Nissan Primera P12. Manual — part 616
MA-6
GENERAL MAINTENANCE
GENERAL MAINTENANCE
PFP:00000
General Maintenance
ELS000OA
General maintenance includes those items which should be checked during the normal day-to-day operation
of the vehicle. They are essential if the vehicle is to continue operating properly. The owners can perform the
checks and inspections themselves or they can have their NISSAN dealers do them for a nominal charge.
OUTSIDE THE VEHICLE
The maintenance items listed here should be performed from time to time, unless otherwise specified.
INSIDE THE VEHICLE
The maintenance items listed here should be checked on a regular basis, such as when performing periodic maintenance, cleaning the
vehicle, etc.
*: Refer to the section in P12 ESM (SM2E00-1P12E0E).
UNDER THE HOOD AND VEHICLE
The maintenance items listed here should be checked periodically e.g. each time you check the engine oil or refuel.
Item
Reference page
Tires
Check the pressure with a gauge periodically when at a service station, includ-
ing the spare, and adjust to the specified pressure if necessary. Check carefully
for damage, cuts or excessive wear.
—
Windshield wiper
blades
Check for cracks or wear if not functioning correctly.
—
Doors and engine
hood
Check that all doors, the engine hood, the trunk lid and back door operate prop-
erly. Also ensure that all latches lock securely. Lubricate if necessary. Make sure
that the secondary latch keeps the hood from opening when the primary latch is
released.
When driving in areas using road salt or other corrosive materials, check for
lubrication frequently.
Tire rotation
Tires should be rotated every 10,000 km (6,000 miles).
Item
Reference page
Lamps
Make sure that the headlamps, stop lamps, tail lamps, turn signal lamps, and
other lamps are all operating properly and installed securely. Also check
headlamp aim.
—
Warning lamps and
chimes
Make sure that all warning lamps and buzzers/chimes are operating properly.
—
Steering wheel
Check that it has the specified play.
Check for changes in the steering conditions, such as excessive free play, hard
steering or strange noises.
Free play: Less than 35 mm (1.38 in)
—
Seat belts
Check that all parts of the seat belt system (e.g. buckles, anchors, adjusters and
retractors) operate properly and smoothly, and are installed securely. Check the
belt webbing for cuts, fraying, wear or damage.
SE section*
Item
Reference page
Windshield washer
fluid
Check that there is adequate fluid in the tank.
—
Engine coolant level
Check the coolant level when the engine is cold.
(F9Q)
(YD22DDTi)
Engine oil level
Check the level after parking the vehicle (on level ground) and turning off the
engine.
(F9Q)
(YD22DDTi)
Power steering fluid
level and lines
Check the level with the engine off.
Check the line for improper attachment, leaks, cracks, etc.
Brake and clutch fluid
levels
Make sure that the brake and clutch fluid levels are between the “MAX” and
“MIN” lines on the reservoir.
Battery
Check the fluid level in each cell. It should be between the “MAX” and “MIN”
lines.
—
PERIODIC MAINTENANCE
MA-7
C
D
E
F
G
H
I
J
K
M
A
B
MA
PERIODIC MAINTENANCE
PFP:00026
Periodic Maintenance
ELS000OB
The following tables show the normal maintenance schedule. Depending upon weather and atmospheric con-
ditions, varying road surfaces, individual driving habits and vehicle usage, additional or more frequent mainte-
nance may be required.
Periodic maintenance beyond the last period shown on the tables requires similar maintenance.
ENGINE AND EMISSION CONTROL MAINTENANCE (YD DIESEL ENGINE)
(Annual Mileage <30,000 Km/year)
Abbreviations: I = Inspect and correct or replace as necessary,
R = Replace,
D = Check filter and drain water
NOTE:
●
Maintenance items with “
” should be performed more frequently according to “Maintenance Under Severe Driving
Conditions”.
●
(1) If valve noise increases, check valve clearance.
●
(2) Never use CG-4 oil.
●
(3) Oil filter and O-ring seal are replacement parts.
●
(4) First replace at 100,000 Km (60,000 miles)/60 months, then every 60,000Km (36,000 miles)/36 months. After first
replacement, perform “I” (checking the mixture ratio and correcting the mixture ratio if necessary) at the middle of
replacement interval.
●
(5) If engine power decreases, black exhaust smoke is emitted or engine noise increases, perform this maintenance item.
CHASSIS AND BODY MAINTENANCE (YD DIESEL ENGINE)
(Annual Mileage <30,000 km/year)
Abbreviations: I = Inspect and correct or replace as necessary,
R = Replace,
L = Lubricate.
MAINTENANCE OPERATION
MAINTENANCE INTERVAL
Reference page
Perform either at number of kilometers
(miles) or months, whichever comes first.
km x 1,000
(Miles x 1,000)
Months
20
(12)
12
40
(24)
24
60
(36)
36
80
(48)
48
100
(60)
60
120
(72)
72
Engine compartment and under vehicle
Intake & exhaust valve clearance
See NOTE (1)
Drive belts
I
I
I
I
I
I
Engine oil (Use recommended oil.)
See NOTE (2)
R
R
R
R
R
R
Engine oil filter (Use recommended filter)
See NOTE (3)
R
R
R
R
R
R
Engine anti-freeze coolant (Use genuine
Nissan Anti-freeze coolant (L250) or equiva-
lent)
See NOTE (4)
I
R
Cooling system
I
I
I
I
I
I
Fuel lines
I
I
I
Air cleaner filter
R
R
Fuel filter
D
R
D
R
D
R
Fuel injector
See NOTE (5)
MAINTENANCE OPERATION
MAINTENANCE INTERVAL
Reference page
Perform either at number of kilometers
(miles) or months, whichever comes first.
km x 1,000
(Miles x 1,000)
Months
20
(12)
12
40
(24)
24
60
(36)
36
80
(48)
48
100
(60)
60
120
(72)
72
Underhood and under vehicle
Headlamp aiming
I
I
I
I
I
I
Brake & clutch, systems and fluid (For level
& leaks)
I
I
I
I
I
I
Brake fluid
R
R
R
MA-8
PERIODIC MAINTENANCE
NOTE:
●
(1) Inspect once per year.
●
Maintenance items with “
” should be performed more frequently according to “Maintenance Under Severe Driving
Conditions”.
●
*: Refer to the section in P12 ESM (SM2E00-1P12E0E).
ENGINE AND EMISSION CONTROL MAINTENANCE (F9Q DIESEL ENGINE)
(Annual Mileage <30,000 km/year)
Abbreviations: R = Replace
I = Inspect: Correct or replace if necessary
D = Check filter and drain water
NOTE:
●
Maintenance items with “
” should be performed more frequently according to “Maintenance Under Severe Driving
Conditions”.
Brake booster vacuum hoses, connections
& check valve
I
I
I
Power steering fluid & lines (For level &
leaks)
I
I
I
I
I
I
Manual transaxle gear oil (For level & leaks)
I
I
I
I
I
I
Steering gear & linkage, axle & suspension
parts, front drive shafts & exhaust system
I
I
I
I
I
I
,
,
,
Wheel alignment (If necessary, rotate & bal-
ance wheels)
I
I
I
I
I
I
Brake pads, rotors & other brake compo-
nents
I
I
I
I
I
I
,
,
Foot brake, parking brake & clutch (For free
play, stroke & operation)
I
I
I
I
I
I
, PB sec-
tion*,
Ventilation air filter
R
R
R
R
R
R
Body corrosion
See NOTE (1)
MAINTENANCE OPERATION
MAINTENANCE INTERVAL
Reference page
Perform either at number of kilometers
(miles) or months, whichever comes first.
km x 1,000
(Miles x 1,000)
Months
20
(12)
12
40
(24)
24
60
(36)
36
80
(48)
48
100
(60)
60
120
(72)
72
MAINTENANCE OPERATION
MAINTENANCE INTERVAL
Reference page
Perform on a kilometer basis, but on an
annual basis when driving less than 15,000
km (9,000 miles) per year.
km x 1,000
(Mile x 1,000)
Months
30
(18)
24
60
(36)
48
90
(54)
72
120
(72)
96
Engine compartment and under vehicle
Engine oil (Use recommended oil)
R
R
R
R
Engine oil filter (Use recommended oil fil-
ter)
R
R
R
R
Timing belt
See NOTE (1)
Replace every 120,000 km/60 months
Drive belt
See NOTE (2)
I
I
I
I
Cooling system
I
I
I
I
Engine anti-freeze coolant (Use genuine
NISSAN Anti-freeze Coolant (L250) or
equivalent)
See NOTE (3)
I
I
I
Air cleaner filter
R
R
Intake & exhaust valve clearance
See NOTE (4)
Inspect every 100,000 km
Fuel lines
I
I
I
I
Fuel filter
D
R
D
R
PERIODIC MAINTENANCE
MA-9
C
D
E
F
G
H
I
J
K
M
A
B
MA
●
(1) The replacement interval for the timing belt is the maximum lifespan which should not be exceeded. Replace the tim-
ing belt if it comes into contact with fuel. The frequency of replacement should be adapted depending on vehicle usage.
See “Maintenance Under Severe Driving Conditions”.
●
(2) Replace every 120,000 km/maximum 60 moths. Replace drive belt if it comes in to contact with fuel or damage is found
during inspection.
●
(3) First replace at 90,000 km (54,000 miles)/60 months, then every 60,000 km (36,000 miles)/48 months. After first replace-
ment, perform “I” (checking the mixture ratio and correcting the mixture ratio if necessary) at the middle of replacement
interval.
●
(4) If valve noise increases, check valve clearance.
CHASSIS AND BODY MAINTENANCE (F9Q ENGINE MODELS)
Abbreviations: R = Replace
I = Inspect: Correct or replace if necessary
NOTE:
●
: Maintenance items with “
” should be performed more frequently according to “Maintenance Under Severe Driving
Conditions”.
●
(1) Inspect once per year.
●
*: Refer to the section in P12 ESM (SM2E00-1P12E0E).
MAINTENANCE UNDER SEVERE DRIVING CONDITIONS
(Annual Mileage <30,000 Km/year)
The maintenance intervals shown on the preceding pages are for normal operating conditions. If the vehicle is
mainly operated under severe driving conditions as shown below, more frequent maintenance must be per-
formed on the following items as shown in the table.
Severe driving conditions
A — Driving in dusty conditions
B — Repeatedly driving short distances
C — Towing a trailer or caravan
D — Extensive idling
MAINTENANCE OPERATION
MAINTENANCE INTERVAL
Reference page
Perform on a kilometer basis, but on an
annual basis when driving less than 15,000
km (9,000 miles) per year.
km x 1,000
(Mile x 1,000)
Months
30
(18)
24
60
(36)
48
90
(54)
72
120
(72)
96
Underhood and under vehicle
Headlamp aiming
I
I
I
I
,
Wheel alignment (if necessary, balance &
rotate wheels)
I
I
I
I
,
Brake pads, rotor & other brake compo-
nents*
I
I
I
I
,
,
Foot brake, parking brake & clutch
(for level and leaks)
I
I
I
I
, PB sec-
tion*, CL-5
Brake booster vacuum hoses, connections,
check valve
I
I
I
I
Brake & clutch, systems and fluid
(for level and leaks)
I
I
I
I
,
Brake fluid
R
R
R
R
Power steering fluid & lines
(for level & leaks)
I
I
I
I
Ventilation air filter
R
R
R
R
Manual transaxle gear oil
(check for leakage. Use genuine Nissan
gear oil or exact equivalent)
I
I
I
I
Steering gear & linkage, axle & suspension
parts, drive shafts, exhaust system
I
I
I
I
,
,
,
Body corrosion
See NOTE (1)
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст