Nissan Juke F15. Manual — part 829
REAR REGULATOR
GW-23
< REMOVAL AND INSTALLATION >
C
D
E
F
G
H
I
J
L
M
A
B
GW
N
O
P
REAR REGULATOR
Exploded View
INFOID:0000000012199904
Removal and Installation
INFOID:0000000012199905
REMOVAL
1. Remove rear door glass. Refer to
GW-21, "Removal and Installation"
.
2. Disconnect the power window motor harness connector.
3. Remove rear door regulator mounting bolts and then remove rear door regulator from door panel.
4. Remove lower sash (front) mounting bolt and then remove lower sash (front) from rear door panel.
INSTALLATION
Install in the reverse order of removal.
Disassembly and Assembly
INFOID:0000000012199906
DISASSEMBLY
Remove the power window motor from the regulator assembly.
INSPECTION AFTER REMOVAL
Check the regulator assembly for the following items. Replace or grease it if a malfunction is detected.
• Wire wear
• Regulator deformation
1.
Rear door panel
2.
Sealing screen
3.
Lower sash (front)
4.
Rear door regulator assembly
5.
Power window motor
6.
Rear door glass
7.
Lower sash (rear)
8.
Rear door glass run
JMKIA5590ZZ
GW-24
< REMOVAL AND INSTALLATION >
REAR REGULATOR
ASSEMBLY
Assemble in the reverse order of disassembly.
Inspection and Adjustment
INFOID:0000000012199907
SYSTEM INITIALIZATION
Initialize the system if any of the following work is complete. Refer to
FITTING INSPECTION
• Check that the glass is fit securely into the sash groove.
• Lower the glass slightly [approximately 10 to 20 mm (0.394 to 0.787 in)], and check that the clearance to the
sash is parallel. Loosen the regulator mounting bolts, guide rail mounting bolts, and glass and guide rail
mounting bolts to correct the glass position if the clearance between the glass and sash is not parallel.
HA-1
VENTILATION, HEATER & AIR CONDITIONER
C
D
E
F
G
H
J
K
L
M
SECTION
HA
A
B
HA
N
O
P
CONTENTS
HEATER & AIR CONDITIONING SYSTEM
PRECAUTION . . . . . . . . . . . ...
PRECAUTIONS . . . . . . . . . . . . ...
Precaution for Procedure without Cowl Top Cover
. ..
Precautions For Xenon Headlamp Service . . . ...
Precautions for Removing Battery Terminal . . .....
Precautions For Refrigerant System Service . . ....
Service Equipment . . . . . . . . . . . . ....
PREPARATION . . . . . . . . . . .
PREPARATION . . . . . . . . . . . . ...
Special Service Tool . . . . . . . . . . . .....
Commercial Service Tool . . . . . . . . . .
Sealant or/and Lubricant . . . . . . . . . . .
SYSTEM DESCRIPTION . . . . . . . .
COMPONENT PARTS . . . . . . . . . ...
Component Parts Location . . . . . . . . . ..
Component Description . . . . . . . . . . ...
SYSTEM . . . . . . . . . . . . . . . .
System Diagram . . . . . . . . . . . . . ..
System Description . . . . . . . . . . . . .
BASIC INSPECTION . . . . . . . . ...
DIAGNOSIS AND REPAIR WORKFLOW . . .
Work Flow . . . . . . . . . . . . . . . ...
REFRIGERANT . . . . . . . . . . . . ..
Description . . . . . . . . . . . . . . . ..
Leak Test . . . . . . . . . . . . . . . .
Recycle Refrigerant . . . . . . . . . . . . .
Charge Refrigerant . . . . . . . . . . . . ..
LUBRICANT . . . . . . . . . . . . . ...
Description . . . . . . . . . . . . . . . ..
Inspection . . . . . . . . . . . . . . . .
Perform Lubricant Return Operation . . . . . ...
Lubricant Adjusting Procedure for Components
Replacement Except Compressor . . . . . . ...
Lubricant Adjusting Procedure for Compressor
Replacement . . . . . . . . . . . . . . ...
PERFORMANCE TEST . . . . . . . . .
Inspection . . . . . . . . . . . . . . . .
SYMPTOM DIAGNOSIS . . . . . . . ..
REFRIGERATION SYSTEM SYMPTOMS . .
Trouble Diagnosis For Unusual Pressure . . . .
Symptom Table . . . . . . . . . . . . . ...
NOISE . . . . . . . . . . . . . . . .
Symptom Table . . . . . . . . . . . . . ...
REMOVAL AND INSTALLATION . . . ...
COMPRESSOR . . . . . . . . . . . . .
Exploded View . . . . . . . . . . . . . . .
COMPRESSOR . . . . . . . . . . . . . . ..
COMPRESSOR : Removal and Installation . . .
MAGNET CLUTCH . . . . . . . . . . . . .
MAGNET CLUTCH : Removal and Installation of
Compressor Clutch . . . . . . . . . . . . ..
Inspection . . . . . . . . . . . . . . . .
COOLER PIPE AND HOSE . . . . . . . ..
Exploded View . . . . . . . . . . . . . . .
HIGH-PRESSURE FLEXIBLE HOSE . . . . . .
HIGH-PRESSURE FLEXIBLE HOSE : Removal
and Installation . . . . . . . . . . . . . .
LOW-PRESSURE FLEXIBLE HOSE . . . . . . .
LOW-PRESSURE FLEXIBLE HOSE : Removal
and Installation . . . . . . . . . . . . . .
HA-2
HIGH-PRESSURE PIPE : Removal and Installa-
tion . . . . . . . . . . . . . . . . . . ..
CONDENSER . . . . . . . . . . . . .
Exploded View . . . . . . . . . . . . . ....
CONDENSER . . . . . . . . . . . . . . ....
CONDENSER : Removal and Installation . . . ..
LIQUID TANK . . . . . . . . . . . . . . ....
LIQUID TANK : Removal and Installation . . . ...
REFRIGERANT PRESSURE SENSOR . . . . ....
REFRIGERANT PRESSURE SENSOR : Remov-
al and Installation . . . . . . . . . . . . ....
A/C UNIT ASSEMBLY . . . . . . . . . ...
Exploded View (Automatic Air Conditioning) . . ..
Exploded View (Manual Air Conditioning) . . . ..
A/C UNIT ASSEMBLY . . . . . . . . . . . ..
A/C UNIT ASSEMBLY : Removal and Installation ...
EVAPORATOR . . . . . . . . . . . . . . ..
EVAPORATOR : Removal and Installation . . . .
HEATER CORE . . . . . . . . . . . . . . .
HEATER CORE : Removal and Installation . . .
EXPANSION VALVE . . . . . . . . . . . . .
EXPANSION VALVE : Removal and Installation .
SERVICE DATA AND SPECIFICATIONS
(SDS) . . . . . . . . . . . . . . ..
SERVICE DATA AND SPECIFICATIONS
(SDS) . . . . . . . . . . . . . . . . .
Compressor . . . . . . . . . . . . . . .
Lubricant . . . . . . . . . . . . . . . . .
Refrigerant . . . . . . . . . . . . . . . ..
Engine Idling Speed . . . . . . . . . . . .
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст