Kia Carnival (2007 year). Manual — part 575
2007 > 3.8L V6 GASOLINE >
TROUBLE SYMPTOM CHARTS
TROUBLE SYMPTOM 1
TROUBLE SYMPTOM 2
Trouble symptom
Probable cause
Remedy
The set vehicle speed varies greatly
upward or downward
"Surging" (repeated alternating
acceleration and deceleration) occurs
after setting
Malfunction of the vehicle speed
sensor circuit
Repair the vehicle speed sensor
system, or replace the part
Malfunction of ECM
Replace the ECM
TROUBLE SYMPTOM 3
Trouble symptom
Probable cause
Remedy
The CC system is not canceled when
the brake pedal is depressed
Damaged or disconnected wiring of
the brake pedal switch
Repair the harness or replace the
brake pedal switch
Malfunction of the ECM
Replace the ECM
TROUBLE SYMPTOM 4
Trouble symptom
Probable cause
Remedy
The CC system is not canceled when
the shift lever is moved to the "N"
Damaged or disconnected wiring of
inhibitor switch input circuit
Repair the harness or repair or
replace the inhibitor switch
the shift lever is moved to the "N"
position (It is canceled, however,
when the brake pedal is depressed
replace the inhibitor switch
Improper adjustment of inhibitor
switch
Malfunction of the ECM
Replace the ECM
TROUBLE SYMPTOM 5
Trouble symptom
Probable cause
Remedy
Cannot decelerate (coast) by using
the SET switch
Temporary damaged or disconnected
wiring of SET switch input circuit
Repair the harness or replace the
SET switch
Malfunction of the ECM
Replace the ECM
TROUBLE SYMPTOM 6
Trouble symptom
Probable cause
Remedy
Cannot accelerate or resume speed
by using the RESUME switch
Damaged or disconnected wiring, or
short circuit, or RESUME switch input
circuit
Repair the harness or replace the
RESUME switch
Malfunction of the ECM
Replace the ECM
TROUBLE SYMPTOM 7
Trouble symptom
Probable cause
Remedy
CC system can be set while driving at
a vehicle speed of less than 40km/h
(25mph), or there is no automatic
cancellation at that speed
Malfunction of the vehicle-speed
sensor circuit
Repair the vehicle speed sensor
system, or replace the part
Malfunction of the ECM
Replace the ECM
TROUBLE SYMPTOM 8
Trouble symptom
Probable cause
Remedy
The cruise main switch indicator lamp
does not illuminate (But CC system is
normal)
Damaged or disconnected bulb of
cruise main switch indicator lamp
Repair the harness or replace the
part.
Harness damaged or disconnected
2007 > 3.8L V6 GASOLINE >
CIRCUIT DIAGRAM
2007 > 3.8L V6 GASOLINE >
REMOVAL
1. Disconnect the battery (-) terminal.
2. Remove the driver side air bag module. (Refer to RT GR.)
3. Disconnect the cruise control switch connector and then remove the cruise control switch(A) with two screws.
4. Installation is the reverse of removal.
INSPECTION
MEASURING RESISTANCE
1. Disconnect the cruise control switch connector from the control switch.
2. Measure resistance between terminals on the control switch when each function switch is ON (switch is
depressed).
Function switch
Terminal
Resistance
Cruise Main
RH 1-2
3.9kΩ ± 1%
Cancel
RH 1-3
0Ω ± 1%
Set/Coast
RH 1-3
220Ω ± 1%
Resume/Accel
RH 1-3
910Ω ± 1%
3. If not within specification, replace switch.
MEASURING VOLTAGE
1. Connect the cruise control switch connector to the control switch.
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст