Nissan Pathfinder (2006 year). Manual — part 388
PRECAUTIONS
SRS-3
C
D
E
F
G
I
J
K
L
M
A
B
SRS
2006 Pathfinder
PRECAUTIONS
PFP:00001
Precautions for Supplemental Restraint System (SRS) “AIR BAG” and “SEAT
BELT PRE-TENSIONER”
EHS001LI
The Supplemental Restraint System such as “AIR BAG” and “SEAT BELT PRE-TENSIONER”, used along
with a front seat belt, helps to reduce the risk or severity of injury to the driver and front passenger for certain
types of collision. This system includes seat belt switch inputs and dual stage front air bag modules. The SRS
system uses the seat belt switches to determine the front air bag deployment, and may only deploy one front
air bag, depending on the severity of a collision and whether the front occupants are belted or unbelted.
Information necessary to service the system safely is included in the SRS and SB section of this Service Man-
ual.
WARNING:
●
To avoid rendering the SRS inoperative, which could increase the risk of personal injury or death
in the event of a collision which would result in air bag inflation, all maintenance must be per-
formed by an authorized NISSAN/INFINITI dealer.
●
Improper maintenance, including incorrect removal and installation of the SRS, can lead to per-
sonal injury caused by unintentional activation of the system. For removal of Spiral Cable and Air
Bag Module, see the SRS section.
●
Do not use electrical test equipment on any circuit related to the SRS unless instructed to in this
Service Manual. SRS wiring harnesses can be identified by yellow and/or orange harnesses or
harness connectors.
Precautions for SRS “AIR BAG” and “SEAT BELT PRE-TENSIONER” Service
EHS001LJ
●
Do not use electrical test equipment to check SRS circuits unless instructed to in this Service Manual.
●
Before servicing the SRS, turn ignition switch OFF, disconnect both battery cables and wait at least 3 min-
utes.
For approximately 3 minutes after the cables are removed, it is still possible for the air bag and seat belt
pre-tensioner to deploy. Therefore, do not work on any SRS connectors or wires until at least 3 minutes
have passed.
●
The air bag diagnosis sensor unit must always be installed with the arrow mark “
⇐
” pointing toward the
front of the vehicle for proper operation. Also check the air bag diagnosis sensor unit for cracks, deformi-
ties or rust before installation and replace as required.
●
The spiral cable must be aligned with the neutral position since its rotations are limited. Do not attempt to
turn steering wheel or column after removal of steering gear.
●
Handle air bag module carefully. Always place driver and front passenger air bag modules with the pad
side facing upward and seat mounted front side air bag module standing with the stud bolt side facing
down.
●
Conduct self-diagnosis to check entire SRS for proper function after replacing any components.
●
After air bag inflates, the front instrument panel assembly should be replaced if damaged.
Occupant Classification System Precaution
EHS001LK
Replace control unit and passenger front seat cushion as an assembly.
SRS-4
PREPARATION
2006 Pathfinder
PREPARATION
PFP:00002
Special Service Tools
EHS001LM
The actual shapes of Kent-Moore tools may differ from those of special service tools illustrated here.
Tool number
(Kent-Moore No.)
Tool name
Description
—
(J-42057-UPD)
Air bag key set
Part of kit (J-42057)
Removing and installing air bag lock
LRS210
SUPPLEMENTAL RESTRAINT SYSTEM (SRS)
SRS-5
C
D
E
F
G
I
J
K
L
M
A
B
SRS
2006 Pathfinder
SUPPLEMENTAL RESTRAINT SYSTEM (SRS)
PFP:28556
SRS Configuration
EHS001LO
The air bag deploys if the air bag diagnosis sensor unit is activated while the ignition switch is in the ON or
START position.
The collision modes for which supplemental restraint systems are activated are different among the SRS sys-
tems. For example, the driver air bag module, front passenger air bag module and front seat belt pre-tension-
ers are activated in a frontal collision but not in a side collision.
SRS configurations for some collision modes are as follows:
WHIA0194E
SRS configuration
Frontal collision
Left side collision
Right side colli-
sion
Rollover
Driver air bag module
x
—
—
—
Front passenger air bag module
x
—
—
—
Front LH seat belt pre-tensioner
x
—
—
x
Front RH seat belt pre-tensioner
x
—
—
x
Front LH side air bag module (if equipped)
—
x
—
—
Front RH side air bag module (if equipped)
—
—
x
—
LH side front curtain air bag module (if equipped)
—
x
—
x
LH side rear curtain air bag module (if equipped)
—
x
—
x
RH side front curtain air bag module (if equipped)
—
—
x
x
RH side rear curtain air bag module (if equipped)
—
—
x
x
SRS-6
SUPPLEMENTAL RESTRAINT SYSTEM (SRS)
2006 Pathfinder
Front Seat Belt Pre-tensioner with Load Limiter
EHS001LP
The seat belt pre-tensioner system with load limiter is installed for
both the driver's seat and the front passenger's seat. It operates
simultaneously with the SRS air bag system in the event of a frontal
collision with an impact exceeding a specified level.
When the frontal collision with an impact exceeding a specified level
occurs, seat belt slack resulting from clothing or other factors is
immediately taken up by the pre-tensioner. Vehicle passengers are
securely restrained.
When passengers in a vehicle are thrown forward in a collision and
the restraining force of the seat belt exceeds a specified level, the
load limiter permits the specified extension of the seat belt by the
twisting of the ELR shaft, and a relaxation of the chest-area seat belt
web tension while maintaining force.
Front Side Air Bag
EHS001LQ
Front side air bag modules are built into the front seatback assemblies.
Vehicles with side air bags are equipped with labels as shown.
Side Curtain Air Bag
EHS001LR
Side curtain air bag modules are located above the vehicle headlining.
Vehicles with side curtain air bags are equipped with labels as
shown.
Occupant Classification System (OCS)
EHS001S8
The occupant classification system (OCS) identifies different size occupants, out of position occupants, and
detects if child seat is present in the front passenger seat. The OCS receives inputs from the occupant classi-
fication sensor (located inside the passenger seat cushion assembly) and belt tension sensor (part of the pas-
senger front seat belt assembly and located at the belt anchor location). Depending on classification of the
passenger, the OCS sends a signal to the air bag diagnosis sensor unit. The air bag diagnosis sensor unit
uses this signal and the seat belt buckle switch RH signal to determine deployment or non deployment of the
passenger front air bag in the event of a collision. Depending on the signals received, the air bag diagnosis
sensor unit can disable the passenger front air bag completely.
NOTE:
In case of customer concern, CONSULT-II can be used to confirm the passenger air bag status (readiness).
WHIA0225E
WHIA0008E
WHIA0041E
SUPPLEMENTAL RESTRAINT SYSTEM (SRS)
SRS-7
C
D
E
F
G
I
J
K
L
M
A
B
SRS
2006 Pathfinder
Passenger Air Bag Status Conditions
NOTE:
Passenger does not meet Occupant Classification System specifications for passenger air bag activation.
Direct-connect SRS Component Connectors
EHS001LT
The following SRS components use direct-connect style harness connectors.
●
Driver air bag module
●
Front passenger air bag module
●
LH side front curtain air bag module
●
LH side rear curtain air bag module
●
RH side front curtain air bag module
●
RH side rear curtain air bag module
●
Front LH seat belt pre-tensioner
●
Front RH seat belt pre-tensioner
Always pull up to release black locking tab prior to removing connector from SRS component.
Always push down to lock black locking tab after installing connector
to SRS component. When locked, the black locking tab is level with
the connector housing.
Front Passenger Seat
(Condition)
PASS AIR BAG OFF Indicator
(Status)
Passenger Air Bag Status
(Readiness)
CONSULT-II Display
Seat occupied
OFF
Active (enabled)
ON
Seat occupied
NOTE
ON
Deactivated (disabled)
OFF
Seat empty
OFF
Deactivated (disabled)
OFF
WHIA0195E
WHIA0103E
SRS-8
TROUBLE DIAGNOSIS
2006 Pathfinder
TROUBLE DIAGNOSIS
PFP:00004
Trouble Diagnosis Introduction
EHS001LU
CAUTION:
●
Do not use electrical test equipment on any circuit related to the SRS unless instructed to do so in
this Service Manual. SRS wiring harnesses can be identified by yellow and/or orange harness con-
nectors.
●
Do not attempt to repair, splice or modify SRS wiring harnesses. If a harness is damaged, replace
it with a new one.
●
Keep ground connections clean.
DIAGNOSIS FUNCTION
The SRS self-diagnosis results can be read by using “AIR BAG” warning lamp and/or CONSULT-II.
The User mode is exclusively prepared for the customer (driver). This mode warns the driver of a system mal-
function through the operation of the “AIR BAG” warning lamp.
The Diagnosis mode allows the technician to locate and inspect the malfunctioning part.
The mode applications for the “AIR BAG” warning lamp and CONSULT-II are as follows:
HOW TO PERFORM TROUBLE DIAGNOSES FOR QUICK AND ACCURATE REPAIR
A good understanding of the malfunction conditions can make troubleshooting faster and more accurate.
In general, each customer feels differently about a malfunction. It is important to fully understand the symp-
toms or conditions for a customer complaint.
Information From Customer
WHAT - Vehicle model
WHEN - Date, Frequencies
WHERE - Road conditions
HOW - Operating conditions, Symptoms
Preliminary Check
Check that the following parts are in good order.
●
Battery (Refer to
●
Fuse (Refer to
SRS-12, "Wiring Diagram — SRS —"
●
System component-to-harness connections
User mode
Diagnosis mode
Display type
“AIR BAG” warning lamp
X
X
ON-OFF operation
CONSULT-II
—
X
Monitoring
TROUBLE DIAGNOSIS
SRS-9
C
D
E
F
G
I
J
K
L
M
A
B
SRS
2006 Pathfinder
WORK FLOW
*1:
*2:
*3:
*4:
WHIA0098E
SRS-10
TROUBLE DIAGNOSIS
2006 Pathfinder
SRS Components Parts Location
EHS001LV
1.
Side curtain air bag modules
(If equipped)
2.
Front RH side air bag module
(If equipped)
3.
Front RH seat belt pre-tensioner
4.
Belt tension sensor
5.
Seat belt buckle switch RH
6.
RH side air bag (satellite) sensor
(If equipped)
7.
Occupant classification system sen-
sor
8.
Occupant classification sys-
tem control unit
9.
Front passenger air bag off indicator
10. Front passenger air bag module
11.
Crash zone sensor
12. Air bag warning lamp
13. Spiral cable
14. Driver air bag module
15. LH side air bag (satellite) sensor
(If equipped)
16. Front LH seat belt pre-tensioner
17. Air bag diagnosis sensor unit
18. Front LH side air bag module
(If equipped)
WHIA0196E
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст