Suzuki Grand Vitara JB416 / JB420 / JB419. Manual — part 84
1A-283 Engine General Information and Diagnosis: For Diesel Engine Model
P0403
EGR Control Circuit
• EGR valve actuator circuit shorted to ground
circuit
• EGR valve actuator circuit open or shorted to
power circuit
P0409
EGR Motor Malfunction
• Excessive or insufficient EGR flow
• Poor performance of EGR valve
P0470*
Differential Pressure Sensor Circuit*
• Differential pressure sensor circuit shorted to
ground circuit
• Differential pressure sensor circuit open or
shorted to power circuit
• Poor performance of differential pressure sensor
P0480
Radiator Fan Low Control Circuit
Radiator fan relay No.1 control circuit low or high
input
P0481
Radiator Fan High Control Circuit
Radiator fan relay No.2 and No.3 control circuit low
or high input
P0486
EGR Stroke Sensor Circuit
EGR stroke sensor signal low or high input
P0500
VSS Malfunction
• Vehicle speed signal not inputted or incorrect
signal inputted
• Receiving error on CAN communication from
other control module
P0530
A/C Refrigerant Pressure Sensor Circuit
A/C refrigerant pressure sensor signal circuit low or
high input
P0544*
Exhaust Gas Temperature Sensor 3 Circuit*
• Exhaust gas temperature sensor 3 circuit
shorted to ground circuit
• Exhaust gas temperature sensor 3 circuit open
or shorted to power circuit
P0560
System Voltage
Power supply low or high input
P0571
Brake Light Switch Circuit
Brake pedal switch signal (Brake switch 2) is
inconsistent with stop light switch signal (Brake
switch 1).
P0575
Cruise Control Input Circuit
Inconsistent signal inputted
P0606
ECM Processor
Engine control module internal faulty (system error)
P0611
ECM Performance
• Poor performance of ECM
• IMA codes is not entered or erroneous
P0615
Ignition Switch Circuit
Power supply from ignition switch low or high input
P0627
Fuel Pump Control Circuit
Fuel pump relay control circuit low or high input
P0638
Inlet Throttle Valve Control Range/
Performance
• Inlet throttle valve actuator circuit shorted to
ground circuit
• Inlet throttle valve actuator circuit open or
shorted to power circuit
• Inlet throttle valve position signal low or high
input
P0641
Sensor Reference Voltage 1 Circuit
Sensor power source voltage is too high or too low
from ECM (Accelerator pedal position (APP) sensor
(main), boost pressure sensor, differential pressure
sensor)
P0645
A/C Compressor Relay Control Circuit
A/C compressor relay control circuit low or high
input
P0651
Sensor Reference Voltage 2 circuit
Sensor power source voltage is too high or too low
from ECM (Accelerator pedal position (APP) sensor
(sub), EGR stroke sensor)
P0670
Glow Plug Control Circuit
Detection an error of pre-heating control or glow
plug failure
DTC No.
(SUZUKI scan
tool)
Detecting Item
Detecting Condition
(DTC will set when detecting:)
Engine General Information and Diagnosis: For Diesel Engine Model 1A-284
P0685
Main Relay Control Circuit
Monitor signal of main relay is different from
command signal.
P0697
Sensor Reference Voltage 3 circuit
Sensor power source voltage is too high or too low
from ECM (Fuel pressure sensor, MAF)
P0830
CPP Switch Circuit
Poor performance of CPP switch
P1431*
Clogged Diesel Particulate Filter Failures* Diesel particulate filter clogged
P1436*
Diesel Particulate Filter Regeneration
Request Failures*
This DTC indicates whether a specific running
request has been made in order to prompt a
particulate filter regeneration.
P1480*
Upstream Side Differential Pressure Sensor
Failure*
Clog diesel particulate filter upstream side pipe of
differential pressure sensor
P1641
Additional Heater Relay No.1 Control
Circuit
Additional heater relay No.1 control circuit low or
high input
P1642
Additional Heater Relay No.2, 3 Control
Circuit
Additional heater relay No.2 and 3 control circuit
low or high input
P2002*
Diesel Particulate Filter Efficiency Below
Threshold*
• Differential pressure sensor signal out of
specification
Exhaust Gas Temperature Sensor 2 Circuit*
• Exhaust gas temperature sensor 2 circuit
shorted to ground circuit
• Exhaust gas temperature sensor 2 circuit open
or shorted to power circuit
P2120
APP Sensor (Sub) Circuit
• Accelerator pedal position (APP) sensor (sub)
circuit shorted to ground circuit
• Accelerator pedal position (APP) sensor (sub)
circuit open or shorted to power circuit
• Poor performance of Accelerator pedal position
(APP) sensor (sub)
P2141
EGR Motor Control Circuit Low
EGR valve out of tolerance or inoperative
P2142
EGR Motor Control Circuit High
EGR valve out of tolerance or inoperative
P2264
Fuel Filter Water Detection Sensor Circuit
• Fuel filter water detection sensor circuit open or
short
• Fuel filter water detection sensor detects water in
fuel filter
P2413
EGR System Performance
• Excessive EGR flow
• Poor performance of EGR valve
P242A
Exhaust Gas Temperature Sensor 1 Circuit
• Exhaust gas temperature sensor 1 circuit
shorted to ground circuit
• Exhaust gas temperature sensor 1 circuit open
or shorted to power circuit
P242B
Exhaust Gas Temperature Sensor 1
Regulation Failure
Exhaust gas temperature sensor 1 signal too high
input
P2600
Turbocharger Electric Water Pump Control
Circuit
Turbocharger electric water pump relay control
circuit low or high input
P3031*
Exhaust Gas Temperature Sensor 2
Threshold Overshoot Failures During After-
sales Regeneration*
The exhaust gas temperature sensor 2 detects
over 700
°C, 1292 °F while the after-sales
regeneration was in progress.
DTC No.
(SUZUKI scan
tool)
Detecting Item
Detecting Condition
(DTC will set when detecting:)
1A-285 Engine General Information and Diagnosis: For Diesel Engine Model
Indicator Light Operation Table
S6JB0A1124008
NOTE
• For vehicle without diesel particulate filter, DTCs with asterisk (*) in table below are not detected.
• For indicator / warning light operation of items with asterisks (**), refer to corresponding Faulty
Finding – Fault Interpretation in this section.
• “–” marked in above table indicates that indicator / warning light does not light.
DTC No. (SUZUKI
scan tool)
Detecting Item
Malfunction
Indicator
Lamp (MIL)
Injection
Warning Light
(Gravity 1 Fault)
Red Stop
Warning Light
(Gravity 2 Fault)
P0016
CKP – CMP Correlation
—
—
—
P0033
Boost Pressure Control Solenoid Valve
Control Circuit
**3 driving
cycles
**1 driving cycle
—
P0089
Fuel Flow Actuator Performance
—
**1 driving cycle **1 driving cycle
P0100
Mass or Volume Air Flow Circuit
—
1 driving cycle
—
P0105
Barometric Pressure Circuit
—
1 driving cycle
—
IAT Sensor Circuit
—
1 driving cycle
—
ECT Circuit
—
1 driving cycle
—
P0190
Fuel Pressure Sensor Circuit
—
—
1 driving cycle
P0201
Fuel Injector No.1 Circuit
**3 driving
cycles
**1 driving cycle **1 driving cycle
P0202
Fuel Injector No.2 Circuit
**3 driving
cycles
**1 driving cycle **1 driving cycle
P0203
Fuel Injector No.3 Circuit
**3 driving
cycles
**1 driving cycle **1 driving cycle
P0204
Fuel Injector No.4 Circuit
**3 driving
cycles
**1 driving cycle **1 driving cycle
P0225
APP Sensor (Main) Circuit
—
1 driving cycle
—
P0235
Boost Pressure Sensor “A” Circuit
—
1 driving cycle
—
P0243
Boost Pressure Malfunction
—
1 driving cycle
—
P0297
Vehicle Overspeed Condition
—
—
—
P0301
Cylinder No.1 Misfire Detected
—
—
—
P0302
Cylinder No.2 Misfire Detected
—
—
—
P0303
Cylinder No.3 Misfire Detected
—
—
—
P0304
Cylinder No.4 Misfire Detected
—
—
—
P0335
CKP Sensor Circuit
—
—
1 driving cycle
P0340
CMP Sensor Circuit
—
1 driving cycle
—
P0380
Glow Plug Control Module Circuit
—
1 driving cycle
—
P0403
EGR Control Circuit
—
**1 driving cycle
—
P0409
EGR Motor Malfunction
—
**1 driving cycle
—
P0470
Differential Pressure Sensor CIrcuit*
**1 driving
cycle
1 driving cycle
—
P0480
Radiator Fan Low Control Circuit
—
—
—
P0481
Radiator Fan High Control Circuit
—
—
—
P0486
EGR Stroke Sensor Circuit
1 driving cycle
—
—
P0500
VSS Malfunction
—
—
—
P0530
A/C Refrigerant Pressure Sensor Circuit
—
—
—
P0544*
Exhaust Gas Temperature Sensor 3 Circuit*
—
—
—
P0560
System Voltage
—
—
—
P0571
Brake Light Switch Circuit
—
—
—
P0575
Cruise Control Input Circuit
—
—
—
P0606
ECM Processor
**3 driving
cycles
**1 driving cycle **1 driving cycle
ECM Performance
—
1 driving cycle
—
P0615
Ignition Switch Circuit
—
—
—
P0627
Fuel Pump Control Circuit
—
—
—
P0638
Inlet Throttle Valve Control Range/
Performance
—
1 driving cycle
—
Engine General Information and Diagnosis: For Diesel Engine Model 1A-286
P0641
Sensor Reference Voltage 1 Circuit
—
1 driving cycle
—
P0645
A/C Compressor Relay Control Circuit
—
—
—
P0651
Sensor Reference Voltage 2 Circuit
**3 driving
cycles
**1 driving cycle
—
P0670
Glow Plug Control Circuit
—
1 driving cycle
—
P0685
Main Relay Control Circuit
—
1 driving cycle
—
P0697
Sensor Reference Voltage 3 Circuit
—
—
1 driving cycle
P0830
CPP Switch Circuit
—
—
—
P1431*
Clogged Diesel Particulate Filter Failures*
—
1 driving cycle
—
P1436*
Diesel Particulate Filter Regeneration
Request failures*
—
—
—
P1480*
Upstream Side Differential Pressure Sensor
Failure*
—
1 driving cycle
—
P1641
Additional Heater Relay No.1 Control
Circuit
—
—
—
P1642
Additional Heater Relay No.2, 3 Control
Circuit
—
—
—
P2002*
Diesel Particulate Filter Efficiency Below
Threshold*
1 driving cycle
1 driving cycle
—
Exhaust Gas Temperature Sensor 2 Circuit*
—
1 driving cycle
—
P2120
APP Sensor (Sub) Circuit
—
1 driving cycle
—
P2141
EGR Motor Control Circuit Low
—
1 driving cycle
—
P2142
EGR Motor Control Circuit High
—
1 driving cycle
—
P2264
Fuel Filter Water Detection Sensor Circuit
—
—
—
P2413
EGR System Performance
**3 driving
cycles
P242A
Exhaust Gas Temperature Sensor 1 Circuit 1 driving cycle
1 driving cycle
—
P242B
Exhaust Gas Temperature Sensor 1
Regulation Failure
—
1 driving cycle
—
P2600
Turbocharger Electric Water Pump Control
circuit
—
1 driving cycle
—
P3031*
Exhaust Gas Temperature Sensor 2
Threshold Overshoot Failures During After-
sales Regeneration*
—
—
—
DTC No. (SUZUKI
scan tool)
Detecting Item
Malfunction
Indicator
Lamp (MIL)
Injection
Warning Light
(Gravity 1 Fault)
Red Stop
Warning Light
(Gravity 2 Fault)
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст