Toyota Tundra. Manual — part 2834
MONITOR DESCRIPTION
These DTCs indicate an open or short in the shift solenoid valve S4 circuit. When there is an open or short
circuit in any shift solenoid valve circuit, the ECM detects the problem, illuminates the MIL and stores the
DTC. When the shift solenoid valve S4 is ON, if its resistance is 8 ohms or less, the ECM determines there is a
short in the shift solenoid valve S4 circuit.
When the shift solenoid valve S4 is OFF, if its resistance is 100 kohms or more, the ECM determines there is an
open in the shift solenoid valve S4 circuit (see FAIL-SAFE TABLE ).
MONITOR STRATEGY
MONITOR STRATEGY TABLE
TYPICAL ENABLING CONDITIONS
All
TYPICAL ENABLING CONDITIONS TABLE
P0982: Range Check (Low Resistance)
TYPICAL ENABLING CONDITIONS TABLE
P0983: Range Check (High Resistance)
TYPICAL ENABLING CONDITIONS TABLE
TYPICAL MALFUNCTION THRESHOLDS
Related DTCs
P0982: Shift solenoid valve S4/Range check (Low
resistance)
P0983: Shift solenoid valve S4/Range check (High
resistance)
Required sensors/Components
Shift solenoid valve S4
Frequency of operation
Continuous
Duration
0.128 sec. or more
MIL operation
Immediately
Sequence of operation
None
The monitor will run whenever the following DTCs are not
present
None
Battery voltage
8 V or higher
Ignition switch
ON
Starter
OFF
Shift solenoid valve S4
ON
Shift solenoid valve S4
OFF
2009 Toyota Tundra
2009 TRANSMISSION AB60F Automatic Transaxle - Tundra
P0982: Range Check (Low Resistance)
TYPICAL MALFUNCTION THRESHOLDS TABLE
P0983: Range Check (High Resistance)
TYPICAL MALFUNCTION THRESHOLDS TABLE
COMPONENT OPERATING RANGE
COMPONENT OPERATING RANGE TABLE
WIRING DIAGRAM
Fig. 95: Identifying Shift Solenoid Valve S4 - Wiring Diagram
Courtesy of TOYOTA MOTOR SALES, U.S.A., INC.
INSPECTION PROCEDURE
HINT:
The shift solenoid valve S4 is turned ON/OFF normally when the shift lever is on D:
SHIFT SOLENOID VALVE S4 REFERENCE TABLE
1. INSPECT NO. 1 TRANSMISSION WIRE (SHIFT SOLENOID VALVE S4)
Shift solenoid valve S4 resistance
8 ohms or less
Shift solenoid valve S4 resistance
100 kohms or higher
Shift solenoid valve S4 resistance
11 to 15 ohms at 20°C (68°F)
ECM gear shift command
1st
2nd
3rd
4th
5th
6th
Shift solenoid valve S4
OFF
OFF
OFF
OFF
ON
ON
2009 Toyota Tundra
2009 TRANSMISSION AB60F Automatic Transaxle - Tundra
a. Disconnect the D63 No. 1 transmission wire connector.
b. Measure the resistance according to the value (s) in the table below.
Standard resistance
TESTER CONNECTION SPECIFIED CONDITION TABLE
Fig. 96: Identifying D63 No. 1 Transmission Wire Connector Terminals
Courtesy of TOYOTA MOTOR SALES, U.S.A., INC.
NG: Go to step 3
2. CHECK HARNESS AND CONNECTOR (NO. 1 TRANSMISSION WIRE - ECM)
a. Disconnect the D74 ECM connector.
b. Measure the resistance according to the value (s) in the table below.
Standard resistance
TESTER CONNECTION SPECIFIED CONDITION TABLE
Result
Tester Connection
Condition
Specified
Condition
14 (S4) - Body ground
20°C (68°F)
11 to 15 ohms
Tester Connection
Condition
Specified
Condition
D74-5 (S4) - Body
ground
20°C (68°F)
11 to 15 ohms
Result
Proceed To
NG
A
2009 Toyota Tundra
2009 TRANSMISSION AB60F Automatic Transaxle - Tundra
Fig. 97: Identifying D74 ECM Connector Terminals
Courtesy of TOYOTA MOTOR SALES, U.S.A., INC.
NG: REPAIR OR REPLACE HARNESS OR CONNECTOR
B: OK (for 3UR-FE) (See REMOVAL )
C: OK (for 3UR-FBE) (See REMOVAL )
3. INSPECT SHIFT SOLENOID VALVE S4
a. Remove shift solenoid valve S4.
b. Measure the resistance according to the value (s) in the table below.
Standard resistance
TESTER CONNECTION SPECIFIED CONDITION TABLE
c. Connect the battery's positive (+) lead to the terminal of the solenoid valve connector, and the
negative (-) lead to the solenoid valve body. Then check that the valve moves and makes an
operating noise.
OK: Valve moves and makes an operating noise.
OK (for 3UR-FE)
B
OK (for 3UR-FBE)
C
Tester Connection
Condition
Specified
Condition
Shift solenoid valve S4 connector terminal - Shift solenoid valve
S4 body
20°C (68°
F)
11 to 15 ohms
2009 Toyota Tundra
2009 TRANSMISSION AB60F Automatic Transaxle - Tundra
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст