Ford F-650 / 750 (2023 year). Manual in english — page 21

Other Maintenance Items

1

Note: When adding coolant additive, do not exceed the
specified maximum of 47 fl oz (1.4 L) for the engine and
20 fl oz (473 ml) for the secondary cooling system. Oper-
ating the engine with excessive coolant additive may cause
overheating which could lead to severe, permanent engine
damage.

Replace the air inlet foam filter.

Every 45,000 mi
(72,000 km)

Inspect the accessory drive belt or belts.

4

At 90,000 mi
(144,000 km)

Change the rear axle fluid. See

Special Operating

Conditions Scheduled Maintenance

(page 329).

5

At 100,000 mi
(160,000 km)

Change the automatic transmission fluid and filter. Consult
an authorized dealer for requirements.

Every 150,000 mi
(240,000 km)

Replace the accessory drive belt or belts if not replaced
within the last 100,000 mi (160,000 km).

Replace the front wheel bearings and seals.

Change the engine and secondary cooling system coolant.

6

At 200,000 mi
(320,000 km)

1

You can perform these maintenance items within 3,000 mi (4,800 km) of the last oil

change. Do not exceed the designated distance for the interval.

2

Every 22,000 mi (36,000 km) or as indicated by the information display.

3

Every 30,000 mi (48,000 km), 1200 engine hours or as indicated by the information

display.

4

Perform follow-up inspections every 15,000 mi (24,000 km) after the initial inspection.

Replace the belt or belts at 150,000 mi (240,000 km).

5

Change the fluid again at 150,000 mi (240,000 km).

6

Initial replacement at 10 years or 200,000 mi (320,000 km), then every five years or

100,000 mi (160,000 km).

328

Scheduled Maintenance

SPECIAL OPERATING
CONDITIONS SCHEDULED
MAINTENANCE

Gasoline Engines

If you operate your vehicle

primarily

in any

of the following conditions, you need to
perform extra maintenance as indicated.
If you operate your vehicle

occasionally

under any of these conditions, it is not
necessary to perform the extra
maintenance. For specific
recommendations, see your dealership
service advisor or technician.

Towing a Trailer

Inspect and lubricate the U-joints.

Inspect frequently, service
as required

See axle maintenance items under

Exceptions

.

Inspect the wheels and related components for abnormal
noise, wear, looseness or drag.

Every 5,000 mi (8,000 km)

Change the engine oil and filter.

Every 5,000 mi (8,000 km)
or six months

Inspect and lubricate U-joints.

Rotate the tires

1

and inspect them for wear, and measure

the tread depth.

Every 7,500 mi (12,000 km)

Replace the spark plugs.

Every 60,000 mi
(96,000 km)

Replace the spark plug wires.

1

Rotate the front wheels on vehicles with dual rear wheels when specified. Only rotate

the rear wheels if you notice unusual wear.

Extensive Idling or Low-speed Driving for Long Distances, as in Heavy Commercial Use

(Such as Delivery, Taxi, Patrol Car or Livery)

Replace engine air filter.

Inspect frequently, service
as required

Inspect the brake system.

Every 5,000 mi (8,000 km)

Inspect the wheels and related components for abnormal
noise, wear, looseness or drag.

Lubricate the control arm and steering ball joints if
equipped with grease fittings.

Inspect and lubricate U-joints.

Every 5,000 mi (8,000 km)
or six months

329

Scheduled Maintenance

Extensive Idling or Low-speed Driving for Long Distances, as in Heavy Commercial Use

(Such as Delivery, Taxi, Patrol Car or Livery)

Change the engine oil and filter.

Every 5,000 mi (8,000 km),
six months or 200 engine
hours

Rotate the tires

1

and inspect them for wear, and measure

the tread depth.

Every 7,500 mi (12,000 km)

Replace the spark plugs.

Every 60,000 mi
(96,000 km)

1

Rotate the front wheels on vehicles with dual rear wheels when specified. Only rotate

the rear wheels if you notice unusual wear.

Operating in Dusty or Sandy Conditions (Such as Unpaved or Dusty Roads)

Replace the engine air filter.

Inspect frequently, service
as required

Inspect the wheels and related components for abnormal
noise, wear, looseness or drag.

Every 5,000 mi (8,000 km)

Change the engine oil and filter.

Every 5,000 mi (8,000 km)
or six months

Inspect and lubricate U-joints.

Rotate the tires

1

and inspect them for wear, and measure

the tread depth.

Every 7,500 mi (12,000 km)

1

Rotate the front wheels on vehicles with dual rear wheels when specified. Only rotate

the rear wheels if you notice unusual wear.

Off-road Operation

Inspect the steering linkage, ball joints and U-joints,
lubricate if equipped with grease fittings.

Inspect frequently, service
as required

Replace the engine air filter.

Change the engine oil and filter.

Every 5,000 mi (8,000 km)
or six months

330

Scheduled Maintenance

Off-road Operation

Inspect the wheels and related components for abnormal
noise, wear, looseness or drag.

Rotate the tires

1

and inspect them for wear, and measure

the tread depth.

Every 7,500 mi (12,000 km)

1

Rotate the front wheels on vehicles with dual rear wheels when specified. Only rotate

the rear wheels if you notice unusual wear.

Diesel Engine

If you operate your vehicle

primarily

in any

of the following conditions, you need to
perform extra maintenance as indicated.
If you operate your vehicle

occasionally

under any of these conditions, it is not
necessary to perform the extra
maintenance. For specific
recommendations, see your dealership
service advisor or technician.

Towing a Trailer or Using a Car-top Carrier

Change the engine oil and filter as indicated by the
information display, and perform the services listed in the
scheduled maintenance chart.

As required

See the axle maintenance items under

Exceptions

.

Replace the engine-mounted and frame-mounted fuel
filters.

Every 15,000 mi
(24,000 km) or six months,
600 engine hours

Flush and refill the coolant.

At 60,000 mi (96,000 km)
or 2400 engine hours

Note:

After the initial coolant flush and fill at 60,000 mi (96,000 km) or 2400 engine

hours, flush and fill every 45,000 mi (72,000 km) or 1800 engine hours thereafter.

331

Scheduled Maintenance

Frequent or Extended Idling, Over 10 Minutes Per Hour of Normal Driving or Frequent

Low-speed Operation if You Use Your Vehicle for Stationary Operation

Change the engine oil and filter as indicated by the
information display, and perform the services listed in the
scheduled maintenance chart.

As required

Replace the engine-mounted and frame-mounted fuel
filters.

Every 15,000 mi
(24,000 km), six months or
600 engine hours

Inspect the coolant concentration, freeze-point protection
and additive, corrosion inhibitor strength. Add coolant
additive if necessary.

Every 30,000 mi
(48,000 km) or 1200 engine
hours

Flush and refill the coolant. Do not add coolant additive.

Every 60,000 mi
(96,000 km) or 2400
engine hours

Note:

When adding coolant additive, do not exceed the specified maximum of 47 fl oz

(1.4 L) for the engine and 20 fl oz (473 ml) for the secondary cooling system. Operating the
engine with excessive coolant additive may cause overheating which could lead to severe,
permanent engine damage.

Note:

After the initial coolant flush and fill at 60,000 mi (96,000 km) or 2400 engine

hours, flush and fill every 45,000 mi (72,000 km) or 1800 engine hours thereafter.

332

Scheduled Maintenance

Frequent Low-speed Operation, Consistent Heavy Traffic Under 25 mph (40 km/h) or

Long Rush-hour Traffic

Change the engine oil and filter as indicated by the
information display, and perform the services listed in the
scheduled maintenance chart.

As required

Replace the engine-mounted and frame-mounted fuel
filters.

Every 15,000 mi
(24,000 km), six months or
600 engine hours

Inspect the coolant concentration, freeze-point protection
and additive, corrosion inhibitor strength. Add coolant
additive if necessary.

Every 30,000 mi
(48,000 km) or 1200 engine
hours

Flush and refill the coolant. Do not add coolant additive.

Every 60,000 mi
(96,000 km) or 2400
engine hours

Note:

When adding coolant additive, do not exceed the specified maximum of 47 fl oz

(1.4 L) for the engine and 20 fl oz (473 ml) for the secondary cooling system. Operating the
engine with excessive coolant additive may cause overheating which could lead to severe,
permanent engine damage.

Note:

After the initial coolant flush and fill at 60,000 mi (96,000 km) or 2400 engine

hours, flush and fill every 45,000 mi (72,000 km) or 1800 engine hours thereafter.

333

Scheduled Maintenance

Sustained High-speed Driving at Gross Vehicle Weight Rating, Maximum Loaded Weight

for Vehicle Operation

Change the engine oil and filter as indicated by the
information display, and perform the services listed in the
scheduled maintenance chart.

As required

Replace the engine-mounted and frame-mounted fuel
filters.

Every 15,000 mi
(24,000 km), six months or
600 engine hours

Inspect the coolant concentration, freeze-point protection
and additive, corrosion inhibitor strength. Add coolant
additive if necessary.

Every 30,000 mi
(48,000 km) or 1200 engine
hours

Flush and refill the coolant. Do not add coolant additive.

Every 60,000 mi
(96,000 km) or 2400
engine hours

Note:

When adding coolant additive, do not exceed the specified maximum of 47 fl oz

(1.4 L) for the engine and 20 fl oz (473 ml) for the secondary cooling system. Operating the
engine with excessive coolant additive may cause overheating which could lead to severe,
permanent engine damage.

Note:

After the initial coolant flush and fill at 60,000 mi (96,000 km) or 2400 engine

hours, flush and fill every 45,000 mi (72,000 km) or 1800 engine hours thereafter.

Operating in Sustained Ambient Temperatures Below -9.4°F (-23°C) or Above 100.3°F

(38°C)

Change the engine oil and filter as indicated by the
information display, and perform the services listed in the
scheduled maintenance chart.

As required

Replace the engine-mounted and frame-mounted fuel
filters.

Every 15,000 mi
(24,000 km), six months or
600 engine hours

Operating in Dusty or Sandy Conditions, Such as Unpaved or Dusty Roads

Rotate the tires

1

, inspect the tires for wear and measure

tread depth.

Every 7,500 mi (12,000 km)

Inspect the brake system pads and rotors.

Inspect the air filter restriction gauge. Replace the filter if
necessary.

334

Scheduled Maintenance

Operating in Dusty or Sandy Conditions, Such as Unpaved or Dusty Roads

Inspect the steering and suspension ball joints and tie rods.
Lubricate any grease fittings.

Change the engine oil and filter.

2

Every 7,500 mi (12,000 km),
six months or 300 engine
hours

Inspect and lubricate the U-joints.

Replace the engine-mounted and frame-mounted fuel
filters.

Every 15,000 mi
(24,000 km), 6 months or
600 engine hours

Replace the air inlet foam filter.

Every 30,000 mi
(48,000 km)

1

Rotate the front wheels on vehicles with dual rear wheels when specified. Only rotate

the rear wheels if you notice unusual wear.

2

Reset the Intelligent Oil-Life Monitor after engine oil and filter changes.

Off-road Operation

Inspect functional holes in each leg of the twin exhaust
tips and the holes under the shield just inboard of the right
rear tire to make sure they are clean and clear of debris or
foreign materials. Refer to the Vehicle Care chapter of your
owner’s manual for more information.

As required

Inspect the steering and suspension ball joints and tie rods.
Lubricate any grease fittings.

Rotate the tires

1

, inspect the tires for wear and measure

tread depth.

Every 7,500 mi (12,000 km),
six months or 300 engine
hours

Inspect the brake system pads and rotors.

Inspect the air filter restriction gauge. Replace the filter if
necessary.

Change the engine oil and filter.

2

Every 7,000 mi (12,000 km)
or 300 engine hours

335

Scheduled Maintenance

Off-road Operation

Replace the engine-mounted and frame-mounted fuel
filters.

Every 15,000 mi
(24,000 km), six months or
600 engine hours

Replace the air inlet foam filter.

Every 30,000 mi
(48,000 km)

1

Rotate the front wheels on vehicles with dual rear wheels when specified. Only rotate

the rear wheels if you notice unusual wear.

2

Reset the Intelligent Oil-Life Monitor after engine oil and filter changes.

Using Biodiesel, up to and Including 20% Biodiesel (B20)

Change the engine oil and filter as indicated by the
information display, and perform the services listed in the
scheduled maintenance chart.

As required

Replace the engine-mounted and frame-mounted fuel
filters.

Every 15,000 mi
(24,000 km), six months or
300 engine hours

Using Fuel Other Than Ultra-low Sulfur Diesel Fuel - Vehicles Operated Where Ultra-low

Sulfur Diesel Fuel is not Required or Available

Change the engine oil and filter.

Every 2,500 mi (4,000 km)
or three months (if using
high sulfur fuel with more
than 500 ppm sulfur)

Change the engine oil and filter.

Every 5,000 mi (8,000 km)
or six months (if using high
sulfur fuel with fewer than
500 ppm sulfur)

Exceptions

There are several exceptions to the Normal
Schedule:

336

Scheduled Maintenance

Rear Axle Maintenance

A rear axle fluid change or level check is
not required unless you suspect a leak or
the assembly has been submerged in
water. During long periods of trailer towing
with outside temperatures above 70°F
(21°C), and at wide-open throttle for long
periods above 45 mph (72 km/h), change
the rear axle fluid every 24,000 mi
(38,000 km) or three months, whichever
comes first.

California Fuel Filter Replacement

If you register your vehicle in California, the
California Air Resources Board has
determined that the failure to perform this
maintenance item does not nullify the
emission warranty or limit recall liability
before the completion of your vehicle's
useful life. We, however, urge you to have
all recommended maintenance services
performed at the specified intervals and
to record all vehicle service.

Hot Climate Oil Change Intervals

The normal oil change interval is 3,000 mi
(5,000 km) for gasoline vehicles operating
in the Middle East, North Africa,
Sub-Saharan Africa or locations with
similar climates using American Petroleum
Institute (API) oils Certified for Gasoline
Engines and displaying the API Certification
Mark. If API Certified Oils are not available,
then it is acceptable to use API SM or SN
oils. If API oils are not available, then the
oil change interval is 1,750 mi (3,000 km).

Engine Air Filter Replacement

The life of the engine air filter is dependent
on exposure to dusty and dirty conditions.
Vehicles operated in these conditions
require frequent inspection and
replacement of the engine air filter and
cabin air filter.

Diesel Particulate Filter

Over time, a slight amount of ash builds
up in the diesel particulate filter, which is
not removed during the regeneration
process. The filter may need to be replaced
with a new or remanufactured part at
approximately 250,000 mi (400,000 km).
Actual mileage varies depending on engine
and vehicle operating conditions.

In this case, the engine control system sets
a service light (wrench icon) to inform you
to bring your vehicle to the dealer for
service. If there are any issues with the
oxidation catalyst or particulate filter
system, a service light (wrench or engine
icon) sets by the engine control system to
inform you to bring your vehicle into a
dealer for service.

337

Scheduled Maintenance

ELECTROMAGNETIC
COMPATIBILITY

WARNING:

Do not place objects

or mount equipment on or near the
airbag cover, on the side of the front or
rear seatbacks, or in areas that may
come into contact with a deploying
airbag. Failure to follow these
instructions may increase the risk of
personal injury in the event of a crash.

WARNING:

Do not fasten antenna

cables to vehicle wiring, fuel pipes and
brake pipes.

WARNING:

Keep antenna and

power cables at least 4 in (10 cm) from
any electronic modules and airbags.

Note:

We test and certify your vehicle to

meet electromagnetic compatibility
legislation. It is your responsibility to make
sure that any equipment an authorized
dealer installs on your vehicle complies with
applicable local legislation and other
requirements. Installation of some
aftermarket electronic devices could
degrade the performance of vehicle
functions, which use radio frequency signals
such as broadcast radio receiver, tire
pressure monitoring system, push button
start,

Bluetooth®

connectivity or satellite

navigation.

Note:

Any radio frequency transmitter

equipment in your vehicle (such as cellular
telephones and amateur radio transmitters)
must keep to the parameters in the
following illustrations and table. We do not
provide any other special provisions or
conditions for installations or use.

Car/SUV

E239120

343

Appendices

Van

E239122

Truck

E239121

344

Appendices

Antenna Positions

Maximum Output Power Watt

(Peak RMS)

Frequency Band

MHz

1

50

1-30

2, 3

50

50-54

2, 3

50

68-88

2, 3

50

142-176

2, 3

50

380-512

2, 3

10

806-870

345

Appendices

END USER LICENSE
AGREEMENT

SYNC End User License Agreement
(EULA)

•

You have acquired a device ("DEVICE")
that includes software licensed by Ford
Motor Company and its affiliates
("FORD MOTOR COMPANY") from an
affiliate of Microsoft Corporation
("MS") . Those installed software
products of MS origin, as well as
associated media, printed materials,
and "online" or electronic
documentation ("MS SOFTWARE")
are protected by international
intellectual property laws and treaties.
The MS SOFTWARE is licensed, not
sold. All rights reserved.

•

The MS SOFTWARE may interface with
and/or communicate with, or may be
later upgraded to interface with and/or
communicate with additional software
and/or systems provided by FORD
MOTOR COMPANY. The additional
software and systems of FORD
MOTOR COMPANY origin, as well as
associated media, printed materials,
and "online" or electronic
documentation ("FORD SOFTWARE")
are protected by international
intellectual property laws and treaties.
The FORD SOFTWARE is licensed, not
sold. All rights reserved.

•

The MS SOFTWARE and/or FORD
SOFTWARE may interface with and/or
communicate with, or may be later
upgraded to interface with and/or
communicate with additional software
and/or systems provided by third party
software and service suppliers. The
additional software and services of
third party origin, as well as associated
media, printed materials, and "online"
or electronic documentation ("THIRD
PARTY SOFTWARE") are protected by
international intellectual property laws
and treaties. The THIRD PARTY
SOFTWARE is licensed, not sold. All
rights reserved.

•

The MS SOFTWARE, FORD
SOFTWARE and THIRD PARTY
SOFTWARE hereinafter collectively
and individually will be referred to as
"SOFTWARE".

IF YOU DO NOT AGREE TO THIS END
USER LICENSE AGREEMENT ("EULA")
DO NOT USE THE DEVICE OR COPY
THE SOFTWARE. ANY USE OF THE
SOFTWARE, INCLUDING BUT NOT
LIMITED TO USE ON THE DEVICE, WILL
CONSTITUTE YOUR AGREEMENT TO
THIS EULA (OR RATIFICATION OF ANY
PREVIOUS CONSENT).

GRANT OF SOFTWARE LICENSE:

This

EULA grants you the following license:

•

You may use the SOFTWARE as
installed on the DEVICE and as
otherwise interfacing with systems
and/or services provide by or through
FORD MOTOR COMPANY or its third
party software and service providers.

346

Appendices

Description of Other Rights and
Limitations

•

Speech Recognition:

If the

SOFTWARE includes speech
recognition component(s), you should
understand that speech recognition is
an inherently statistical process and
that recognition errors are inherent in
the process. Neither FORD MOTOR
COMPANY nor its suppliers shall be
liable for any damages arising out of
errors in the speech recognition
process.

•

Limitations on Reverse Engineering,
Decompilation and Disassembly:

You may not reverse engineer,
decompile, or disassemble nor permit
others to reverse engineer, decompile
or disassemble the SOFTWARE, except
and only to the extent that such activity
is expressly permitted by applicable
law notwithstanding this limitation.

•

Limitations on Distributing,
Copying, Modifying and Creating
Derivative Works:

You may not

distribute, copy, make modifications
to or create derivative works based on
the SOFTWARE, except and only to the
extent that such activity is expressly
permitted by applicable law
notwithstanding this limitation.

•

Single EULA:

The end user

documentation for the DEVICE and
related systems and services may
contain multiple EULAs, such as
multiple translations and/or multiple
media versions (e.g., in the user
documentation and in the software).
Even if you receive multiple EULAs, you
are licensed to use only one (1) copy of
the SOFTWARE.

•

SOFTWARE Transfer:

You may

permanently transfer your rights under
this EULA only as part of a sale or
transfer of the DEVICE, provided you
retain no copies, you transfer all of the
SOFTWARE (including all component
parts, the media and printed materials,
any upgrades, and, if applicable, the
Certificate(s) of Authenticity), and the
recipient agrees to the terms of this
EULA. If the SOFTWARE is an upgrade,
any transfer must include all prior
versions of the SOFTWARE.

•

Termination:

Without prejudice to any

other rights, FORD MOTOR COMPANY
or MS may terminate this EULA if you
fail to comply with the terms and
conditions of this EULA.

•

Security Updates/Digital Rights
Management:

Content owners use

the WMDRM technology included in
your DEVICE to protect their
intellectual property, included
copyrighted content. Portions of the
SOFTWARE on your DEVICE use
WMDRM software to access
WMDRM-protected content. If the
WMDRM software fails to protect the
content, content owners may ask
Microsoft to revoke the SOFTWARE's
ability to use WMDRM to play or copy
protected content. This action does
not affect unprotected content. When
your DEVICE downloads licenses for
protected content, you agree that
Microsoft may include a revocation list
with the licenses. Content owners may
require you to upgrade the SOFTWARE
on your DEVICE to access their content.
If you decline an upgrade, you will not
be able to access content that requires
the upgrade.

347

Appendices

•

Consent to Use of Data:

You agree

that MS, Microsoft Corporation, FORD
MOTOR COMPANY, third party
software and systems suppliers, their
affiliates and/or their designated agent
may collect and use technical
information gathered in any manner as
part of product support services related
to the SOFTWARE or related services.
MS, Microsoft Corporation, FORD
MOTOR COMPANY, third party
software and services suppliers, their
affiliates and/or their designated agent
may use this information solely to
improve their products or to provide
customized services or technologies to
you. MS, Microsoft Corporation, FORD
MOTOR COMPANY, third party
software and systems suppliers, their
affiliates and/or their designated agent
may disclose this information to others,
but not in a form that personally
identifies you.

•

Internet-Based Services
Components:

The SOFTWARE may

contain components that enable and
facilitate the use of certain
Internet-based services. You
acknowledge and agree that MS,
Microsoft Corporation, FORD MOTOR
COMPANY, third party software and
service suppliers, their affiliates and/or
their designated agent may
automatically check the version of the
SOFTWARE and/or its components
that you are utilizing and may provide
upgrades or supplements to the
SOFTWARE that may be automatically
downloaded to your DEVICE.

•

Additional Software/Services:

The

SOFTWARE may permit FORD MOTOR
COMPANY, third party software and
service suppliers, MS, Microsoft
Corporation, their affiliates and/or their
designated agent to provide or make
available to you SOFTWARE updates,

supplements, add-on components, or
Internet-based services components
of the SOFTWARE after the date you
obtain your initial copy of the
SOFTWARE ("Supplemental
Components").

If FORD MOTOR COMPANY or third party
software and services suppliers provide or
make available to you Supplemental
Components and no other EULA terms are
provided along with the Supplemental
Components, then the terms of this EULA
shall apply.

If MS, Microsoft Corporation, their affiliates
and/or their designated agent make
available Supplemental Components, and
no other EULA terms are provided, then
the terms of this EULA shall apply, except
that the MS, Microsoft Corporation or
affiliate entity providing the Supplemental
Component(s) shall be the licensor of the
Supplemental Component(s).

FORD MOTOR COMPANY, MS, Microsoft
Corporation, their affiliates and/or their
designated agent reserve the right to
discontinue without liability any
Internet-based services provided to you or
made available to you through the use of
the SOFTWARE.

348

Appendices