Chery Tiggo 5 (T21). Manual — part 476
43–
84
43
Circuit Diagram
Rear Window Defroster System
ET21430040
F1 F2 F3
F8 F9 F10
F11 F12 F13 F14
F15 F16 F17 F18
F4
F5 F6
F7
E20
E19
E18
E17
E12
E11
E10
E9
E4
E3
E2
E1
E8
E7
E6
E5
E16
E15
E14
E13
22 21 20
18
19
17 16 15
13
14
12 11 10
8
9
7
6
5
3
4
2
1
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20
21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40
1
9 10
11
12
13
14 15
2
3
4
5
6
7
8
1
1
BATTERY
DEFOGER
RELAY
RRLY02
85
30
86
87
RF33
25A
IGNITION SEITCH
ON OR ACC
RF13
7.5A
A32
A31
A30
A29
A28
A16
A15
A14
A13
A12
A11
A10
A9
A8
A7
A6
A5
A4
A3
A2
A1
A27
A26
A25
A24
A23
A22
A21
A20
A19
A18
A17
RW
WV
BG
BCM
B
BrW
DEFOGGER
SWITCH
DEFROSTER
NEGATIVE
24
4
MT
CVT
A21
A12
E4
F13
HVAC
CONTROL
PANEL
8
10
1
1
R
R
B
B
1
13
INSTRUMENT
PANEL FUSE
AND RELAY
BOX B
I-031
I-037
I-039
K-007
I-005
B-060
B-012
T-004
B-012
B-017
T-004
T-002
T-010
W
B-060
W
I-031
L
I-005
W
B-012
11
B
T-002
B
T-010
B
I-039
K-002
K-012
W
K-002
W
K-012
43–
85
43
Problem Symptoms Table
HINT:
Use the table below to help determine the cause of problem symptoms. Check each suspected area in
sequence. Repair or replace the faulty components, or adjust as necessary.
Symptom
Suspected Area
See page
Rear window defogger switch is turned on
but does not operate (indicator on)
Fuse
Rear window defogger switch
-
Rear window defogger wire
-
Wire harness or connector
-
Rear window defogger switch is turned on
but does not operate (indicator off)
Fuse
Rear window defogger switch
-
Wire harness or connector
-
Rear window defogger have intermittent
problem
Ground
-
Wire harness or connector
-
43–
86
43
Rear Window Defogger Switch
Removal
HINT:
Rear window defogger switch is installed on A/C control panel assembly, and cannot be disassembled.
1. Turn off all the electrical equipment and ignition switch.
2. Disconnect the negative battery cable.
3. Remove the DVD panel assembly.
a. Using a screwdriver wrapped with protective tape, pry
up the clips on DVD panel assembly.
b. Disconnect the connectors (arrow) from DVD panel
assembly, and remove the DVD panel assembly.
CAUTION
Make sure to wear safety equipment to prevent accidents when removing rear window defogger switch.
Appropriate force should be applied when removing rear window defogger switch. Be careful not to
operate roughly.
Try to prevent interior from being scratched when removing rear window defogger switch.
RT21430500
1
2
3
0
20
40
60
80
ON
OFF
RT21430510
43–
87
43
4. Remove the A/C control panel
a. Remove 2 fixing screws (arrow) from A/C control panel.
(Tightening torque: 2 ± 0.5 N·m)
b. Using a screwdriver wrapped with protective tape, pry
up the clips on A/C control panel.
c. Disconnect the connector (arrow) from A/C control
panel, and remove the A/C control panel.
Installation
Installation is in the reverse order of removal.
RT21430520
RT21430530
CAUTION
Install connectors in place when installing rear window defogger switch.
Always operate carefully to prevent components from being damaged when installing rear window
defogger switch.
Check rear window defogger switch for proper operation after installation.
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст