Fiat Punto (2018 year). Manual — part 3

WARNING LIGHTS AND MESSAGES

IMPORTANT NOTES

IMPORTANT Warning lights are accompanied by a specific message and/or sound when implemented on the instrument panel.
These indications are indicative and precautionary and as such must not be considered as exhaustive and/or alternative to the
information contained in the Owner Handbook, which you are advised to read carefully in all cases. Always refer to the
information in this section in the event of a failure indication.

IMPORTANT The failure indicators appearing on the display are divided into two categories: very serious and less serious faults.
Serious faults are indicated by a repeated and prolonged warning "cycle". Less serious faults are indicated by a warning
"cycle" with a shorter duration. The display cycle of both categories can be interrupted by pressing the MENU/

button.

The instrument panel warning light will stay on until the cause of the malfunction is eliminated.

WARNING LIGHTS ON INSTRUMENT PANEL

Red warning lights

Warning light

What it means

SEAT BELTS NOT FASTENED

The warning light switches on constantly with the vehicle stationary and the driver’s seat belt not fastened. The

warning light will flash and a buzzer will sound if the car is in motion and the front seat belts are not correctly

fastened.

For permanent deactivation of the acoustic signal (buzzer) of the S.B.R. (Seat Belt Reminder) system contact a Fiat

Dealership. On some versions, the system can be reactivated from the Setup Menu.

40

KNOWING

THE

INSTRUMENT

P

ANEL

Warning light

What it means

DOORS/BONNET/LUGGAGE COMPARTMENT OPEN

On some versions, the warning light turns on along with a message and a symbol on the display, when one or more

doors, the bonnet or the tailgate are not properly closed. An acoustic signal is activated with the doors open and

the car moving.

LOW BRAKE FLUID/HANDBRAKE ENGAGED

When the ignition key is turned to MAR, the warning light switches on but should switch off after a few seconds.

Low brake fluid level: the warning light turns on when the level of the brake fluid in the reservoir falls below the

minimum level, possibly due to a leak in the circuit. On some versions, a message is shown on the display.

44)

Handbrake engaged

The warning light switches on when the handbrake is engaged. If the vehicle is moving a buzzer will also sound.

IMPORTANT If the warning light comes on when the vehicle is in motion, check that the handbrake is not on.

WARNING

44) If the

warning light comes on while driving, stop the car immediately and contact a Fiat Dealership.

41

Warning light

What it means

EBD FAILURE

If the

(red) and

(amber) warning lights come on simultaneously while the engine is running, it indicates

either a malfunction of the EBD system or that the system is not available. In this case, the rear wheels may

suddenly lock and the vehicle may swerve when braking sharply. On some versions, a message is shown on the

display. Drive very carefully to the nearest Fiat Dealership to have the system inspected immediately.

AIR BAG FAILURE

When the ignition key is turned to MAR, the warning light switches on but should switch off after a few seconds. If

the warning light switches on constantly, this indicates a fault in the airbag system. On some versions, a message is

shown on the display.

45) 46)

ENGINE OIL MINIMUM LEVEL (for versions/markets, where provided)

The warning light comes on when the ignition key is turned to MAR, but should go off after a few seconds. The

warning light comes on when the engine oil level falls below the minimum recommended value. Restore the correct

engine oil level. On some versions, a message is shown on the display.

WARNING

45) If, when turning the key to MAR, the

warning light does not switch on or if it stays on when travelling, there could be a fault in the

restraint systems; in this event airbags or pretensioners may not be deployed in the event of impact or, in a lower number of cases, they may
deploy accidentally. Contact a Fiat Dealership immediately to have the system checked.

46) A failure of the

warning light is indicated by the

warning light flashing. In this case, any faults of the airbag system might be not

signalled. Before continuing, contact a Fiat Dealership immediately to have the system checked.

42

KNOWING

THE

INSTRUMENT

P

ANEL

Warning light

What it means

LOW BATTERY CHARGE (For versions/markets, where provided)

The warning light comes on when the ignition key is turned to MAR, but it should go out as soon as the engine has

started (with the engine running at idle speed a brief delay before going out is acceptable). If the warning light stays

on constantly or flashing (on some versions along with a message on the display) contact a Fiat Dealership.

“DUALDRIVE" ELECTRIC POWER STEERING SYSTEM FAILURE (For versions/markets, where provided)

The warning light switches on when the ignition key is turned to MAR, but it should switch off after a few seconds.

If the warning light stays on (on some versions along with a message on the display) you may not have steering

assistance and the effort required to operate the steering wheel could be notably increased. However, steering is

possible. In this case, contact a Fiat Dealership. On some versions, a message is shown on the display.

INSUFFICIENT ENGINE OIL/PRESSURE: When the ignition key is turned to MAR the warning light switches on, but

should switch off as soon as the engine is started.

Insufficient engine oil pressure: the warning light switches on constantly (on some versions along with a

message on the display), when the system detects that engine oil pressure is insufficient.

47) 48)

WARNING

47) If the warning light comes on while driving (on some versions along with a message on the display), stop the engine immediately and
contact a Fiat Dealership.

48) After the warning light comes on, the degraded engine oil must be changed as soon as possible, and never more than 500 km from the
first time that the warning light comes on. Failure to observe the above may result in severe damage to the engine and invalidate the warranty.
Remember that the operation of this warning light is not related to the amount of oil in the engine. Therefore, never top up with oil when the
light starts flashing.

43

Warning light

What it means

Degraded engine oil (MultiJet versions with DPF)

The warning light comes on and flashes (on some versions along with a message on the display). Depending on

the versions, the warning light can flash: for 1 minute every 2 hours or for 3 minute cycles with the warning light off

for 5 seconds until the oil is changed. After the initial warning, each time the engine is started up, the warning light

will continue to flash in the same mode, until the oil is changed. On some versions, a message is shown on the

display.

The flashing of the warning light should not be considered as a fault, it simply informs the customer that the oil

needs to be changed following normal car use. On some versions, if the oil is not changed, when a second

degradation threshold is reached, the

instrument panel warning light also comes on and the engine is limited

to 3000 rpm operation. If the oil is still not changed, when a third deterioration threshold is reached, the engine is

limited to 1500 rpm to prevent damage.

Engine oil deterioration is accelerated by:

use of the vehicle mainly in town, which makes the DPF regeneration process more frequent;

use of the vehicle for short drives, in which the engine does not have time to reach its regular operating

temperature;

repeated interruptions to the regeneration process signalled by the DPF warning light coming on.

21)

WARNING

21) To prevent damaging the engine, it is advisable to change the engine oil when the warning light flashes. Contact a Fiat Dealership.

44

KNOWING

THE

INSTRUMENT

P

ANEL

Warning light

What it means

ENGINE COOLANT TEMPERATURE TOO HIGH

The warning light switches on when the ignition key is turned to MAR, but it should switch off after a few seconds.

The warning light comes on (on some versions along with a message on the display), when the engine has

overheated.

In normal driving conditions: stop the car, switch off the engine and check that the coolant level in the reservoir

is not below the MIN mark. In this case, wait for the engine to cool down, then slowly and carefully open the cap,

top up with coolant and check that the level is between the MIN and MAX marks on the reservoir itself. Also check

visually for any fluid leaks. If, when restarting, the warning light switches on again, contact a Fiat Dealership.

If the car is used under demanding conditions (e.g. towing trailers uphill or fully loaded): slow down and, if the

warning light stays on, stop the car. Wait for 2 or 3 minutes with the engine running and slightly accelerated to

further favour the coolant circulation. Then stop the engine. Check that the coolant level is correct as described

above. On some versions the display shows the dedicated message.

IMPORTANT Over demanding routes, it is advisable to keep the engine on and slightly accelerated for a few
minutes before switching it off.

45

Warning light

What it means

“DUALOGIC" GEARBOX FAULT (for versions/markets, where provided)

When the ignition key is turned to MAR, the warning light switches on but should switch off after a few seconds.

The warning light comes on flashing, along with a dedicated message on the display and an acoustic signal, to

indicate gearbox failure.

The following messages can also be displayed: reduce gear changes, manual mode not available, automatic mode

not available, clutch overheating, press the brake pedal - delayed starting, gear not available, manoeuvre not

allowed, press the brake pedal and repeat the manoeuvre, bringing the gear lever to N (neutral).

49)

22) 23)

WARNING

49) If the gearbox is faulty, contact a Fiat Dealership as soon as possible to have the system checked.

WARNING

22) If the messages continue to be shown in the display, contact a Fiat Dealership.

23) In order to safeguard the efficiency of the clutch, do not use the accelerator to keep the car stationary (e.g. when stopped on an incline); if
the clutch overheats it could damage it; use the brake pedal instead and only use the accelerator pedal when you decide to set off.

.

46

KNOWING

THE

INSTRUMENT

P

ANEL

Amber warning lights

Warning light

What it means

ABS FAILURE

The warning light switches on when the ignition key is turned to MAR, but it should switch off after a few seconds.

The warning light comes on, on some versions along with a message on the display, when the system is inefficient.

In this case the braking system maintains its efficiency unaltered but without the advantage of the ABS system.

Drive carefully and contact a Fiat Dealership as soon as possible.

PASSENGER SIDE AIRBAG DEACTIVATED

The warning light in the centre of the dashboard or, on some versions, on the instrument panel, comes on when the

front passenger side airbag is deactivated. With front passenger airbag on, when the ignition key is turned to MAR,

the warning light switches on constantly for several seconds and then it should switch off.

47

Warning light

What it means

INJECTION/EOBD SYSTEM FAILURE

In normal conditions, when the ignition key is turned to MAR the warning light switches on, but it should switch off

as soon as the engine is started. If the warning light stays on or comes on while driving, it indicates that the supply/

ignition system is not working correctly, causing possible loss of performance, high exhaust emissions, poor

driveability and high fuel consumption levels. On some versions the display shows the dedicated message. Under

these conditions, the vehicle can continue travelling at moderate speed without demanding excessive effort from

the engine. Prolonged use of the vehicle with the warning light on constantly may cause damage: contact a Fiat

Dealership as soon as possible. The warning light switches off if the malfunction disappears, but is still stored by

the system.

NOTE For petrol engines, if the warning light flashes, the catalytic converter may be damaged. In this case, it is

necessary to release the accelerator pedal to lower the speed of the engine until the warning light stops flashing;

continue the journey at moderate speed, trying to avoid driving conditions that may cause further flashing and

contact a Fiat Dealership as soon as possible.

24)

WARNING

24) If, when the ignition key is turned to MAR, the

warning light does not come on, comes on constantly or flashes while driving (on

some versions along with a message on the display), contact a Fiat Dealership as soon as possible. The operation of the

warning light

may be checked by the traffic police using specific devices. Comply with the laws and regulations of the country where you are driving.

48

KNOWING

THE

INSTRUMENT

P

ANEL

Warning light

What it means

ESC SYSTEM FAILURE

The warning light switches on when the ignition key is turned to MAR, but it should switch off after a few seconds.

If the warning light does not go off or stays on while driving (on some versions along with a message on the display)

contact a Fiat Dealership. Flashing of the warning light while driving indicates the intervention of the ESC system.

HILL HOLDER SYSTEM FAILURE (for versions/markets, where provided)

When the key is turned to MAR, the warning light comes on (on some versions along with a dedicated message on

the display) in the event of a Hill Holder system failure, but it should go off after a few seconds. In this case, contact

a Fiat Dealership as soon as possible. On some versions, the

warning light comes on instead.

FIAT CODE SYSTEM FAILURE (for versions/markets, where provided)

The warning light comes on (on some versions along with a dedicated message on the display) to indicate a Fiat

CODE system failure or an alarm system failure, if present. Contact a Fiat Dealership as soon as possible.

GLOW PLUG HEATING/GLOW PLUG HEATING FAILURE (Multijet versions)

Glow plug pre-heating: this warning light comes on when the key is turned to MAR and should go off as soon as

the heater plugs have reached a preset temperature. The engine can be started as soon as the warning light

switches off.

IMPORTANT At ambient or high temperatures, the warning light may stay on for an extremely short time.

Glow plug pre-heating failure: the warning light will flash, on some versions along with a dedicated message on

the display, to indicate a fault in the glow plug pre-heating system. Contact a Fiat Dealership as soon as possible.

49

Warning light

What it means

DPF CLEANING (PARTICULATE TRAP) IN PROGRESS (Multijet versions with DPF only)

When the ignition key is turned to MAR, the warning light switches on but should switch off after a few seconds.

The warning light switches on constantly, on some versions along with a dedicated message on the display, to

notify the driver that the DPF system needs to eliminate captured pollutants (particulate) through the regeneration

process.

The warning light does not come on every time the DPF is being regenerated, rather only when the driving

conditions are such that the driver needs to know it. To switch the warning light off, the vehicle must be kept

moving until the regeneration process is completed. On average, the process lasts 15 minutes. Optimal conditions

for completing the process are achieved by travelling at 60 km/h with engine speed above 2000 rpm. If this light

switches on, it does not mean that the vehicle is defective, so there is no need to take it to a workshop.

50)

WARNING

50) The driving speed must always be suitable for traffic and weather conditions and the driver must always comply with the Highway Code.
The engine can also be switched off if the DPF warning light is on; nevertheless, repeated interruptions of the regeneration process could
cause an early deterioration of engine oil. For this reason, always wait until the warning light switches off before stopping the engine as
described above. Do not complete the DPF regeneration process when the vehicle is stopped.

50

KNOWING

THE

INSTRUMENT

P

ANEL

Warning light

What it means

GENERAL FAILURE WARNING (for versions/markets, where provided)

The warning light comes on in the following circumstances (in which case contact a Fiat Dealership to have the fault

fixed as soon as possible):

Limit speed exceeded: the warning light comes on when the set speed limit is exceeded and the display shows a

dedicated message.

Fuel cut-off activated: this warning light comes on (on some versions along with a message on the display) in the

event of a fuel cut-off system intervention/failure.

Stop&Start failure: the warning light comes on when a failure is detected in the Stop&Start system (on some

versions along with a message on the display and the

icon coming on).

Parking sensor failure: the warning light comes on (on some versions along with a dedicated message on the

display) when a fault is detected in the parking sensors. Contact a Fiat Dealership as soon as possible.

Engine oil pressure sensor failure: an engine oil pressure sensor failure is indicated by the warning light coming

on (along with a message on the display, for versions where provided). Contact a Fiat Dealership as soon as

possible.

iTPMS system failure: the warning light comes on (on some versions along with a dedicated message on the

display) when a Tyre Pressure Monitoring Sensor (iTPMS) malfunction is detected. Contact a Fiat Dealership as

soon as possible. If there are one or more wheels without sensors, the instrument panel warning light will come on

and stay on until initial conditions are restored.

Rain sensor failure: the warning light comes on (on some versions along with a message on the display) when a

rain sensor malfunction is detected. Contact a Fiat Dealership as soon as possible

Warning light failure

: the

warning light comes on and flashes in the event of an “airbag failure” warning

light failure.

51

Warning light

What it means

PARKING SENSOR FAILURE (for versions/markets, where provided)

The warning light comes on (on some versions along with a message on the display) when a failure is detected in

the parking sensors (on some versions the

warning light comes on instead). At ambient or high temperatures,

the warning light may stay on for an extremely short time.

WATER IN DIESEL FILTER (Multijet versions)

The warning light switches on when the ignition key is turned to MAR, but it should switch off after a few seconds.

The warning light comes on if there is water in the diesel filter (on some versions along with a message in the

display).

25)

EXTERNAL LIGHTS FAILURE (for versions/markets, where provided)

The warning light comes on in the event of failure of one of the following lights: side lights, brake lights, rear fog

lights, direction indicators, number plate lights and daytime running lights (DRL). On some versions, the

warning light comes on instead and the display shows a dedicated message.

BRAKE PAD WEAR (for versions/markets, where provided)

The warning light comes on (on some versions along with a message on the display) if the front brake pads are

worn. In this case, change them as soon as possible.

FUEL RESERVE

The warning light switches on when about 7 litres of fuel are left in the tank.

IMPORTANT The warning light will flash while driving to indicate a system failure. If this is the case, go to a Fiat
Dealership to have the system checked.

52

KNOWING

THE

INSTRUMENT

P

ANEL

WARNING

25) The presence of water in the supply circuit may severely damage the injection system and cause irregular engine operation. If the warning
light comes on (on some versions along with a message on the display), contact a Fiat Dealership as soon as possible to have the system
bled. If the above indication occurs immediately after refuelling, water may have entered the tank: turn the engine off immediately and contact
a Fiat Dealership.

53

Warning light

What it means

iTPMS (for versions/markets where provided)

Low tyre pressure : The warning light switches on constantly to indicate that the tyre pressure is lower than the

recommended value, in order to guarantee long tyre life and low fuel consumption, or to indicate a slow loss of

pressure. In this way the iTPMS warns the driver that one or more tyres may be flat and probably punctured. In this

case it is advisable to restore the correct pressure value. Once the normal operating conditions of the vehicle are

restored, carry out the Reset procedure.

IMPORTANT Do not continue driving with one or more flat tyres as handling may be compromised. Stop the
vehicle, avoiding sharp braking and steering.

iTPMS failure/iTPMS temporarily deactivated: The warning light flashes for about 75 seconds and then stays

on constantly (along with a dedicated message on the display) to indicate that the system is temporarily

deactivated or faulty. The system goes back to normal operation when the operating conditions allow it. If this is not

the case, carry out the Tyre reset procedure after restoring the normal operating conditions. If the malfunction

warning persists, contact a Fiat Dealership as soon as possible.

REAR FOG LIGHT

The warning light switches on when the rear fog light is activated.

54

KNOWING

THE

INSTRUMENT

P

ANEL

Green warning lights

Warning light

What it means

“DUALDRIVE" ELECTRIC POWER STEERING SYSTEM ACTIVATION (for versions/markets, where provided)

The indication CITY comes on when the "Dualdrive" electric power steering system is activated by pressing the

button on the dashboard. The CITY indication goes off when the button is pressed again. On some versions, the

activation/deactivation of the electric power steering is indicated by a message shown on the display.

CRUISE CONTROL (for versions/markets, where provided)

The warning light switches on when the ignition key is turned to MAR, but it should switch off after a few seconds.

The warning light comes on when the Cruise Control ring nut is turned to ON. On certain versions a dedicated

message is displayed.

FRONT FOG LIGHTS

The warning light comes on when the front fog lights are turned on.

SIDE LIGHTS AND DIPPED BEAM HEADLIGHTS/FOLLOW ME HOME

Side lights and dipped beam headlights: the warning light comes on when the side lights or the dipped beam

headlights are activated.

Follow me home: the warning light comes on, on some versions along with a message on the display, when the

"Follow me home" device is used.

LEFT DIRECTION INDICATOR

The warning light comes on when the direction indicator control stalk is moved downwards or, together with the

right direction indicator, when the hazard warning light button is pressed.

RIGHT DIRECTION INDICATOR

The warning light comes on when the direction indicator control stalk is moved upwards or, together with the left

direction indicator, when the hazard warning light button is pressed.

55