Kia Carens. Manual — part 194
2001 > 1.8L DOHC >
Mechanical specifications
Item
Specifications
Driver air bag installation bolts
69~104 lb-in (8~12 N·m, 80~120 kg-cm)
Passenger air bag installation bolts
69~104 lb-in (8~12 N·m, 80~120 kg-cm)
Steering wheel installation nut
29~36 lb-ft (39~49 N·m, 4.0~5.0 kg-m)
ADU installation nuts
69~120 lb-in (8~14 N·m, 80~140 kg-cm)
Connector pin
No.
Description
No.
Description
1
-
16
Short bar (harness side)
2
-
17
Short bar (harness side)
3
-
18
Short bar (harness side)
4
-
19
Short bar (harness side)
5
Supply Power (IG1) +
20
-
6
Ground (Air bag warning light LOW)
21
Short bar (harness side)
7
Air bag warning light
22
Short bar (harness side)
8
-
23
-
9
Communication (K-line)
24
-
10
Driver air bag module +
25
Short bar (harness side)
11
Driver air bag module -
26
Short bar (harness side)
12
-
27
-
13
Passenger air bag module +
28
Short bar (harness side)
14
Passenger air bag module -
29
Short bar (harness side)
15
-
30
-
*There is a short bar between terminal 6 and 7.
Restraint
Supplemental Restraint System Control Module
(SRnodeM)
Restraint
2001 > 1.8L DOHC >
Air bag diagnostic trouble code (DTC) chart
Diagnostic
Trouble
Code
Fault Description
Possible Cause
Warning
Light
Mode
Corrective Action
01~03
10~15
ADU Fault
Internal Fault
1
Replace Air Bag Diagnostic
Unit (ADU)
18~29
31~32
ADU Fault
Internal Fault
1
Replace Air Bag Diagnostic
Unit (ADU)
33
Power Supply Low
Power supply voltage below
8.0 volts
5
Repair or replace battery or
harness
34
Power Supply High
Power supply High voltage
above 16 volts
5
Repair or replace battery or
harness harness
35
Warning Light Short
Warning Light damaged, or
short circuit in harness
5
Repair or replace warning
light or harness
36
Warning Light Open
Driver Module damaged, or
circuit shorted to ground
5
Repair or replace warning
light or harness
53
Driver Module Short to
ground
Driver Module damaged, or
circuit shorted to battery
5
Repair or replace warning
light or harness
54
Driver Module Short to
battery
Driver Module damaged, or
circuit shorted to harness
5
Repair or replace warning
light or harness
55
Driver Module Short
Driver Module damaged, or
circuit shorted to harness
5
Repair or replace warning
light or harness
56
Driver Module Open
Driver Moudule damaged, or
circuit shorted to harness
5
Repair or replace warning
light or harness
57
Passenger Module
Short to ground
Passenger Module damaged,
or circuit shorted to ground
5
Repair or replace warning
light or harness
58
Passenger Module
Short to battery
Passenger Module damaged,
or circuit shorted to battery
5
Repair or replace warning
light or harness
59
Passenger Module
Short
Passenger Module damaged,
or circuit shorted to harness
5
Repair or replace warning
light or harness
60
Passenger Module
Open
Passenger Module damaged,
or circuit shorted to harness
5
Repair or replace warning
light or harness
78
ADU
Inconsistency(exclusive
of PAB)
ADU unmatching, PAB
Installed in DAB-only ADU
vehicle
5
Replace Air Bag Diagnostic
Unit (ADU)
Warning light operating modes:
Mode 1 : Warning Light be illuminated for reminder ON cycle, but it will not be illuminated after next ignition ON
cycle if fault has self-corrected.
Mode 5 : Warning Light will be illuminated for reminder of ignition ON cycle, but it will go out approximately 10
seconds later if fault has corrected at the same ignition ON cycle.
Air bag diagnostic trouble code troubleshooting
SERVICING AIR BAG SYSTEM INPROPERLY MAY CAUSE IT TO DEPLOY, WHICH CAUSE SERIOUS
INJURY OR DEATH.MUST READ AND FOLLOW ALL SERVICE WARNINGS, BEFORE SERVICING.
Never service wiring or electrical components when air bag is connected.
Air bag diagnostic trouble code erasure
Disconnecting battery will not erase Air Bag Diagnostic Trouble Codes. This procedures can only be
performed using Hi-Scan Pro tool equipped with appropriate software.
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст