
18
30
(48)
24
37.5
(60)
30
45
(72)
36
52.5
(84)
42
60
(96)
48
MAINTENANCE OPERATION
MAINTENANCE INTERVAL
Refer-
ence
page
Perform either at number of kilometers (miles) or months,
whichever comes first.
km x 1,000
(Miles x
1,000)
Months
10
(6)
6
20
(12)
12
30
(18)
18
40
(24)
24
50
(30)
30
60
(36)
36
70
(42)
42
80
(48)
48
Engine compartment and under vehicle
Intake & exhaust valve clearance
See NOTE
(1)
Drive belts
See NOTE
(2)
I
I
Engine oil (Use recommended oil)
R
R
R
R
R
R
R
R
Engine oil filter (Use Genuine NISSAN engine oil filter or
equivalent)
R
R
R
R
R
R
R
R
Engine coolant (Use Genuine NISSAN Engine Coolant or
equivalent in its quality)
See NOTE
(3)
E
R
Cooling system
I
I
I
I
Fuel lines and EVAP vapor lines
I
I
Air cleaner filter (Viscous paper type)
R
R
Fuel filter
See NOTE
(4)
—
Spark plugs (Iridium-tipped type)
Replace every 100,000 km (60,000 miles)
MA-14
< ON-VEHICLE MAINTENANCE >
PERIODIC MAINTENANCE
Abbreviations: I = Inspect and correct or replace as necessary,
R = Replace,
L = Lubricate, T = Tighten
Maintenance items with “
” should be performed more frequently according to “Maintenance Under Severe Driving Condi-
tions”.
(1) It is applicable, when the vehicle is in commercial use.
MAINTENANCE UNDER SEVERE DRIVING CONDITIONS
The maintenance intervals shown on the preceding pages are for normal operating conditions. If the vehicle is
mainly operated under severe driving conditions as shown below, more frequent maintenance must be per-
formed on the following items as shown in the table.
Severe driving conditions
A — Driving in dusty conditions
B — Repeatedly driving short distances
C — Towing a trailer or caravan
D — Extensive idling
E —Driving in extremely adverse weather conditions or in areas where ambient temperatures are either
extremely low or extremely high
F — Driving in high humidity or mountainous areas
G — Driving in areas using salt or other corrosive materials
H — Driving on rough and/or muddy roads or in the desert
I — Driving with frequent use of braking or in mountainous areas
MAINTENANCE OPERATION
MAINTENANCE INTERVAL
Reference
page
Perform either at number of kilometers
(miles) or months, whichever comes first.
km x 1,000
(Miles x 1,000)
Months
10
(6)
6
20
(12)
12
30
(18)
18
40
(24)
24
50
(30)
30
60
(36)
36
70
(42)
42
80
(48)
48
Underhood and under vehicle
Brake and automatic transmission fluid
(For level & leaks)
I
I
I
I
I
I
I
I
Brake fluid
R
R
Brake booster vacuum hoses, connec-
tions & check valve
I
I
Power steering fluid & lines (For level &
leaks)
I
I
I
I
I
I
I
I
Brake & exhaust systems
I
I
I
I
I
I
I
I
,
Transfer gear fluid (For level &leaks)
I
I
I
I
I
I
I
I
Differential gear oil (For level & leaks)
I
I
I
I
I
I
I
I
,
Steering gear & linkage, axle & suspen-
sion parts, propeller shaft, and drive
shafts
I
I
I
I
Body mountings
See NOTE (1)
T
T
T
T
Outside and inside
Wheel alignment (If necessary, rotate &
balance wheels)
I
I
I
I
,
Brake pads, rotors & other brake compo-
nents
I
I
I
I
I
I
I
I
Locks, hinges and hood latch
L
L
L
L
L
L
L
L
Seat belts, buckles, retractors, anchors
and adjustor
I
I
I
I
Foot brake & parking brake
(For free play, stroke & operation)
I
I
I
I
I
I
I
I
Air conditioner filter
R
R
R
R
PERIODIC MAINTENANCE
MA-15
< ON-VEHICLE MAINTENANCE >
C
D
E
F
G
H
I
J
K
L
M
B
MA
N
O
A
Maintenance for off-road driving (4WD only)
Whenever you drive off-road through sand, mud or water, more frequent maintenance may be required of the
following items.
• Brake pads and rotors
• Brake lines and hoses
• Differential gear oil, transfer fluid and automatic transmission fluid
• Steering linkage
• Propeller shafts and front drive shafts
• Air cleaner filter
Driving condition
Maintenance item
Maintenance
operation
Maintenance interval
Reference
page
A
.
.
.
.
.
.
.
.
Air cleaner filter
Viscous paper filter
Replace
More frequently
A
B
C
D
.
.
.
.
.
Engine oil and engine oil filter
Replace
Every 5,000 km (3,000
miles) or 3 months
.
.
.
.
.
F
.
.
.
Brake fluid
Replace
Every 20,000 km (12,000
miles) or 12 months
.
.
C
.
.
.
.
H
.
Automatic transmission fluid
Replace
Every 40,000 km (24,000
miles) or 24 months
.
.
C
.
.
.
.
H
.
Differential gear oil
Replace
Every 40,000 km (24,000
miles) or 24 months
.
.
.
.
.
.
G
H
.
Steering gear & linkage, axle & suspen-
sion parts & propeller shaft, & drive
shafts
Inspect
Every 10,000 km (6,000
miles) or 6 months
.
.
.
.
.
.
G
.
.
Locks, hinges and hood latch
Inspect
Every 5,000 km (3,000
miles) or 3 months
A
.
C
.
.
.
G
H
I
Brake pads, rotors & other brake com-
ponents
Inspect
Every 5,000 km (3,000
miles) or 3 months
A
.
.
.
.
.
.
.
.
Air conditioner filter
Replace
More frequently
MA-16
< ON-VEHICLE MAINTENANCE >
RECOMMENDED FLUIDS AND LUBRICANTS
RECOMMENDED FLUIDS AND LUBRICANTS
For North America: Fluids and Lubricants
INFOID:0000000005272733
FOR NORTH AMERICA: FLUIDS AND LUBRICANTS
QR25DE
*1: For further details, refer to
*2: If Genuine NISSAN Matic S ATF is not available, Genuine NISSAN Matic J ATF may also be used. Using automatic transmission
fluid other than NISSAN Matic S ATF or Genuine NISSAN Matic J ATF will cause deterioration in driveability and automatic transmission
durability, and may damage the automatic transmission, which is not covered by the NISSAN new vehicle limited warranty.
*3: DEXRON
TM
VI type ATF may also be used.
*4: Available in mainland U.S.A. through your NISSAN dealer.
*5: For further details, see “Air conditioner specification label”.
*6: See a NISSAN dealer for service for synthetic oil.
*7: For further details, refer to
GI-35, "Fuel (Regular Unleaded Gasoline Recommended) QR25DE and VQ40DE"
.
VQ40DE
Description
Capacity (Approximate)
Recommended Fluids/Lubricants
Metric
US measure
Imp measure
Fuel
80
21-1/8 gal
17-5/8 gal
Unleaded gasoline with an octane rating
of at least 87 AKI (RON 91) *7
Engine oil
Drain and refill
With oil filter
change
4.6
4 7/8 qt
4 qt
• Engine oil with API Certification Mark
*1
• Viscosity SAE 5W-30
Without oil filter
change
4.3
4-1/2 qt
3-3/4 qt
Dry engine (engine overhaul)
5.0
5-1/4 qt
4-3/8 qt
Cooling system
With reservoir at
MAX level
9.4
10 qt
8-1/4 qt
Genuine NISSAN Long Life Anti-freeze /
Coolant or equivalent
Automatic transmission fluid (ATF)
10.3
10-7/8 qt
9-1/8 qt
Genuine NISSAN Matic S ATF *2
Manual transmission fluid (MTF)
(5 M/T)
2.89
6-1/8 pt
5-1/8 pt
Genuine NISSAN Manual Transmission
Fluid (MTF) HQ Multi 75W-85 or API GL-
4, Viscosity SAE 75W-85
Rear final drive oil
C200
1.6
3-3/8 pt
2-7/8 pt
Genuine NISSAN differential oil synthetic
75W-90 or API GL-5 synthetic gear oil,
Viscosity SAE 75W-90 *6
Power steering fluid (PSF)
1.0
2-1/8 pt
1-3/4 pt
Genuine NISSAN PSF or equivalent *3
Brake and clutch fluids
—
—
—
Genuine NISSAN Super Heavy Duty
Brake Fluid or equivalent, DOT 3 *4
Brake grease
—
—
—
PBC (poly butyl cuprysil)
Brake pad plate grease
—
—
—
Molykote AS880N grease
Multi-purpose grease
—
—
—
NLGI No. 2 (Lithium soap base)
Windshield washer fluid
4.5
1-1/4 gal
1 gal
Genuine NISSAN Windshield Washer
Concentrate Cleaner & Anti-freeze or
equivalent
Air conditioning system refrigerant
0.70
±
0.05 kg
1.54
±
0.11 lb
1.54
±
0.11 lb
HFC-134a (R-134a) *5
Air conditioning system oil
180 m
6.1 fl oz
6.3 fl oz
NISSAN A/C System Oil Type R or equiv-
alent *5
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст